Steering. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

15 crash reports7 fire reports18 injury reports

What owners actually said

245 reports

Mileage unknown · Apr 23, 2003

Power Train

WHILE DRIVING ABOUT 65 MPH VEHICLE DOWN SHIFTED. IT WAS LATER DETERMINED THAT THE TRANSMISSION CONTROL MODULE FAILED. *NLM

NHTSA ODI #10017477

Mileage unknown · Apr 10, 2003

Seat Belts

THE SEAT BELT FAILED TO RELEASE, WHEN THE VEHICLE WAS TURNED OFF. *JB

NHTSA ODI #10015626

6,720 miles · Mar 10, 2003

Visibility

Read full complaint

MY 2003 TOWN AND COUNTRY LIMITED MINIVAN RECENTLY HAD A WINDOW BLOW OUT ON THE PASSENGER SLIDING DOOR. THE INCIDENT HAPPENED WHILE DRIVING DOWN THE HIGHWAY AND RESEMBLED A TEAR ABOUT A THIRD OF THE WAY UP THE WINDOW. IT DID NOT RESEMBLE AN EXTERNAL DAMAGE SIGHT AND SEEMED TO LOOK AS IF THE WINDOW RIPPED OPEN FOR SOME REASON. THE INITIAL 'TEAR' WAS ABOUT A FOOT LONG AND EXPANDED THROUGH OUT THE ENTIRE WINDOW FROM THERE. I WAS QUICKLY REFERRED TO MY INSURANCE CARRIER BY THE DEALERSHIP. I WAS ON MY WAY THERE AND WAS LESS THEN A MILE FROM THEM WHEN THIS OCCURRED.*JB

NHTSA ODI #10010205

Mileage unknown · Dec 26, 2002

Visibility

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEM WITH THE VEHICLE VISIBILITY SUN SCREEN, FROM THE WINDSHIELD DO NOT PROTECT HIS EYE VISION, AND HIS AFRAID TO HAVE AN ACCIDENT. DEALER HAS BEEN NOTIFIED NOTHING THEY CAN DO. PLEASE PROVIDE FURTHER INFORMATION. TS

NHTSA ODI #10001525

Mileage unknown · Nov 21, 2002

Exterior Lighting

Read full complaint

WE PURCHASED A NEW VEHICLE ASSUMING THAT THE LIGHTS WOULD BE AT LEAST THE SAME AS PREVIOUS VEHICLES. UPON TAKING THE VAN HOME AND DRIVING IT AT NIGHT. WE NOTED THAT THE DASH AND DOOR SWITCH LIGHTS WEREN'T FUNCTIONING. WE WENT BACK TO THE DEALERSHIP AND LOOKED AT ANOTHER VAN (ASSUMING THAT IT WAS A 2003) ON WHICH THE LIGHTS DID WORK. WE TOOK THE VAN IN TO THE SERVICE PERSONNEL TO HAVE THE LIGHTS REPAIRED, BUT THEY TOLD US THAT THESE LIGHTS WERE NO LONGER FUNCTIONAL ON THE 2003 VANS. WE HAVE NOTIFIED THE DEALERSHIP OWNER AND CHRYSLER'S TELEPHONE COMPLAINT LINE ABOUT THIS. THE ANSWER TO OUR COMPLAINT HAS BEEN THAT CHRYSLER "DECOMMISSIONED" THE LIGHT FUNCTION FOR COST SAVINGS. I CONSIDER THIS A CONVENIENCE AND SAFETY CONCERN, SINCE YOU MUST FUMBLE AROUND IN THE DARK TO FIND THE SWITCHES OR TO TURN ON THE VEHICLE LIGHTS. DT

NHTSA ODI #769989

Official recalls

05V134000 · Latches/locks/linkages:hatchback/liftgate:lock

Apr 6, 2005

ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, AN UNBELTED PASSENGER COULD BE EJECTED FROM THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE POWER LIFTGATE CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN APRIL 26, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Aug 5, 2004

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence & remedy

Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP14002 · Engine Stall After Refueling

Opened Sep 5, 2014 · Closed Apr 6, 2015

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300

EA04031 · Power Liftgate Latch

Opened Nov 22, 2004 · Closed Apr 7, 2005

Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch

THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.

Additional source detail variants (2)

Latches/locks/linkages

Latches/locks/linkages:tailgate:latch

PE04054 · Power Liftgate Latch

Opened Jul 30, 2004 · Closed Nov 22, 2004

Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:hatchback/liftgate:lock

THIS INVESTIGATION WAS OPENED ON JULY 30, 2004, BASED ON ODI CONSUMER COMPLAINTS ALLEGING UNWANTED OPENING OF THE VEHICLE'S POWER LIFTGATE (PLG) WHILE DRIVING.IN DAIMLERCHRYSLER CORPORATION (DCC)'S SEPTEMBER 17, 2004 RESPONSE TO ODI' S INFORMATION REQUEST LETTER, IT PROVIDED ADDITIONAL CONSUMER COMPLAINTS AND LAWSUITS.DCC STATES IN PART, ...THE PLG LATCH BECOMES STUCK IN A SEMI-CLOSED STATE NOT ALLOWING THE PLG LATCH TO ENGAGE THE STRIKER, THUS NOT CLOSING THE LIFTGATE COMPLETELY.IN THIS CONDITION THE PLG AJAR WARNING LIGHT WILL NOT BE ILLUMINATED AND THE PLG CAN RISE (NOT A POWERED OPEN) WHILE DRIVING. THIS INVESTIGATION HAS BEEN UPGRADED TO EA04-031 FOR FURTHER ANALYSIS.

Additional source detail variants (2)

Latches/locks/linkages

Latches/locks/linkages:hatchback/liftgate:lock