IllustrationHead gasket failed, flooding #5 cylinder with engine coolant. A warning lamp came on just prior to the failure signaling the #5 plug was misfiring. The engine stopped running and could not start the vehicle. The engine is the Chrysler Pentastar V6 with 63,763 miles.
2017 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2017 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3900–25K
20925–50K
11650–75K
3975–100K
27100–150K
12150K+
793 reports with mileage · 726 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 522 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 468 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 389 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports10 fire reports22 injury reports
Engine complaints
522 reportsAs I am driving down the street in the middle of traffic the van will cut off and all wheels will lock , I buy a new battery and wires and it continues to happen, not able to drive the expressway scared of causing an accident. The dash will start blinking and the electric will start flashing radio shuts down and the whole car is…
Read full complaint
As I am driving down the street in the middle of traffic the van will cut off and all wheels will lock , I buy a new battery and wires and it continues to happen, not able to drive the expressway scared of causing an accident. The dash will start blinking and the electric will start flashing radio shuts down and the whole car is down for a few minutes like it need to reset.
At 76,000 miles, the engine started to misfire and smoke while driving. Loud pop heard. Took it in and dealership said it was a known engine problem with this 3.6 liter engine on cylinder #5 due to the lack of heat dissipation in the rear of the engine compartment. Thank goodness we had just started the car when we heard the pop…
Read full complaint
At 76,000 miles, the engine started to misfire and smoke while driving. Loud pop heard. Took it in and dealership said it was a known engine problem with this 3.6 liter engine on cylinder #5 due to the lack of heat dissipation in the rear of the engine compartment. Thank goodness we had just started the car when we heard the pop. The service engine light cam on immediately after the rough start and now if started, it smokes from the tailpipe. Likely head gasket, warped head due to lack of cooling. Car always serviced at dealership. This is a common and known problem at this mileage for this vehicle.
1. Engine power failure 2. Put in extreme danger-I lost all power going through a tunnel under water (MM Bridge Tunnel). I completely stalleddead center in the middle. Only by the grace of God did no one hit me. I also have severe neck issues. A couple of my neck discs need to be replaced. If I were hit I could have been paralyz…
Read full complaint
1. Engine power failure 2. Put in extreme danger-I lost all power going through a tunnel under water (MM Bridge Tunnel). I completely stalleddead center in the middle. Only by the grace of God did no one hit me. I also have severe neck issues. A couple of my neck discs need to be replaced. If I were hit I could have been paralyzed. This has created emotional and financial anxiety as well as poor sleep due to tense muscles and body aches. 3. It has almost cut off twice since then. A mechanic did a deep check of all electrical systems, they are fine. He said it was an engine power drain issue. He said according to research it was a known engine problem. 4. Dealer said my vin # is not on the list (even though it's a known problem) and stated I would have to pay for check and repairs. I saw there was a case settlement and am hoping that will cover the cost. The was no police report even though they pulled up to protect me. The van eventually started again and I moved to a safe location. Dodd's Auto shop did evaluation. 5. I noticed an engine light before stall. I'm not sure how long it had been on. My van has a security video but I'm not sure how to get it. My husband is out of town caring for his 96yr old father so he couldn't get it for me.
Check engine light on. P0303 Cylinder 3 Misfire Detected, My maintenance history : Coil is good, only been 27,000 mile since I replaced 6xspark plugs, replaced 1 fuel injector just a week a go, still got engine light on. I took my van to Chrysler Dealer found coolant leaking into cylinder head or gasket. I searched online see…
Read full complaint
Check engine light on. P0303 Cylinder 3 Misfire Detected, My maintenance history : Coil is good, only been 27,000 mile since I replaced 6xspark plugs, replaced 1 fuel injector just a week a go, still got engine light on. I took my van to Chrysler Dealer found coolant leaking into cylinder head or gasket. I searched online seems pacifica has many cylinder manufacturers issue.
