NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
155 reportsClear category filterMileage unknown · Feb 9, 2026
EngineFuel/propulsion SystemPower Train
As I was leaving the gas station the Check engine light flashed on and off then the car was like turning on and off fast and a loud clunk sound and the Fuel pump module exploded gas sprayed all over the gas station. Huge fire hazard and the car began to smoke Vehicle experienced a sudden catastrophic fuel system failure involv…
Read full complaint
As I was leaving the gas station the Check engine light flashed on and off then the car was like turning on and off fast and a loud clunk sound and the Fuel pump module exploded gas sprayed all over the gas station. Huge fire hazard and the car began to smoke Vehicle experienced a sudden catastrophic fuel system failure involving fire risk and loss of propulsion. The incident occurred without warning and created a serious safety hazard to occupants and surrounding traffic. This vehicle is a Chrysler Pacifica Hybrid. Similar failures involving fuel system and hybrid control logic have been widely reported. The manufacturer was contacted but declined to properly document the safety incident. This failure is not consistent with normal wear and tear and represents a potential safety defect. Key details to include when submitting online: - Sudden loss of propulsion - Fire risk / fuel involvement - Hybrid system interaction - Manufacturer declined to document incident
NHTSA ODI #11716894
Mileage unknown · Jan 28, 2026
Electrical SystemFuel/propulsion SystemPower Train
My vehicle went in for recall 73B at the end of August 2025. Every since the recall it has been back to the dealer for multiple check engine lights, service hybrid system, abs system, battery heater fail, blind spot warning temporary unavailable, service shifter(would not go into gear), parking brake, stability control light, pa…
Read full complaint
My vehicle went in for recall 73B at the end of August 2025. Every since the recall it has been back to the dealer for multiple check engine lights, service hybrid system, abs system, battery heater fail, blind spot warning temporary unavailable, service shifter(would not go into gear), parking brake, stability control light, partial loss of power steering while driving, service electronic throttle control, and service airbag messages. The van has been to the dealership 4 times for these messages. They have replaced components, tried to find loose wires and connectors, replaced the 12V battery, and other fixes. The van will drive normally for a few weeks, and then they come back. On the latest visit (4th since 73B recall) it's been at the dealership for 31 days and counting. The dealership is waiting on Chrysler to figure out a fix for the van. The vehicle has over 50 stored messages. This recall was supposed to monitor the hybrid battery for early indications for a fire, but according to the original recall all batteries are assumed to have the manufacturing defect that leads to spontaneous fires. This van is unsafe, and we never know when it will work correctly. The van operated normally before the recall software was installed.
NHTSA ODI #11714048
Mileage unknown · Jan 13, 2026
Electrical SystemEnginePower Train
On October 31, 2020 (before our purchase of the van) the previous owner had to take the van to Chrysler for hesitation in the transmission shifting. On June 14, 2021 (only two weeks after purchase), we had to drop it off for intermittent shifting issues with what seemed like skipped gears. No engine light came on, and the va…
Read full complaint
On October 31, 2020 (before our purchase of the van) the previous owner had to take the van to Chrysler for hesitation in the transmission shifting. On June 14, 2021 (only two weeks after purchase), we had to drop it off for intermittent shifting issues with what seemed like skipped gears. No engine light came on, and the van was returned stating an inability to reproduce the issue. On February 7, 2022 we brought the van to Chrysler after taking it in a few times to Carmax to resolve the the disabled "Start/ Stop" System. The light would intermittently come on indicating the system was unavailable, and shifting would be erratic. An inspection and recall work for the PCM was performed. In June of 2023, the UConnect System stopped working intermittently. The gears were still shifting roughly with the shift knob becoming increasingly more difficult to turn. An independent shop found no solution with an unknown timeframe on the delivery of a new transmission. In June of 2023 while driving, the van shut off completely while in motion. After a few minutes, it started up again and drove as if nothing was wrong. June 24, 2023, we took the van to Chrysler with the same issues. At the time there was still a back order of transmissions for the van. Upon contacting Chrysler, we found out that there was a recall effective on the new transmission and the company rush ordered the part to the shop. As well, the Uconnect system was also addressed. The issue was fixed. After a few years of reliable service, the van functioned normally with rough shifting and start/stop system failures still an issue. In January of 2024, the van would not start at first try. Often my wife was able to get it started after sitting for awhile. In other cases, changing the key fob helped. Changing the AUX battery repaired the issue temporarily. Now it won't start at all. The starter was misdiagnosed by an independent shop with Chrysler finding a failed transmission once again.
