Engine. Review the 373 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports14 fire reports14 injury reports

Power Train complaints

155 reports

Clear category filter

82,000 miles · Sep 14, 2026

Power Train

Read full complaint

The contact owns a 2018 Chrysler Pacifica. While the contact's son was driving at an undisclosed speed, the shifter module warning light illuminated. The dealer was contacted by phone and was made aware of the failure. The vehicle was towed to the dealer where it was diagnosed with a shifter module failure. The contact was informed that the shifter module needed to be replaced. The vehicle was repaired; however, the failure reoccurred. While the contact's son was driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. In addition, the steering wheel failed to turn in the intended direction and several unknown warning lights illuminated. The vehicle was driven to the residence. The contact stated that the following day, the vehicle was started; however, the gear shifter failed to shift as needed. The dealer was contacted by phone and made aware of the failure. The vehicle was towed to the dealer, and the battery was replaced, but the failure reoccurred. The dealer was contacted by phone and made aware of the failure. The vehicle was towed to the dealer; however, the failure was not duplicated. The contact was informed that the failure was possibly caused by the wiring harness. The vehicle was not repaired. The contact was informed that the parts were discontinued. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 82,000.

NHTSA ODI #11764165

120,000 miles · Aug 19, 2026

Power Train

Read full complaint

The contact owns a 2018 Chrysler Pacifica. The contact stated that while driving at an undisclosed speed, the vehicle became difficult to maneuver, and the vehicle stalled. The message "Power Train" was displayed on the instrument panel. The failure occurred on several occasions. The vehicle was towed to a dealer where it was diagnosed and determined that the auxiliary battery needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

NHTSA ODI #11758035

Mileage unknown · Aug 4, 2026

Power Train

While driving the vehicle the minivan will lose all acceleration. There is usually a preceding error displayed on the dashboard to pull over immediately. The dealership has thus far been unable to fix it.

NHTSA ODI #11754802

Mileage unknown · Jul 29, 2026

Electrical SystemEnginePower Train

While driving, the vehicle unexpectedly shut off without warning. The engine stalled while the vehicle was in motion, causing an immediate loss of acceleration and power. This created a serious safety hazard in traffic. The issue is consistent with the condition described in Safety Recall U01 for 2017 Chrysler Pacifica vehicles …

Read full complaint

NHTSA ODI #11753607

Mileage unknown · Jul 15, 2026

EnginePower Train

Read full complaint

I had my cylinder heads, valves and head gasket replaced over a year ago and drove 15k miles and i am having the same issues again. The Dealer is trying there very best not to honor my valid powertrain parts warranty like saying the head gasket is only covered for 12 months and denying my claim but my cylinder heads and top end have a 3 year 100k mile warranty since they were installed not to long ago and they are trying to deny my claim using the head gasket. I have seen and read online that these engines all have similar problems with the head gaskets.

NHTSA ODI #11750601

Mileage unknown · Jul 12, 2026

Power Train

Read full complaint

The van fail GA state emissions with code p2797. I have to the end of July to get the tag. I went to the state for a repair waiver control # s1174706. I told them this code is under a tsb it fell on deaf ears. I. Took the van back to the dealership for a third time a different dealership they say they did the procedure for the tsb code p2797 butt didn't fix the code to pass GA emission. Tsb are good for the automotive industry but if the tsb and engineers procedures didn't fix the p2797 code than the tsb need to be moved to a recall program. The dealership was good at explaining that the van needs a new transmission that cost the customer 13,000.00 to replace and 3000 for new struts. The van was bought Sept 2025 and the payoff is 13,000.00. The problem is have is will not pass GA state emissions, a code thats not related with emissions cover under a tsb that should have fix it at the dealership.

