THE FUEL RAIL FEEDING THE FUEL INJECTION LEAKS AT THE CRIMP ON THE LINE. THIS CAUSED A MAJOR FUEL LEAK ON UNDER THE INTAKE MANIFOLD. I SAW BY SEARCHING THE WEB SITE THAT SEVERAL OTHERS HAVE COMPLAINED OF THE SAME PROBLEM. I HAD TO HAVE THE ENTIRE FUEL RAIL REPLACED AT A COST OF $650.48. THIS SHOULD HAVE BEEN A RECALL DUE TO PROP…
Read full complaint
THE FUEL RAIL FEEDING THE FUEL INJECTION LEAKS AT THE CRIMP ON THE LINE. THIS CAUSED A MAJOR FUEL LEAK ON UNDER THE INTAKE MANIFOLD. I SAW BY SEARCHING THE WEB SITE THAT SEVERAL OTHERS HAVE COMPLAINED OF THE SAME PROBLEM. I HAD TO HAVE THE ENTIRE FUEL RAIL REPLACED AT A COST OF $650.48. THIS SHOULD HAVE BEEN A RECALL DUE TO PROPENSITY FOR FIRE HAZARD. WHEN I WAS INSPECTING THE LEAK I GOT SPRAYED IN THE FACE AND EYES WITH GASOLINE PAINFULLY. *AK
NHTSA ODI #10196391
120,000 miles · Jan 19, 2005
Fuel System, Gasoline
91 CHRYSLER FIFTH AVENUE - LEAKING JOINT IN OEM FUEL RAIL. I BELIEVE THE ORIGINAL DESIGN WAS TO BE ABLE TO ROTATE FRONT AND BACK RAILS TO ALIGN INJECTORS DURING ASSEMBLY. THIS JOINT IS SEALED AT FACTORY WITH NO REPLACEMENT PARTS AVAILABLE, EXCEPT FOR THE WHOLE FUEL RAIL. LEAKING FUEL LAY ON TOP MOTOR AND COULD BE VERY HAZARDOUS …
Read full complaint
91 CHRYSLER FIFTH AVENUE - LEAKING JOINT IN OEM FUEL RAIL. I BELIEVE THE ORIGINAL DESIGN WAS TO BE ABLE TO ROTATE FRONT AND BACK RAILS TO ALIGN INJECTORS DURING ASSEMBLY. THIS JOINT IS SEALED AT FACTORY WITH NO REPLACEMENT PARTS AVAILABLE, EXCEPT FOR THE WHOLE FUEL RAIL. LEAKING FUEL LAY ON TOP MOTOR AND COULD BE VERY HAZARDOUS IF IGNITED. *NM
NHTSA ODI #10107543
75,600 miles · Nov 7, 2004
Fuel System, Gasoline
1991 CHRYSLER NEW YORKER FIFTH AVENUE V6 3.3L. I INCURRED 2 FUEL LEAKS FROM THE FUEL INTAKE FUEL RAIL. EACH OCCURRED AT BOTH 'U' JOINTS. THE FUEL IS LEAKING DIRECTLY INTO THE ENGINE. MY RESEARCH ONLINE INDICATES THAT A GREAT NUMBER OF CHRYSLERS HAVE SIMILAR PROBLEMS. OBVIOUSLY SIMULTANEOUS FUEL LEAKS INTO AN ENGINE IS EXTREMELY …
Read full complaint
1991 CHRYSLER NEW YORKER FIFTH AVENUE V6 3.3L. I INCURRED 2 FUEL LEAKS FROM THE FUEL INTAKE FUEL RAIL. EACH OCCURRED AT BOTH 'U' JOINTS. THE FUEL IS LEAKING DIRECTLY INTO THE ENGINE. MY RESEARCH ONLINE INDICATES THAT A GREAT NUMBER OF CHRYSLERS HAVE SIMILAR PROBLEMS. OBVIOUSLY SIMULTANEOUS FUEL LEAKS INTO AN ENGINE IS EXTREMELY DANGEROUS. PLEASE HAVE THESE RECALLED. THANK YOU. *JB
NHTSA ODI #10098410
65,000 miles · Apr 17, 2004
Fuel System, Gasoline
FUEL RAIL LEAKING GAS. STRONG SMELL OF GAS (INTERMITTENT) FOR LAST 6 YEARS. ONLY RECENTLY FOUND CAUSE. HOW MUCH DAMAGE TO MY HEALTH? LUCKY CAR HAS NOT CAUGHT FIRE. AND NOW CAN'T EVEN FIND A REPLACEMENT PART! *AK
NHTSA ODI #10066342
Mileage unknown · Apr 16, 2002
Fuel System, Gasoline
GAS IS LEAKING AND CAUSING FUMES TO COME INTO THE CAB OF VEHICLE. IT HESITATES TO START. CONSUMER FEELS THIS IS VERY DANGEROUS TO HEALTH. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8007733
Mileage unknown · Dec 26, 2000
Fuel System, Gasoline
FUEL RAIL IS LEAKING FUEL ONTO ENGINE, CAUSING GAS ODOR IN PASSENGER COMPARTMENT AND FIRE HAZARD.
NHTSA ODI #738294
Mileage unknown · Feb 14, 2000
Fuel System, Gasoline
FUEL LINE IS LEAKING NEXT TO IGNITION COIL PACKAGE, CAUSING A FIRE HAZARD. *AK
NHTSA ODI #856803
Mileage unknown · Oct 14, 1999
Fuel System, Gasoline
WAS HAVING THE VEHICLE SERVICED FOR AN OIL CHANGE AND NOTICED THE FUEL INJECTION LINE HAD A CRACK OR SPLIT WHICH CAUSED A FUEL LEAK.CONTACTED DEALER. *AK
NHTSA ODI #850711
Mileage unknown · Jun 22, 1998
Fuel System, Gasoline
FUEL RAIL IS LEAKING FUEL ONTO ENGINE, CAUSING GAS ODOR. PART IS ON BACKORDER. *AK
WATER LEAKING UNDER WINDSHIELD COWL IN AREA ABOVE HEATER BLOWER MOTOR RESISTOR BLOCK RESULTS IN CORROSION OF THE RESISTOR TERMINALS.
Consequence & remedy
Consequence: CORROSION OF THE RESISTOR TERMINALS INCREASES ELECTRICALRESISTANCE, LEADING TO OVERHEATING AND POSSBLE IGNITION OF THE WIRING CONNECTORSAND INSULATION, CAUSING A FIRE IN THE COWL AREA.
Remedy: THE BLOWER MOTOR RESISTOR BLOCK WILL BE REPLACED, AND A MASTIC PATCH APPLIED TO SEAL THE COWL AGAINST WATER ENTRY. DAMAGED WIRE CONNECTORS WILL BE REPLACED.
FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.
Consequence & remedy
Consequence: LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.
Illustration