NHTSA ODI #11710733
Mileage unknown · Jan 5, 2026
EnginePower Train
At 48,445 miles, the vehicle's engine experienced a catastrophic internal failure involving Cylinders 4 and 6. The failure resulted in a sudden loss of motive power and engine misfires while the vehicle was in operation, creating a severe safety hazard and risk of stalling in active traffic. A certified mechanic performed a cyli…
Read full complaint
At 48,445 miles, the vehicle's engine experienced a catastrophic internal failure involving Cylinders 4 and 6. The failure resulted in a sudden loss of motive power and engine misfires while the vehicle was in operation, creating a severe safety hazard and risk of stalling in active traffic. A certified mechanic performed a cylinder leak-down and compression test, confirming internal engine failure consistent with the known 3.6L Pentastar cylinder head/gasket manufacturing defects. The vehicle is now unsafe to operate. This failure occurred well before the expected useful life of the powertrain and appears consistent with the defects alleged in the class action Maugain et al. v. FCA US LLC. No warning lights illuminated prior to the immediate failure.
NHTSA ODI #11708795
Mileage unknown · Dec 29, 2025
Power Train
Head Gasket Blew at 102,000 Miles which caused windows to fog up on freeway.
NHTSA ODI #11707579
Mileage unknown · Dec 11, 2025
EnginePower TrainSteering
The vehicle stalls while driving without any notice. This van has a start/stop function and it malfunctions. There are two separate batteries that control this function and both of them have been replaced. The entire steering rack and steering column have had to be replaced. The front suspension has also had to be replaced becau…
Read full complaint
The vehicle stalls while driving without any notice. This van has a start/stop function and it malfunctions. There are two separate batteries that control this function and both of them have been replaced. The entire steering rack and steering column have had to be replaced. The front suspension has also had to be replaced because the tires wear out very quickly. The alternator, radiator, and motor mounts have also had to be replaced. The van is available for inspection. At the moment the vehicle will not start and I have been advised that it needs a new starter. This vehicle is a safety risk and it puts others at risk as well. These problems have been diagnosed and confirmed by at least three different service centers including a Chrysler dealership. I generally do not get any warning lamps, messages, or symptoms when the van stalls.