I purchased my 2017 in 2023. Within a few months, problems began. When we brought the van back to the Chrysler dealer to have it checked with their OBD2 code reader, multiple codes pulled up… First thing “needing” to be replaced was the hood sensor because the display said the hood was open (even though I was simply stopped a…
Read full complaint
I purchased my 2017 in 2023. Within a few months, problems began. When we brought the van back to the Chrysler dealer to have it checked with their OBD2 code reader, multiple codes pulled up… First thing “needing” to be replaced was the hood sensor because the display said the hood was open (even though I was simply stopped at a red light). The auto start/stop light was also coming on and staying on. The dealer said that would go away after replacing the sensor. That repair was done (I believe) in April of 2024 at the Chrysler dealer (and the auto start/stop light came back on a week later, both batteries testing fine independently of one another). Next thing “needing” to be replaced was the accelerator pedal module because my van would start shaking, not accelerate, and go into (what I now know is) limp mode with all warning lights displaying on almost every right hand turn. This absolutely puts my safety and the safety of my four children at risk when it suddenly decides to not accelerate!! That repair was done in June 2024 at the Chrysler dealer. Next thing to happen is the check engine light illuminating. We checked the coolant and it was almost empty! This should NOT be happening! We filled with coolant, but have to do this every few days now. The check engine light has come back on and is still producing many codes, the worst of which is p0303. This code has pulled up every single time we’ve had the van scanned at the dealer. The dealer has had my vehicle on MULTIPLE occasions for MULTIPLE days each time and NEVER ONCE told me the severity of this problem. Their words: We just go down the list, starting at the top. P0303 was not at the top, and now I have to pay the price for their incompetency! My van would not start and had to be towed to the dealer yesterday, 7.17.2024. I’m waiting to hear from them, but I can guarantee this is a head gasket/engine failure issue. Who can afford to just replace an engine?! This is infuriating and beyond frustrating!!
Before I purchased the vehicle the head gasket was replaced do to an misfire on cylinder 3 fault code. Misfire on cylinder 3 fault code consistently comes back on after replacing coil packs and spark plugs. Independant mechanic states he cannot solve the issue. Chrysler dealer states engine needs replacement as the block is crac…
Read full complaint
Before I purchased the vehicle the head gasket was replaced do to an misfire on cylinder 3 fault code. Misfire on cylinder 3 fault code consistently comes back on after replacing coil packs and spark plugs. Independant mechanic states he cannot solve the issue. Chrysler dealer states engine needs replacement as the block is cracked and leaking into cylinder 3. 120k miles on engine. Bought it with 112k.
92,000 miles engine failed and had to replace with a new one. Started with a rough idle at start up and code said misfire on #6 ,had a tune up done with replacing plug and coil packs. Next code was #5 misfiring, and then it started blowing white smoke. Head gasket blown but wouldn't guarantee repairs so I went with a new motor …
Read full complaint
92,000 miles engine failed and had to replace with a new one. Started with a rough idle at start up and code said misfire on #6 ,had a tune up done with replacing plug and coil packs. Next code was #5 misfiring, and then it started blowing white smoke. Head gasket blown but wouldn't guarantee repairs so I went with a new motor with a warranty
2017 Pacifica, front bank (also referred to as left side of 3.6 Pentastar engine) multiple cylinder misfire, due to failed head; 110,000 miles. Issues progressed exactly or very similarly as described by multiple (hundreds of owners) on Pacifica forums), most fail between 80,000 to 120,000 miles, with distribution between 50k an…
Read full complaint
2017 Pacifica, front bank (also referred to as left side of 3.6 Pentastar engine) multiple cylinder misfire, due to failed head; 110,000 miles. Issues progressed exactly or very similarly as described by multiple (hundreds of owners) on Pacifica forums), most fail between 80,000 to 120,000 miles, with distribution between 50k and 150k. Suspect excessive heat in engine bay coupled with defective head manufacturing (Mexican built engines suspected to have higher failure rate) and faulty components leading to head failures (cracked heads, warped heads, faulty head gaskets) on 2017+ Pacificas. Rear head known to fail due to lack of sufficient cooling in position at back of engine bay. Vehicle also goes through one aux start/stop battery every 1-1.5 years (suspect early failures due to excessive heat, not overcharging issue that Chrysler recalled for). Vehicle also has history of faulty roller rockers and lifters, already had replaced once while in warranty period. Issue began as faulty cam phase sensor. When repairs made mechanic also noted that oil cooler was cracked. This is a faulty design remedied by Chrysler for 2022 models. Heat coupled with bad o-rings and/or overtightening of oil filter cap leads to crack in assembly allowing for oil and/or coolant loss. Chrysler has made no attempt to fix known issue on pre-2022 models. Repaired both at cost of $1033. Few days later P0300 code and loss of engine power. Diagnosed as faulty roller rockers, one of which had even broken off. Roller rockers, lifters, and cam replaced on left side of engine at cost of $2700. Mechanic pressure tested head and found no leakage. Drove home and multiple cylinder misfire occurred again with loss of power. Returned to mechanic. Suspect crack between intake and exhaust valve guides which opens as head heats (seems to occur once engine reaches 195 degrees F, which is just below normal operating range). Head replacement suggested but not recommended as I'll be upside down in vehicle.
Failed head gasket. Faulty manufacturing. All maintenance done as recommended by manufacturer by the dealership who sold the vehicle.
Official recalls
1125V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
23V010000 · Electrical System:wiring:connectors/plugs/receptacles; Hybrid Propulsion System: Inverter
Jan 17, 2023
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence & remedy
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
Additional source detail variants (2)
Electrical System:wiring:connectors/plugs/receptacles
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
Hybrid Propulsion System: Inverter
Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.
Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.
19V348000 · Electrical SYSTEM:12V/24V/48V Battery
May 9, 2019
Chrysler (FCA US LLC) is recalling certain 2017-2019 Pacifica vehicles equipped with engine stop/start systems. A loose battery ground connection may result in an intermittent loss of power steering assist and/or a stall.
Consequence & remedy
Consequence: A loss of power steering assist or a stall can increase the risk of crash.
Remedy: Chrysler will notify owners, and dealers will inspect the battery ground surfaces, clean the contact surfaces as needed, and properly reassemble the ground connection, free of charge. The recall began May 24, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. FCA US' number for this recall is V53.
18V524000 · Electrical System:wiring:front Underhood
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
18V395000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices
Jun 14, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
Additional source detail variants (2)
EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.
Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.
18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
18V049000 · Electrical System:software; Engine And Engine Cooling:engine
Jan 11, 2018
Chrysler (FCA US LLC) is recalling certain 2017 Chrysler Pacifica vehicles equipped with a 3.6l engine. The engine control software may become out of sync with the crankshaft position sensor, possibly resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the engine control software, free of charge. The recall began March 7, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U01.
Additional source detail variants (2)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2017 Chrysler Pacifica vehicles equipped with a 3.6l engine. The engine control software may become out of sync with the crankshaft position sensor, possibly resulting in an engine stall.
Consequence: An engine stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the engine control software, free of charge. The recall began March 7, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U01.
Engine And Engine Cooling:engine
Chrysler (FCA US LLC) is recalling certain 2017 Chrysler Pacifica vehicles equipped with a 3.6l engine. The engine control software may become out of sync with the crankshaft position sensor, possibly resulting in an engine stall.
Consequence: An engine stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the engine control software, free of charge. The recall began March 7, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U01.
17V542000 · Seat Belts:rear/other
Aug 31, 2017
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles equipped with the 8-passenger seating option. In certain passenger seating and vehicle situations, the second-row center seating position seat belt buckle could cause the left outboard seat belt to become unlatched.
Consequence & remedy
Consequence: Inadvertent unlatching of the left outboard seat belt can increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will install a shorter second-row seat belt buckle, free of charge. The recall began October 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T54.
17V482000 · Power Train:driveline:differential Unit
Jul 28, 2017
Vantage Mobility International, LLC (VMI) is recalling certain 2017 Chrysler Pacifica lowered floor vehicles modified by VMI. The rear pinion bracket on both sides of the vehicle may crack, causing the axle not to be centered and the wheel to wobble.
Consequence & remedy
Consequence: A wheel wobble may cause a possible loss of control, increasing the risk of a crash.
Remedy: VMI will notify owners, and dealers will replace the pinion brackets, free of charge. The recall began on August 14, 2017. Owners may contact VMI customer service at 1-800-488-9082. VMI's number for this recall is PAC20170728.
17V342000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
May 25, 2017
Vantage Mobility International, LLC (Vantage Mobility) is recalling certain 2017 Chrysler Pacifica lowered floor vans modified by Vantage Mobility for wheelchair accessibility. The affected vans have rear brake lines that might have been crossed during the modification. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: The crossed rear brake lines will cause the rear anti-lock brake system to be ineffective, increasing the risk of a crash.
Remedy: Vantage Mobility will notify owners, and dealers will correct the rear brake line attachments, free of charge. The recall began on July 3, 2017. Owners may contact Vantage Mobility customer service at 1-800-488-9082. Vantage Mobility's number for this recall is Pac-20170525.
16V490000 · Seat Belts:rear/other
Jun 30, 2016
Chrysler (FCA US LLC) is recalling certain model year 2017 Pacifica vehicles manufactured February 22, 2016, through April 28, 2016. The center overhead seat belt stow clip may fracture and prevent use of the seat belt in the third-row and/or second-row center passenger seat (if so equipped).
Consequence & remedy
Consequence: If passengers occupying the third-row and/or second-row center seats cannot use a seat belt, there is an increased risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the third-row and, if necessary, second-row center overhead seat belt stow bezel, free of charge. The recall began on July 14, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S42.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25009 · Intermittent Loss Of Electric Power Steering
Opened Sep 5, 2025 · No close date supplied
Status: open (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a sticking sensation during gradual turns, particularly when the steering wheel is positioned near the 11 o'clock or 1 o'clock position. Complainants allege that during these events, increased steering effort is required to return the wheel to center. In many cases, this is followed by a sudden reactivation of EPS assistance, which may result in an oversteer condition. This behavior could increase the risk of a crash, especially at higher speeds. ODI has identified multiple VOQs describing similar symptoms. This investigation will assess the frequency, root cause, and potential safety-related consequences of the alleged EPS malfunction. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP17003 · Stall/loss Of Motive Power
Opened Dec 1, 2017 · Closed Mar 1, 2018
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:gasoline
By letter dated November 30, 2017, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration requesting it open an investigation into allegations of engine stalling in the model year (MY) 2017 Chrysler Pacifica, a new vehicle platform. In support of its petition, CAS cited 57 NHTSA complaints alleging an engine stall in the subject Pacifica vehicles, in addition to other information it provided.On December 1, 2017, NHTSA's Office of Defects Investigation opened Defect Petition 17-003 as requested by CAS.ODI sent an information request letter to Fiat Chrysler Automobiles (FCA), the manufacturer of the subject Pacifica vehicles, on December 12, 2017 requesting information related to engine stalling in Pacificas.The letter requested FCA provide the information by January 23, 2018.On January 11, 2018, and after technical discussions with ODI, FCA filed a defect information report advising the agency that it would conduct a safety recall of certain MY2017 Chrysler Pacificas to address a condition resulting in engine stalling without warning.The recall would address nearly 154,000 MY2017 Pacificas manufactured with engine control software that did not contain a routine intended to address loss of crankshaft position information required to keep the engine from stalling.FCA noted the condition could lead to a stall without illuminating a Malfunction Indicator Lamp, and without setting any Diagnostic Trouble Code.Given these conditions, dealer technicians would be unable to properly diagnose, much less correct the cause of the stalling, which resulted in additional stalling events and significant consumer frustration.ODI reviewed consumer complaints it received through the date of FCA's recall filing and identified 88 alleging engine stalling.The ODI complaints generally describe stalling that occurs at low engine (RPM) and/or vehicle speeds, and are consistent in that regard with most of the 445 reports FCA provided.Also both the ODI and FCA reports note that the engine could be readily restarted after stalling.Both circumstances are consistent with the root cause FCA identified and is conducting a recall to address.Additionally, FCA was able to identify an older vehicle population that used the same engine as the MY2017 Pacifica, however the vehicles were manufactured with the remedy level software; according to FCA reports of stalling in this population were significantly lower.No crash or injury reports were identified in either the ODI or FCA reports.Certain MY2017 and all MY2018 Pacificas were manufactured with the remedy level software and are thus not included in the recall action.In view of the recall action FCA has announced, ODI considers the petition moot and is closing the action without a grant or deny decision.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.Reference (ODI) numbers for the above NHTSA complaints:11060960, 11060808, 11060711, 11057809, 11057520, 11057493, 11057171, 11057169, 11057025, 11055566, 11055031, 11054808, 11054746, 11054717, 11054274, 11054085, 11053669, 11053588, 11053553, 11053322, 11052905, 11052892, 11052654, 11052336, 11051390, 11051158, 11048832, 11048728, 11048720, 11048661, 11048626, 11048175, 11047936, 11047831, 11047793, 11047687, 11047684, 11047399, 11045061, 11042619, 11040610, 11040502, 11040294, 11039494, 11035468, 11034698, 11033417, 11032016, 11030729, 11029903, 11025266, 11025119, 11023691, 11023539, 11022835, 11022154, 11021223, 11019457, 11016083, 1101
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline
By letter dated November 30, 2017, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration requesting it open an investigation into allegations of engine stalling in the model year (MY) 2017 Chrysler Pacifica, a new vehicle platform. In support of its petition, CAS cited 57 NHTSA complaints alleging an engine stall in the subject Pacifica vehicles, in addition to other information it provided.On December 1, 2017, NHTSA's Office of Defects Investigation opened Defect Petition 17-003 as requested by CAS.ODI sent an information request letter to Fiat Chrysler Automobiles (FCA), the manufacturer of the subject Pacifica vehicles, on December 12, 2017 requesting information related to engine stalling in Pacificas.The letter requested FCA provide the information by January 23, 2018.On January 11, 2018, and after technical discussions with ODI, FCA filed a defect information report advising the agency that it would conduct a safety recall of certain MY2017 Chrysler Pacificas to address a condition resulting in engine stalling without warning.The recall would address nearly 154,000 MY2017 Pacificas manufactured with engine control software that did not contain a routine intended to address loss of crankshaft position information required to keep the engine from stalling.FCA noted the condition could lead to a stall without illuminating a Malfunction Indicator Lamp, and without setting any Diagnostic Trouble Code.Given these conditions, dealer technicians would be unable to properly diagnose, much less correct the cause of the stalling, which resulted in additional stalling events and significant consumer frustration.ODI reviewed consumer complaints it received through the date of FCA's recall filing and identified 88 alleging engine stalling.The ODI complaints generally describe stalling that occurs at low engine (RPM) and/or vehicle speeds, and are consistent in that regard with most of the 445 reports FCA provided.Also both the ODI and FCA reports note that the engine could be readily restarted after stalling.Both circumstances are consistent with the root cause FCA identified and is conducting a recall to address.Additionally, FCA was able to identify an older vehicle population that used the same engine as the MY2017 Pacifica, however the vehicles were manufactured with the remedy level software; according to FCA reports of stalling in this population were significantly lower.No crash or injury reports were identified in either the ODI or FCA reports.Certain MY2017 and all MY2018 Pacificas were manufactured with the remedy level software and are thus not included in the recall action.In view of the recall action FCA has announced, ODI considers the petition moot and is closing the action without a grant or deny decision.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.Reference (ODI) numbers for the above NHTSA complaints:11060960, 11060808, 11060711, 11057809, 11057520, 11057493, 11057171, 11057169, 11057025, 11055566, 11055031, 11054808, 11054746, 11054717, 11054274, 11054085, 11053669, 11053588, 11053553, 11053322, 11052905, 11052892, 11052654, 11052336, 11051390, 11051158, 11048832, 11048728, 11048720, 11048661, 11048626, 11048175, 11047936, 11047831, 11047793, 11047687, 11047684, 11047399, 11045061, 11042619, 11040610, 11040502, 11040294, 11039494, 11035468, 11034698, 11033417, 11032016, 11030729, 11029903, 11025266, 11025119, 11023691, 11023539, 11022835, 11022154, 11021223, 11019457, 11016083, 1101
Engine
By letter dated November 30, 2017, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration requesting it open an investigation into allegations of engine stalling in the model year (MY) 2017 Chrysler Pacifica, a new vehicle platform. In support of its petition, CAS cited 57 NHTSA complaints alleging an engine stall in the subject Pacifica vehicles, in addition to other information it provided.On December 1, 2017, NHTSA's Office of Defects Investigation opened Defect Petition 17-003 as requested by CAS.ODI sent an information request letter to Fiat Chrysler Automobiles (FCA), the manufacturer of the subject Pacifica vehicles, on December 12, 2017 requesting information related to engine stalling in Pacificas.The letter requested FCA provide the information by January 23, 2018.On January 11, 2018, and after technical discussions with ODI, FCA filed a defect information report advising the agency that it would conduct a safety recall of certain MY2017 Chrysler Pacificas to address a condition resulting in engine stalling without warning.The recall would address nearly 154,000 MY2017 Pacificas manufactured with engine control software that did not contain a routine intended to address loss of crankshaft position information required to keep the engine from stalling.FCA noted the condition could lead to a stall without illuminating a Malfunction Indicator Lamp, and without setting any Diagnostic Trouble Code.Given these conditions, dealer technicians would be unable to properly diagnose, much less correct the cause of the stalling, which resulted in additional stalling events and significant consumer frustration.ODI reviewed consumer complaints it received through the date of FCA's recall filing and identified 88 alleging engine stalling.The ODI complaints generally describe stalling that occurs at low engine (RPM) and/or vehicle speeds, and are consistent in that regard with most of the 445 reports FCA provided.Also both the ODI and FCA reports note that the engine could be readily restarted after stalling.Both circumstances are consistent with the root cause FCA identified and is conducting a recall to address.Additionally, FCA was able to identify an older vehicle population that used the same engine as the MY2017 Pacifica, however the vehicles were manufactured with the remedy level software; according to FCA reports of stalling in this population were significantly lower.No crash or injury reports were identified in either the ODI or FCA reports.Certain MY2017 and all MY2018 Pacificas were manufactured with the remedy level software and are thus not included in the recall action.In view of the recall action FCA has announced, ODI considers the petition moot and is closing the action without a grant or deny decision.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.Reference (ODI) numbers for the above NHTSA complaints:11060960, 11060808, 11060711, 11057809, 11057520, 11057493, 11057171, 11057169, 11057025, 11055566, 11055031, 11054808, 11054746, 11054717, 11054274, 11054085, 11053669, 11053588, 11053553, 11053322, 11052905, 11052892, 11052654, 11052336, 11051390, 11051158, 11048832, 11048728, 11048720, 11048661, 11048626, 11048175, 11047936, 11047831, 11047793, 11047687, 11047684, 11047399, 11045061, 11042619, 11040610, 11040502, 11040294, 11039494, 11035468, 11034698, 11033417, 11032016, 11030729, 11029903, 11025266, 11025119, 11023691, 11023539, 11022835, 11022154, 11021223, 11019457, 11016083, 1101