2021 Chrysler Pacifica

My vehicle has open Safety Recall 66B. My radio, navigation, and touchscreen worked normally until a recent dealership service that included a 12-volt battery replacement and high-voltage battery recall service. Immediately after I picked up the vehicle, the touchscreen developed a “ghost-touch” issue and began operating by itself. The dealership stated in writing that Recall 66B may address the issue, but that they have previously experienced radios locking up and becoming unusable while performing the recall software update. They stated that this was the reason they intentionally did not perform Recall 66B during my initial service visit. I asked the dealership to confirm with Stellantis or management who would be responsible if the radio became unusable while performing the safety recall. The dealership later told me that they had spoken with their manager and confirmed that if the recall caused the radio to lock up, replacement would be my financial responsibility because the vehicle is out of warranty. I am NOT declining Recall 66B. I want the safety recall completed. However, I do not believe I should be required to assume the financial risk of the radio becoming unusable as a result of the recall procedure itself. I am asking NHTSA to review this situation and the dealership’s handling of Safety Recall 66B.

I am reporting a critical manufacturer-imposed restriction that prevents the completion of a life-saving safety campaign, Recall 52D (NHTSA ID: 24V362), which carries a strict "Park Outside and Do Not Charge" advisory.My vehicle has an active fault code P0E15 (Electric Coolant Heater control performance), which is a well-known, widespread factory defect in Chrysler Pacifica Hybrids. When I took the vehicle to an authorized Stellantis/Chrysler dealership to perform the urgent 52D safety flash, the dealer officially refused to perform the recall. They stated that the manufacturer's diagnostic software (wiTECH) completely blocks the 52D software update from being uploaded if the P0E15 fault is present.I contacted FCA US Customer Care (Case Number: 97720299), and they officially replied that they will not issue a corporate override for their diagnostic software. They are conditioning the execution of a critical fire-safety recall on me privately paying for the repair of a separate known manufacturer defect (P0E15 heater), due to the vehicle's export status.This is a severe threat to public safety and an unacceptable corporate practice. A manufacturer should not be allowed to design diagnostic tools that block critical, life-saving safety recalls due to other unrelated factory defects, effectively forcing owners to drive potential fire hazards unless they pay for commercial repairs. I request NHTSA to investigate FCA US's refusal to deploy safety updates on vehicles with active P0E15 codes.

I brought my vehicle to the dealer for safety recall 52D more than three weeks ago. They will not return the vehicle to me because they say the battery can explode. They have not offered enough money to cover the base model rental car. (I have since rented a slightly better car at my own expense. The allowance would not have covered the cheapest car, though.) No parts have been ordered. The dealer is not returning phone calls to Chrysler customer care. The dealer claims Chrysler technicians won't return their calls. No timeline for repair has been made. I do not believe they intend to return or repair my vehicle.

The contact owns a 2021 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 26V362000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, and the vehicle remained at the dealer for over 5 weeks, and the battery was disconnected. The manufacturer had not yet provided a battery for the replacement. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

We took our 2021 Pacifica Hybrid to the dealership for Recall 52D. The first charge at home after the recall melted one of the charging "pins" in the car, and on our home Level 2 charger. Our dealership now says it's the fault of our charger, and we'll have to pay $2000+ for a repair. Our charger handle is still fine, no damage, only the "pin" is melted. For safety reasons, we can't charge the vehicle, and aren't driving it, as it's still at the dealership.

This 2021 Chrysler Pacifica Hybrid has a severe and recurring history of catastrophic high-voltage hybrid powertrain and transmission failures that cause a sudden loss of motive power while driving, presenting an immediate safety hazard. The vehicle has already required two full automatic transmission (eFlite EVT) replacements under factory warranty due to internal failures. It has experienced multiple high-voltage component repairs, including software modules for the power inverter. The vehicle is currently experiencing a recurring failure and is displaying active diagnostic trouble code P0A78 (Drive Motor "A" Inverter Performance), indicating a critical fault in the high-voltage hybrid propulsion system. Prior to the current failure, the check engine light illuminated, and the vehicle experienced propulsion system degradation. This failure mode risks a sudden shutdown of the hybrid drive system at highway speeds, creating a severe risk of rear-end collisions or being stranded in active traffic. The recurring nature of these transmission and inverter failures indicates a systemic safety defect in the hybrid propulsion system. The issue and the active P0A78 code have been pulled, reproduced, and confirmed by an authorized dealership (Diehl Automotive of Robinson), where the vehicle is currently held and available for inspection. The manufacturer has been notified via an open corporate case (#97399722).

The contact owns a 2021 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 26V362000 (Electrical System); however, the part for the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The dealer stated that the manufacturer had approved the battery pack as a remedy, but the part had not arrived. The contact stated the dealer had the vehicle for a month due to not having the part available, even though the remedy stated that it would be available 2 - 3 days. The manufacturer was made aware of the issue and redirected the contact to locate other dealers who might already have the high-voltage battery for repair in stock. The contact had not experienced a failure.

The High Voltage (HV) Battery System and associated safety isolation circuits failed. Specifically, the vehicle experienced faults with the High Voltage System Interlock Circuit (HVIL), the High Voltage Service Disconnect, and the Hybrid/EV Battery System Precharge circuit. The vehicle is currently located at a manufacturer dealership and is available for inspection. The failure of the high-voltage interlock and precharge circuits compromises the vehicle's electrical isolation safety mechanisms. This poses an immediate risk of a sudden loss of motive power. Additionally, because these faults are rooted in the high-voltage battery system—a system actively under federal scrutiny and manufacturer recalls for thermal runaway—the failure presents a severe risk of spontaneous vehicle fire, endangering occupants, bystanders, and nearby structures. Yes. The failure was initially recorded by an independent diagnostic scan tool, which pulled several confirmed high-voltage fault codes. The vehicle was then taken to a certified manufacturer dealership, where it has been held in the service department for a month. The dealership has confirmed the presence of a severe system failure and initiated repairs costing at least $1800 (with final costs still potentially increasing). Yes. The vehicle is currently in the possession of, and being inspected by, technicians at a certified manufacturer dealership. Yes, the vehicle's onboard diagnostic system detected severe faults and registered the following confirmed trouble codes: * P0B37 - High Voltage Service Disconnect Open * P0C77 - Hybrid/EV Battery System Precharge Time Too Short * P1AE2 - Battery Energy Control Module High Voltage System Interlock Circuit * P0A0A - High Voltage System Interlock Circuit

My 2021 Chrysler Pacifica Hybrid has a recurring hybrid/electrical defect that causes the accelerator to lose all power while driving, leaving the vehicle unable to accelerate or respond to throttle input. The vehicle remains “on,” but it cannot move under its own power and must be coasted or pulled over immediately. This has happened in traffic, including with children in the vehicle. The dealer confirmed fault code P1A21‑00 and documented that the high‑voltage system can lose its loop connection, which results in a no‑propulsion condition. They also found the HVIL high‑voltage connector loose and damaged. The vehicle was in the shop for 18 days for this issue. I picked it up on June 18, 2026, and within 24 hours the same loss‑of‑propulsion failure happened again. The vehicle is now back at the dealer. The dealer performed recall 52D and updated the BPCM software, but the failure still occurred immediately after pickup. This defect has been reproduced and confirmed by the dealership multiple times and remains unresolved. This is a serious safety hazard because the vehicle loses propulsion without warning and cannot accelerate in traffic.