Engine. Review the 373 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports14 fire reports14 injury reports

What owners actually said

869 reports

Mileage unknown · Oct 16, 2024

Engine

Read full complaint

Misfire code on cylinder 1. Pulled the coil and plug and replaced, cleared code. Code returns in a matter of days. Then engine temp hot flashes during a short drive, so I purchase approved OAT coolant and fill it back up. Happens again three weeks later. Then two weeks later. Have local mechanic replace coolant pump and thermostat thinking that might do the trick. It doesn't. Issues return in a week. Mechanic can find no coolant leak and says the only thing that makes sense is a blown head gasket. I browse Chrysler forums and see that this is a common issue. No recall as of yet.

NHTSA ODI #11620219

Mileage unknown · Oct 15, 2024

Power Train

Read full complaint

I left work one day and I stopped at Walmart once I was done there, I got into my car to leave when I attempted to start my car all of the dash board lights illuminated although my car turned over it would not engage into gear. I did notice that all the dashboard lights illuminated simultaneously, which was quite alarming. This happened not once, but twice both times when I went to start the car however the second time I immediately drove it to the dealer for service. This left me concerned about what might be causing the issue. Only for the dealer to tell me it is my transmission and it would cost me $10,000.00 to fix it as a blue collar worker I have absolutely know idea what I am going to do. I then began to research the car only to find out that this year, make & model has a recall on the transmission describing the exact symptoms I am having. Please help!!!!!! my lively hood depends on me being able to get to work!

NHTSA ODI #11619935

Mileage unknown · Oct 14, 2024

Service BrakesSteeringWheels

Read full complaint

While I was driving the right control arm seperated from the car. I was fortunate that I wasn't on the highway, also that I did not cause a collision with another car/person. With no warning the car felt as if it dropped on to the ground. Soon after I received an error message saying to service the brakes which i assume was also damaged when the control arm fell... I had to have the car towed to a repair shop and received a list of repairs. The car is avaliable for inspection. I had no clue how something like that could even happen. Ive been trying to find answers when i saw a recall on another car by the same maker that perfectly summed up what happened to me. Chrysler's number for this recall is V15.

NHTSA ODI #11619720

Mileage unknown · Oct 10, 2024

Engine

Read full complaint

2018 Chrysler Pacifica Touring L+ with 59,300 miles on it that we bought new from the dealer with a blown head gasket needing replacement of cylinders 3 and 4. We are outside the powertrain warranty. We got a check engine light [XXX] and found code p-0303 (cylinder 3 misfire). We were fortunate enough to get it to the dealer the very next day. It failed the engine block test and we were informed that the head gasket had blown and needed replacement. They also recommended replacing cylinders 3 and 4. This cannot be the expected lifespan of this engine or car. Searching forums on the internet and unfortunately it is a common problem with pacifica's and other vehicles with the pentastar 3.6L engine. We are averaging <10,000 miles per year, did not drive it aggressively, and got regular maintenance on it. This seems like obvious premature failure of the engine. Chrysler wanted $8200 for the parts and labor to fix it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11619180

Mileage unknown · Oct 10, 2024

Engine

Read full complaint

In April of 2022 my dash engine check light went on, as well as my start stop. Van was running rough and coolant missing. Chrysler fixed seals, gaskets. In July of 2024, 3000 before warranty ended, the same thing, Chrysler fixed. As of today October 10, 2024, the same dash lights and coolant missing. Now I am over 100,000 warranty. they just fixed this issue. Looking at Technical Service Bulletins and thousands of Chrysler forum complaints report the same issue. Despite two warranty fixes almost 10,00 in 15 months, the same issue continues. In 2024 this past fix Chrysler said this on the phone, Failed leak and combustion test. Cylinder head gasket has gone. Cylinder itself. Cylinder one. Misfire but not as bad. Checking the cylinder wall. Seems odd. Really inspecting the cylinder wall. Odd it would come back odd a year later. Not sure what he is going to find. They can do it tomorrow unless more. When my husband called today all they said was payment is on us of it is not the same thing but did not day to was we did this 3 months ago. I took my van to auto zone after same dash lights went on and they read the code, misfire cylinder one

NHTSA ODI #11619105

Mileage unknown · Oct 7, 2024

SteeringWheels

Been complaining about his front steering key suspension since 2020 about rattling and squeaking whenever customer turn in the wheel

NHTSA ODI #11618389

Mileage unknown · Oct 1, 2024

EnginePower Train

Read full complaint

I have a 2018 Chrysler Pacifica with 50k miles and it is still covered under the powertrain warranty. 1. I had a check engine light with code as "misfire on cylinder 6" in August of 2024. I had all spark plugs and engine coils replaced. 2. I drove the vehicle for one week before the engine light came back on with the same code, and then the vehicle wouldn't start. It was towed to a dealer. 3. A dealer replaced the starter assembly and valve body. 4. I drove the vehicle for 2 days before the engine light came back on with code as misfire to a different cylinder. 5. I am now being told by the dealer that I need to replace both cylinder heads, both cylinder head gaskets, timing cover gaskets, valve cover gaskets, valve cover gaskets and the coil boots (again) because they were ruined the the failure/leaks in the other parts.

NHTSA ODI #11617497

104,417 miles · Oct 1, 2024

Electrical System

Read full complaint

The contact owns a 2018 Chrysler Pacifica. The contact stated while driving approximately 40 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the power steering and braking functionality were inoperable. The contact had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the batteries and the alternator needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V348000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was 104,417.

NHTSA ODI #11617434

Mileage unknown · Sep 28, 2024

EnginePower Train

Read full complaint

The check engine light recently came on, and there was an issue with starting and idling, so we replaced the battery and the light went off, but would randomly come back on. One day notice the vehicle as overheating, and found the coolant tank to be completely empty. Refilled the tank, and several days later the problem arose again. Checked under the van immediately after refilling, no leaks detected. Took van to the dealership and was told the head gasket was bad, and the coolant was leaking into cylinder 3. Recommended repairs noted are as follows: “HEAD GASKET IS BAD. LEAKING ON CYLINDER 3. NEEDS A NEW HEAD AND GASKET TO FIX ISSUE. WILL ALSO NEED CAMS, LIFTERS, AND ROCKERS DUE TO THE TICKING COMING FROM THE RIGHT SIDE OF THE MOTOR” I’ve seen that apparently, this is a more than common issue specifically with the 2018 Chrysler Pacifica. Others have recommended a total engine replacement, as the damage caused thus far is significant enough that replacing only the head and gasket would be, as quoted, “a very expensive bandaid.” This is the only vehicle we have available for my wife and four small kids, and to see that it’s such a common and, thus far ignored problem is infuriating to say the least. Vehicle was purchased 2 years ago, and has depreciated $21,000 in that short amount of time. Repairs are estimated around $6000. Vehicle value is estimated around negative $12,000, so we’re stuck with a faulty vehicle regardless. With the overwhelming number of complaints regarding this issue, almost verbatim, there is absolutely no reason Chrysler should continue to be allowed to let this go unresolved. The fact that the vehicle depreciated so rapidly in such a short time span should be a testament in and of itself to the known and perceived quality of these vehicles, and if ever I can be rid of it, it’ll be that last Chrysler product I ever own.

NHTSA ODI #11617058

Mileage unknown · Sep 27, 2024

Engine

Read full complaint

76,115 and my head gasket is blown. After researching, I found that there are more than over 1000 people with the same issue. Dealership says they can do nothing. Chrysler of America says they have no resolution either. This is ridiculous that so many people are having the issues with low miles on their vans. Something has to be done. I'm not sure why there is not a recall already (because Chrysler won't accept the fact that they messed up). People don't have money to replace the head gaskets and/or replace heads or even engines. Please help.

NHTSA ODI #11616916

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

23V010000 · Electrical System:wiring:connectors/plugs/receptacles; Hybrid Propulsion System: Inverter

Jan 17, 2023

Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

Consequence & remedy

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Additional source detail variants (2)

Electrical System:wiring:connectors/plugs/receptacles

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Hybrid Propulsion System: Inverter

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

19V886000 · Back Over Prevention: Sensing System: Camera; Equipment:electrical:radio/tape Deck/cd Etc.

Dec 12, 2019

Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Equipment:electrical:radio/tape Deck/cd Etc.

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

19V348000 · Electrical SYSTEM:12V/24V/48V Battery

May 9, 2019

Chrysler (FCA US LLC) is recalling certain 2017-2019 Pacifica vehicles equipped with engine stop/start systems. A loose battery ground connection may result in an intermittent loss of power steering assist and/or a stall.

Consequence & remedy

Consequence: A loss of power steering assist or a stall can increase the risk of crash.

Remedy: Chrysler will notify owners, and dealers will inspect the battery ground surfaces, clean the contact surfaces as needed, and properly reassemble the ground connection, free of charge. The recall began May 24, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. FCA US' number for this recall is V53.

19V143000 · Suspension:front:control Arm:lower Arm

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Consequence & remedy

Consequence: A control arm separation could increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V492000 · Power Train:automatic Transmission

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Cherokee vehicles and 2018 Chrysler Pacifica non-hybrid vehicles. A component in the transmission may not have been welded properly, possibly causing the transmission to not transmit engine power to the wheels.

Consequence & remedy

Consequence: If the transmission weld fails, the vehicle will stop moving, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transmission, free of charge. The recall is expected to begin September 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U85.

18V493000 · Power Train:axle Assembly:axle Shaft

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica vehicles. The front axle halfshafts may have been incorrectly assembled, preventing the shaft from being properly secured to the constant-velocity (CV) joint.

Consequence & remedy

Consequence: If the axle shaft disengages from the CV joint, the vehicle will have a loss of drive or allow the vehicle to move while in the "Park" position. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the left or right halfshaft assembly, free of charge. The recall began September 18, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U80.

18V395000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Jun 14, 2018

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."

Consequence & remedy

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Additional source detail variants (2)

EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Electrical System:wiring

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

17V542000 · Seat Belts:rear/other

Aug 31, 2017

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles equipped with the 8-passenger seating option. In certain passenger seating and vehicle situations, the second-row center seating position seat belt buckle could cause the left outboard seat belt to become unlatched.

Consequence & remedy

Consequence: Inadvertent unlatching of the left outboard seat belt can increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will install a shorter second-row seat belt buckle, free of charge. The recall began October 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T54.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE25009 · Intermittent Loss Of Electric Power Steering

Opened Sep 5, 2025 · No close date supplied

Status: open (inferred from source dates) · Steering:electric Power Assist System

The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a sticking sensation during gradual turns, particularly when the steering wheel is positioned near the 11 o'clock or 1 o'clock position. Complainants allege that during these events, increased steering effort is required to return the wheel to center. In many cases, this is followed by a sudden reactivation of EPS assistance, which may result in an oversteer condition. This behavior could increase the risk of a crash, especially at higher speeds. ODI has identified multiple VOQs describing similar symptoms. This investigation will assess the frequency, root cause, and potential safety-related consequences of the alleged EPS malfunction. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.

Opened Feb 27, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:wiring

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.

RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)

Opened Jan 16, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE22008 · Transmission Fault Leading To Loss Of Motive Power

Opened Jul 22, 2022 · Closed Mar 27, 2024

Status: closed (inferred from source dates) · Power Train

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.