NHTSA ODI #11704556
Mileage unknown · Nov 21, 2025
Power Train
This letter concerns repeated and life-threatening failures involving the transmission system in my 2018 Chrysler Pacifica Hybrid (CA License Plate: 8CEF638, VIN: 2C4RC1N79JR172609), covered under your lifetime transmission warranty for this model. Following two confirmed incidents resulting in unexpected engine shutdowns and cr…
Read full complaint
This letter concerns repeated and life-threatening failures involving the transmission system in my 2018 Chrysler Pacifica Hybrid (CA License Plate: 8CEF638, VIN: 2C4RC1N79JR172609), covered under your lifetime transmission warranty for this model. Following two confirmed incidents resulting in unexpected engine shutdowns and critical transmission faults, I am formally demanding a full replacement of the faulty transmission assembly as required under California lemon laws and the issued lifetime warranty extension. Summary of Incidents & Reference to NHTSA Action NHTSA Action Number: RQ24004 pertains specifically to transmission wiring defects, resulting in short circuits and loss of motive power. The recall remedy under Campaign Number 23V-010 has proven inadequate for many 2017–2023 Chrysler Pacifica Plug-In Hybrid Electric Vehicles. NHTSA’s current recall query documents continued transmission failures after owner reports and software updates. Case Number: XXX was opened with Chrysler in response to my experiences, and reflects ongoing safety risks with this transmission. Incident 1 Date/Location: Sunday, September 1, 2025, 5:00 PM — Southbound I-5 near Downey, CA. Description: Sudden vehicle shutoff at highway speeds. Immediate hazard required emergency calls and intervention. Exhibit 1: Call log to Chrysler Downey at 5:07 PM included. Incident 2 Date/Location: Wednesday, October 29, 2025, 2:20 PM — Northbound I-5, Via De Lavalle exit off-ramp. Description: Dashboard warning ("Stop Safely, Vehicle Will Shut Off Soon") and loss of motive power. Towing, police, and emergency assistance required. Exhibit 2: Image of dashboard warning. Exhibit 3: Phone log of AAA towing, Delmar Police, and Sheriff calls, confirming duration and response. Warranty Information As a California owner of a 2018 Chrysler Pacifica Hybrid, your published material and user communications confirm a lifetime warranty for the transmission on this specific model, following NHSTA RQ24004
NHTSA ODI #11700800
Mileage unknown · Nov 12, 2025
Electrical SystemForward Collision AvoidancePower TrainCrashInjury
Vehicle was put into reverse and did not stop, it hit a pole. Then the driver tried to put in drive to get it off of the pole and it accelerated quickly and the driver could not stop the vehicle. There was little time to react as it hit the side of a building and airbags deployed. Driver stated that the car accelerated on it's o…
Read full complaint
Vehicle was put into reverse and did not stop, it hit a pole. Then the driver tried to put in drive to get it off of the pole and it accelerated quickly and the driver could not stop the vehicle. There was little time to react as it hit the side of a building and airbags deployed. Driver stated that the car accelerated on it's own once it was put into gear.
NHTSA ODI #11698911
Mileage unknown · Nov 8, 2025
EnginePower TrainVehicle Speed Control
This van is a 2018 modified with a handicap accessible rear ramp. We purchased this van in 2021 and since it has spent 6 months the first time at the shop then it was at our facility totally not running for another 6 months we paid 400 dollars to tow it to a dealership they replaced the transmission it ran for 2 months and now d…
Read full complaint
This van is a 2018 modified with a handicap accessible rear ramp. We purchased this van in 2021 and since it has spent 6 months the first time at the shop then it was at our facility totally not running for another 6 months we paid 400 dollars to tow it to a dealership they replaced the transmission it ran for 2 months and now doesn’t start it’s in limp mode and when it does start and run when your driving it loses all power suddenly. We have only put 3800 miles on this van in the time we’ve had it and we owe over 25,000 still on it. Nobody can figure out what’s wrong with it but we are very small residential care facility and we are unable to transport residents because we have a broken van that we still pay for do we can’t purchase another one.