NHTSA ODI #11749873

Mileage unknown · Jun 20, 2026

EnginePower Train

Read full complaint

2018 Chrysler Pacifica with the 3.6L V6 engine had a check engine light turn. At same time a vibration started, which was most noticable when the car was in idle. Also, a foggy exhaust started at the same time. No temperature or other warnings were occuring. After driving it to the repair facility the car was not able to be turned on. The findings are that there is a headgasket leak and radiator failure that resulted in coolant entering into the cylinder. That resulted in either hydrolock or engine overheating, causing engine failure. Again no temperature warning or other indication of a major issue was provided. The likely repair is a full engine and radiator replacement. It appears that many other Chrysler Pacifica vehicles have reported similar issues with the 3.6L Pentastar engine. No recall is currently available for the 2018 Chrysler Pacifica for this issue, however, it looks like the older versions (~2011-2013) have had a recall for similar issues. I have reached out to Chrysler Corporate and requested support on this repair.

NHTSA ODI #11745408

Mileage unknown · Jun 15, 2026

Power Train

Read full complaint

This is related to the 23V-010 / XE1 recall and extended warranty for the 2018 Chrysler Pacifica Hybrid Limited. The manufacturer is refusing the recall remedy because the catastrophic nature of the failure (transmission rupture) makes it impossible for the dealer to pull diagnostic codes. This creates an impossible standard for the consumer and effectively nullifies a federal safety recall. On XXX, I brought my 2018 Chrysler Pacifica Hybrid Limited to D’Ambrosio Service in Downingtown, PA. I reported that the car was making a sound during acceleration. On April 16, I was advised that the noise was the rubbing of the heat shield which was reportedly adjusted and tested that the noise was gone. On April 19 I sent a message to D’Ambrosio that the noise remained however I never received a response. I believe that the noise was misdiagnosed and was actually warning signs of an imminent transmission failure. On XXX, while driving, my wife and I heard a pop, saw smoke pouring out the back and immediately pulled over to discover a large amount of fluid spilling out of the bottom of the vehicle. The vehicle was towed to D’Ambrosio service in [XXX] where it has remained unaddressed until June 10. On XXX I received a phone call from D’Ambrosio that the vehicle transmission had a hole in it (quote from service advisor "internal failure of the transmission, which has caused components to puncture the casing") and would need to be replaced at my cost. When I inquired about the XE1 warranty extension, I was told that the lack of diagnostic codes didn’t justify the warranty. I then asked that the issue be escalated INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11744207

Mileage unknown · May 27, 2026

Electrical SystemLane DeparturePower Train

Read full complaint

Odometer 66466. Hybrid battery charge level 100%. When starting the vehicle the issue started with the transmission shifter knob stuck in gear Park. After turning off and on a few times, the transmission shifter knob would shift into Reverse. I then drove it to a dealer service for repair. During the drive several dash warning messages appeared. Also, the blind spot warning system did not function and the backup camera did not function. Dash warning messages while driving to dealer service: Parking Brake, TPS, Service Electronic Stability Control, engine, Red wrench, amber throttle, Brake, Service Electronic Throttle Control, Service Hybrid Electric Vehicle System. stability control, Blind Spot Alert, Arrived at dealer, kept engine on, brought service tech rep to vehicle and demonstrated the issue while in service bay. Mileage 66474. Last message I saw, Service Hybrid Electric Vehicle System. Friday, April 10 2026. The vehicle was in the shop for Service Hybrid Electric Vehicle System just 750 miles previous to this system failure. Dealer is unable to fix problem. Hybrid System still under warranty. Hybrid battery replaced last year, 12 volt battery replaced twice after. Vehicle is beyond unreliable, there is significant risk of failure at any time.

NHTSA ODI #11740295

Mileage unknown · May 20, 2026

Electrical SystemFuel/propulsion SystemPower Train

Read full complaint

The manufacturer's mandatory 73B Safety Recall update (Vehicle Fires) creates a critical software-induced communication failure on the central vehicle network. Following the 73B flash, the vehicle developed an Active SGW U0001-00 CAN C Bus network fault, which permanently blocks data transmission and triggers an HCP U0412 hybrid battery fault. This network crash disables the hybrid propulsion systems, creating an unpredictable and hazardous driving condition. The manufacturer (Stellantis) and its authorized dealer (Seattle Jeep) are refusing to remedy this safety recall side effect under the vehicle's Hybrid Powertrain Warranty, instead forcing consumers to pay out-of-pocket diagnostic fees ($284.67) and multi-module software update fees ($812.50) to correct a defect injected by the recall software itself. This directly compromises vehicle safety and violates federal recall remedy mandates.

NHTSA ODI #11739052

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

23V010000 · Electrical System:wiring:connectors/plugs/receptacles; Hybrid Propulsion System: Inverter

Jan 17, 2023

Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

Consequence & remedy

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Additional source detail variants (2)

Electrical System:wiring:connectors/plugs/receptacles

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Hybrid Propulsion System: Inverter

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

19V886000 · Back Over Prevention: Sensing System: Camera; Equipment:electrical:radio/tape Deck/cd Etc.

Dec 12, 2019

Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Equipment:electrical:radio/tape Deck/cd Etc.

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

19V348000 · Electrical SYSTEM:12V/24V/48V Battery

May 9, 2019

Chrysler (FCA US LLC) is recalling certain 2017-2019 Pacifica vehicles equipped with engine stop/start systems. A loose battery ground connection may result in an intermittent loss of power steering assist and/or a stall.

Consequence & remedy

Consequence: A loss of power steering assist or a stall can increase the risk of crash.

Remedy: Chrysler will notify owners, and dealers will inspect the battery ground surfaces, clean the contact surfaces as needed, and properly reassemble the ground connection, free of charge. The recall began May 24, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. FCA US' number for this recall is V53.

19V143000 · Suspension:front:control Arm:lower Arm

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Consequence & remedy

Consequence: A control arm separation could increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V492000 · Power Train:automatic Transmission

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Cherokee vehicles and 2018 Chrysler Pacifica non-hybrid vehicles. A component in the transmission may not have been welded properly, possibly causing the transmission to not transmit engine power to the wheels.

Consequence & remedy

Consequence: If the transmission weld fails, the vehicle will stop moving, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transmission, free of charge. The recall is expected to begin September 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U85.

18V493000 · Power Train:axle Assembly:axle Shaft

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica vehicles. The front axle halfshafts may have been incorrectly assembled, preventing the shaft from being properly secured to the constant-velocity (CV) joint.

Consequence & remedy

Consequence: If the axle shaft disengages from the CV joint, the vehicle will have a loss of drive or allow the vehicle to move while in the "Park" position. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the left or right halfshaft assembly, free of charge. The recall began September 18, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U80.

18V395000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Jun 14, 2018

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."

Consequence & remedy

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Additional source detail variants (2)

EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Electrical System:wiring

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

17V542000 · Seat Belts:rear/other

Aug 31, 2017

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles equipped with the 8-passenger seating option. In certain passenger seating and vehicle situations, the second-row center seating position seat belt buckle could cause the left outboard seat belt to become unlatched.

Consequence & remedy

Consequence: Inadvertent unlatching of the left outboard seat belt can increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will install a shorter second-row seat belt buckle, free of charge. The recall began October 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T54.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE25009 · Intermittent Loss Of Electric Power Steering

Opened Sep 5, 2025 · No close date supplied

Status: open (inferred from source dates) · Steering:electric Power Assist System

The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a sticking sensation during gradual turns, particularly when the steering wheel is positioned near the 11 o'clock or 1 o'clock position. Complainants allege that during these events, increased steering effort is required to return the wheel to center. In many cases, this is followed by a sudden reactivation of EPS assistance, which may result in an oversteer condition. This behavior could increase the risk of a crash, especially at higher speeds. ODI has identified multiple VOQs describing similar symptoms. This investigation will assess the frequency, root cause, and potential safety-related consequences of the alleged EPS malfunction. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.

Opened Feb 27, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:wiring

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.

RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)

Opened Jan 16, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE22008 · Transmission Fault Leading To Loss Of Motive Power

Opened Jul 22, 2022 · Closed Mar 27, 2024

Status: closed (inferred from source dates) · Power Train

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.