2021 Chrysler Pacifica

I purchased my vehicle from AutoNation Chrysler Dodge Jeep RAM Spring - 21027 I-45, Spring, TX 77388 on or about April 15, 2021. I began having trouble with the electric/gas drivetrain around January 30 of 2023. The vehicle lost all power, as well as throttle and proper braking response. I brought my vehicle back to Helfman Dodge Chrysler Jeep RAM FIAT at 7720 Katy Fwy A, Houston, TX 77024 for repairs on February 6, 2023. The repairs performed seemed to have worked until [XXX]. The most recent event on [XXX] my Pacifica Hybrid lost all power on the highway. While attempting to pull the vehicle off of the highway it abruptly entered its parking gear at 5mph, almost causing a rear end collision from the semi tractor trailer following behind us. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am having a problem with my under-warranty (32,000 miles) 2021 Chrysler Pacifica which the service department at my dealership appears unable to help. I was driving on an interstate in stop-and-go traffic for a couple of hours. It was a very hot day, temperatures well above 90 degrees. Six times over 15 minutes the following occurred: While coasting/braking, so at low RPM the engine turned itself off I braked to stop the vehicle The vehicle put itself into Park A message on the dash said to place my foot on the brake pedal and press the button to start the engine I did so, and the engine cranked for an unusually long time, becoming longer each of the 6 times, before eventually starting By the last time we were doubtful it would start at all After the 6th time I cut my long-distance trip short, turned around, and came home in normal (not stop-and-go) highway traffic conditions, with no more engine failure. The check engine light did not turn on, and no service codes were generated which could have been related to these power failures My local dealer's service department (Pohanka in Salisbury, MD) tested the alternator, starter, and battery and found nothing wrong. They did charge the battery up a bit, saying it took only 20 minutes. They have been unable to re-create the problem, which is not surprising, due to the unique conditions under which it happened. They say there is nothing they can do about my problem under warranty because there is no code and they can't reproduce the problem, so they want to give me back a vehicle that we know behaved unsafely six times under dangerous conditions. Engines failing without warning on interstates are likely to result in being rear-ended. I see online that the hybrid model of the same model year has a recall for exactly this same issue, so it is not a new issue for Chrysler, although maybe new-ish for my non-hybrid model of the same vehicle.

Van has 70K miles. After a long road trip. last stop noticed a gas smell from the front of van. When opening the hood noticed gas had been leaking over top of the motor by spraying fuel. Moving the fuel line running over the top of the motor, showed it was rubbing against top of the coil pack on engine. The rubbing over time caused a small cut in the fuel line allowing for fuel leak. The fuel line seam to be malformed or is unsported causing the rubbing.

Driving the vehicle on the interstate, and the vehicle suddenly lost power and had a warning that said "Stop Safely, Vehicle will shut off soon". However, we were in a construction zone and unable to stop on the interstate causing many vehicles to nearly crash into us. I understand we had previously had a recall worked that simply added this warning, but did not fix the issue. This warning is not a safe solution. It is still very dangerous for your vehicle to suddenly drop to 15mph at highway speeds. We are in the process of having the dealer confirm the issue.

While driving from Texas to Wisconsin our van powered down twice while at freeway speeds in traffic. We had 6 people in the van and were lucky to safely reach the should each time it happened. Transmission was replaced 2 years ago to correct this issue and it returned. Van was recently at dealership in Texas for inspection and work and found no reason to fix recall issues that are now being stated to have needed to be fixed.

Traveling down [XXX] in Escondido at approximately 73mph. In the fast lane and moving left into the car pool lane the vehicle lost all motive power and the error "Service Charging System" came up on the dash then flashing back to "SHIFT TO P TO START". We were able to make it to a very small emergency lane on the left side of the interstate. Had to power vehicle off and restart twice before be regained motive power. There was a very good chance that we would have been stranded in the middle of the interstate with wife and 2 kids in the care on an 85 degree day. We were able to make it off freeway with "Check engine light showing" but no other errors on the dash. We were able to drive home 7 miles and will tow the Pacifica to the dealer tomorrow. This is the second time this has happened and could have had a horrible outcome. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The forward collision alarm was triggered when there was no collision. Additionally the ABS system and cruise control went offline. This occurred numerous times during winter while at a full stop as well as when driving between 45-55mph. Once triggered the collision alarm remained on for hours to days at a time. During that time cruise control was not able to be used and ABS was offline. Additionally the assisted parking was not available. ABS and stability control is important for safe driving and braking in icy/slippery situations putting both my own, my passengers, and other drivers at risk. The vehicle was inspected 4 times by the Bath NY Chrysler dealership. A sensor was replaced the first time but this did not correct the issue. The 2nd time another component was replaced, but the technician stated the issue was still present and I would need to bring it back in for further testing. The 3rd and 4th time the dealership was not able to recreate the issue and did not perform any repairs. The issue has recurred, but the dealership was not able to get the car in at that time. This vehicle has not been inspected by manufacturer, police, insurance etc. There was no prior warning to the issue. When it occurs the warning lamps that come on are: BRAKE, Front Collision, Front Collision OFF, ABS, Seatbelt, and the Traction Control. I have a photo of the dash from one of these incidents.

The engine stopped responding in a safe manner and we were not able to maintain safe speeds along a highway. While traveling on the highway in a busy, high-speed merge area at night, I received a warning "Stop Safely Vehicle Will Shut Off Soon." I was far from a safe pull off location along a highway with sound barriers on all sides and no way to walk away from the highway. I made my way to the shoulder. Seeing that I was not in a safe location for me and the other car passengers, I drove very slowly with my hazards on until I could exit the highway. There was not a safe shoulder available for much of the distance and the car was unable to go faster than about 30 miles per hour at its peak. This max speed dropped gradually to close to 10 mph. The engine barely responded and I struggled to make a turn onto a residential street without a collision with oncoming traffic. Once were in a safe location, I turned the car off and back on again and the same warning light appeared and the engine was similarly limited to moving the car at about 10 mph max. I have not had the car towed to a dealer yet for inspection.

While driving at full speed on an interstate, I received the message, "Stop Safely, Vehicle Will Shut Off Soon." The van then lost power, and I was able to pull over safely (thankfully!). After about 15 minutes, the van restarted, and I made it about 10 miles until it happened again. After two more shut-downs, I was able to get the van to a dealership, where it has been sitting undiagnosed for over a week now.