NHTSA ODI #11698382
Mileage unknown · Oct 7, 2025
Electrical SystemFuel/propulsion SystemPower Train
I was driving and the van suddenly lost all propulsion. Brakes and steering and dash lights functioned, but there was a red turtle icon and error message about a system failure. The accelerator pedal did nothing at all. I was able to coast off the side of the road to a place to pull over, but that could have been a terrible ac…
Read full complaint
I was driving and the van suddenly lost all propulsion. Brakes and steering and dash lights functioned, but there was a red turtle icon and error message about a system failure. The accelerator pedal did nothing at all. I was able to coast off the side of the road to a place to pull over, but that could have been a terrible accident if I lost power like that on I-95 or any other major highway. My husband came and we switch cars (kids, car seats, etc) and he was able to get the van to start after half an hour. It had check engine lights on for things, but the dealer said to bring it in because it was drivable again. Despite brining it in as told, with check engine lights on that they saw, they said they could not reproduce it and couldn't find codes for the check engine light (even though I pulled them from my own OBD2 diagnostic plug tool and took photos of the codes) and eventually said I have to take the car back, despite no cause or resolution. These cars have known faulty battery issues and a large number have been replaced already, but Chrysler isn't authorizing dealers to do that unless they can reliably reproduce the failure. Very frustrating to see Chrysler not go the route of other manufacturers who sourced their batteries from the same plant and ended up proactively replacing them for consumers. While Chrysler's many recalls for the hybrid battery system software have probably made it detect faults earlier to try to prevent fires, they are still known to happen, but now in addition to a fire risk, we also have a car that has a much higher chance of just losing power while driving due to over sensitive battery monitoring, or a plain old faulty battery that just isn't faulty 'enough' for Chrysler to authorize a replacement. So frustrating and dangerous.
NHTSA ODI #11691774
Official recalls
12Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Jan 17, 2023
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence & remedy
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
Additional source detail variants (2)
Electrical System:wiring:connectors/plugs/receptacles
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
Hybrid Propulsion System: Inverter
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
Dec 12, 2019
Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.
Equipment:electrical:radio/tape Deck/cd Etc.
Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.
May 9, 2019
Chrysler (FCA US LLC) is recalling certain 2017-2019 Pacifica vehicles equipped with engine stop/start systems. A loose battery ground connection may result in an intermittent loss of power steering assist and/or a stall.
Consequence & remedy
Consequence: A loss of power steering assist or a stall can increase the risk of crash.
Remedy: Chrysler will notify owners, and dealers will inspect the battery ground surfaces, clean the contact surfaces as needed, and properly reassemble the ground connection, free of charge. The recall began May 24, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. FCA US' number for this recall is V53.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Consequence & remedy
Consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Jul 26, 2018
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Cherokee vehicles and 2018 Chrysler Pacifica non-hybrid vehicles. A component in the transmission may not have been welded properly, possibly causing the transmission to not transmit engine power to the wheels.
Consequence & remedy
Consequence: If the transmission weld fails, the vehicle will stop moving, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the transmission, free of charge. The recall is expected to begin September 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U85.
Jul 26, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica vehicles. The front axle halfshafts may have been incorrectly assembled, preventing the shaft from being properly secured to the constant-velocity (CV) joint.
Consequence & remedy
Consequence: If the axle shaft disengages from the CV joint, the vehicle will have a loss of drive or allow the vehicle to move while in the "Park" position. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the left or right halfshaft assembly, free of charge. The recall began September 18, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U80.
Jun 14, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
Additional source detail variants (2)
EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 31, 2017
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles equipped with the 8-passenger seating option. In certain passenger seating and vehicle situations, the second-row center seating position seat belt buckle could cause the left outboard seat belt to become unlatched.
Consequence & remedy
Consequence: Inadvertent unlatching of the left outboard seat belt can increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will install a shorter second-row seat belt buckle, free of charge. The recall began October 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T54.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25009 · Intermittent Loss Of Electric Power Steering
Opened Sep 5, 2025 · No close date supplied
Status: open (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a sticking sensation during gradual turns, particularly when the steering wheel is positioned near the 11 o'clock or 1 o'clock position. Complainants allege that during these events, increased steering effort is required to return the wheel to center. In many cases, this is followed by a sudden reactivation of EPS assistance, which may result in an oversteer condition. This behavior could increase the risk of a crash, especially at higher speeds. ODI has identified multiple VOQs describing similar symptoms. This investigation will assess the frequency, root cause, and potential safety-related consequences of the alleged EPS malfunction. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.
Opened Feb 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22008 · Transmission Fault Leading To Loss Of Motive Power
Opened Jul 22, 2022 · Closed Mar 27, 2024
Status: closed (inferred from source dates) · Power Train
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration