Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports9 fire reports4 injury reports

Electrical System complaints

119 reports

Clear category filter

45,213 miles · Nov 6, 2014

Electrical SystemElectronic Stability Control (esc)Service Brakes

Read full complaint

ON THE AFTERNOON OF 11/5/2014 I WAS DRIVING AT A SPEED OF APPROX. 45-50 MPH WHEN I NOTICED MY 2011 CHRYSLER 300 MAKING A WHINING SOUND. SHORTLY AFTER THAT I SMELLED WHAT SEEMED LIKE BURNING PLASTIC. I THEN NOTICED THAT MY ABS AND ESC LIGHTS APPEARED ON THE DASHBOARD. A MESSAGE STATING "BATTERY SAVING MODE" APPEARED ON THE HUD AND EVERYTHING BEGAN TO SHUTDOWN. I HAD ZERO CONTROL OVER THE STEERING AND BRAKING. WHAT'S SO BAD IS THAT I HAD MY 20 MONTH OLD AND MY 10 YEAR OLD KIDS IN THE VEHICLE AT THE TIME. I WAS UNABLE TO JUMP START THE CAR AND ENDED UP HAVING TO GET IT TOWED TO A CHRYSLER DEALER. *TR

NHTSA ODI #10653067

79,700 miles · Nov 5, 2014

Electrical SystemElectronic Stability Control (esc)

Read full complaint

ON SATURDAY 11-1-14 I STARTED THE CAR AND NOTICED THAT IT SOUNDED AS THOUGH THERE WAS A SLIGHT HESITATION STARTING. NO WARNINGS WERE PRESENT EVEN WHEN I REVIEWED ALL THE POSSIBLE ONES VIA THE INFORMATION CENTER. I DROVE THE CAR TO 2 DESTINATIONS AND WITH EACH START I NOTICED THE SAME HESITATION WITH INCREASING TIME. AGAIN NO MESSAGES PROVIDED BY THE VEHICLE. ON THE 3RD DESTINATION THE CAR WOULD NOT START AT ALL EVEN WITH ATTEMPTS TO JUMP START THE CAR. I THEN PURCHASED A BATTERY AND DROVE TO THE AUTO ZONE NEARBY AND THEIR TESTER REVEALED A DEAD BATTERY SO LOW THAT A JUMP WAS NOT POSSIBLE. I TOOK THE CAR TO MY DEALER WITH THE INFO ABOUT RECALL P60 DATED 10-8-14 THAT MY VEHICLE PERFECTLY MATCHED. THE ALTERNATOR WAS REPLACED THEN I HAD 4 EPISODES OF FULL PANEL ALARMS DISPLAYED AND LOSS OF ABILITY TO STEER. AUTO HAS BEEN RETURNED TO DEALER. *TR

NHTSA ODI #10652712

51,500 miles · Nov 4, 2014

Electrical System

TL* THE CONTACT OWNS A 2011 CHRYSLER 300. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE BATTERY SAVER MODE LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 51,500.

NHTSA ODI #10652398

55,000 miles · Nov 3, 2014

Electrical SystemExterior Lighting

Read full complaint

I WAS DRIVING AND MY BATTERY SAFE MODE LIGHT WAS ON. THE VEHICLE ALL OF A SUDDEN BEGAN DISPLAYING OTHER LIGHTS SUCH AS MY ENGINE LIGHT AND A CAR WITH SKID LINES BELOW IT LIGHT. ALL OF A SUDDEN I LOST POWER IN MY NAVIGATION SYSTEM WHILE DRIVING MY OTHER LIGHTS BEGAN TO TURN ( MIND YOU IT IS 9:30 ON HALLOWEEN NIGHT). MY CAR BEGINS TO STALL WHILE I HAVE MY SON, AND 3 OTHER CHILDREN IN THE CAR. LUCKILY I WAS ABLE TO PULL OFF OF THE ROAD (SAFELY WITH MY LIGHTS OUT) INTO A SCHOOL. NEVER ONE DID I GET A WARNING THAT MY CAR WOULD SHUT COMPLETELY DOWN. TURNED VEHICLE OFF AND BACK ON IN HOPES OF GETTING BACK UP AND RUNNING AND TO NO AVAIL. HAD TO GET MY CAR TOWED THE FOLLOWING MORNING. THIS COULD HAVE RESULTED IN AN ACCIDENT HAD I BEEN ON MY WAY HOME ON A BUSY I-10 HWY. LUCKILY I WAS DROPPING MY BROTHER OFF AND NEVER MADE IT ON THE HWY. TOOK THE VEHICLE TO THE DEALERSHIP AND THEY TOLD ME IT WAS MY ALTERNATOR. THE VEHICLE WAS PURCHASED BRAND NEW 3 YEARS AGO AND SHOULD NOT BE HAVING THIS SAFETY ISSUE. CAR IS OUTSIDE OF WARRANTY AND I PAID FOR THE DEALER TO REPAIR THE ALTERNATOR BUT WHEN I REQUESTED MY DEFECTIVE ALTERNATOR BACK THEY REFUSED TO GIVE IT TO ME WITHOUT PAYING THEM AN ADDITIONAL FEE. I WANTED TO TAKE THE ALTERNATOR TO GET INSPECTED BY ANOTHER MECHANIC FOR FURTHER INSPECTION. *TR

NHTSA ODI #10652306

80,200 miles · Nov 3, 2014

Electrical System

Read full complaint

SATURDAY MORNING, I WAS DRIVING ON THE HIGHWAY AND MY 'BATTERY SAVING MODE' LIGHT CAME ON. THEN THE BRAKE LIGHT CAME ON EVEN THOUGH THE BRAKE WAS NOT ENGAGED. THEN THE WIPERS WENT ON. NUMEROUS OTHER LIGHTS CAME ON INDICATING TROUBLE. THE RADIO WENT OFF ON ITS OWN AND I TRIED REPEATEDLY TO GET IT BACK ON AND NO LUCK. THE ON SCREEN PRINT CHANGED TO ANOTHER LANGUAGE. I EXITED THE HIGHWAY TO HEAD TO THE DEALER AND ON THE EXIT RAMP, MY CAR LOST ALL POWER. LUCKILY, WAS IN ONE OF THE TWO LANES AND CARS WERE ABLE TO GO AROUND ME. A GENTLEMAN WHO HAD WITNESSED MY TROUBLE ON THE HIGHWAY PULLED OVER TO HELP ME. I COULDN'T EVEN UNLOCK THE OTHER DOORS OR OPEN THE TRUNK (WHERE THE BATTERY IS LOCATED) AND HE COULD NOT GET IN AS I HAD THE SEAT PULLED FORWARD TO DRIVE AND IT WOULD NOT BUDGE DUE TO NO ELECTRIC POWER. I HAD POLICE WAIT BEHIND ME FOR AN HOUR AND A HALF UNTIL THE TOW TRUCK ARRIVED. THE CAR WAS TOWED TO THE DEALER AT MY EXPENSE. THE DEALER ADVISED THIS MORNING AFTER DOING A DIAGNOSTIC TEST THE ALTERNATOR BURNED UP THE BATTERY AND I HAVE TO HAVE BOTH OF THEM REPLACED! COST IS APPROX. $1100. I CONTACTED CHRYSLER AND THEY ADVISED THIS VEHICLE IS NOT SUBJECT TO A RECALL. MY ISSUES SOUND IDENTICAL TO OTHERS REPORTED HERE! HOW IN THE WORLD CAN THIS BE ACCEPTABLE? ALSO THIS IS MY 4TH CHRYSLER 300. I AM VERY LUCKY THIS DID NOT OCCUR ON THE HIGHWAY ITSELF IN THE MIDST OF RUSH HOUR. *TR

NHTSA ODI #10652077

68,500 miles · Oct 29, 2014

Electrical System

Read full complaint

IN RUSH HOUR TRAFFIC GOING 60MPH ON THE HIGHWAY MY CAR STARTED LOSING POWER, THE RADIO FLICKERED ON OFF AND MY CAR WAS STILL GOING BUT MY GAUGES THE RADIO, NOTHING WORKED. I WAS IN THE FAR LEFT LANE AND WAS ALMOST HIT BY A MAC TRUCK, TRYING TO CROSS OVER THREE LANES TO GET TO THE SERVICE ROAD. THE ENGINE STALLED, IT WAS HARD TO STEER AND LUCKILY THERE WAS A GAS STATION NEARBY. THREE PEOPLE TRIED TO GIVE ME A JUMP AND NOTHING WOKED AND THERE WAS NO PRIOR WARNINGS. I HAD TO CALL A TOW TRUCK ONLY TO FIND THAT MY ALTERNATOR AND BATTERY WERE FRIED. THE WORST THING IS I CALLED CHRYSLER TO TELL THEM ABOUT THE P60 RECALL AND THEY DID NOT OWN UP TO THE DEFAULT UNTIL THE SECOND TIME I CALLED FROM DOING MY OWN RESEARCH. THIS COULD HAVE BEEN REALLY BAD FOR ME BECAUSE THERE WAS NOTHING THAT I COULD DO AFTER THE ENGINE STALLED. I HAVE OWNED THREE DIFFRENT 300S OVER THE LAST TEN YEARS AND THIS WILL BE MY LAST. SOMEONE SHOULD DO SOMETHING BEFORE SOMEONE LOSES THEIR LIFE AND FAMILY MEMBERS TO ISSUES THAT DESERVE IMMEDIATE ATTENTION. ADDITIONALLY, I HAVE SPENT ALL DAY ON THE PHONE TRYING TO REPLACE THIS PART AND THE ONLY PLACE THAT CARRIES THE PART IS CHRYSLER, WHAT A RIPOFF. THIS WILL COST ME OVER A THOUSAND DOLLARS FOR A CAR THAT I HAVE NOT HAD A YEAR AND CURRENTLY STILL MAKING PAYMENTS ON. *TR

NHTSA ODI #10651254

65,000 miles · Oct 26, 2014

Electrical SystemEngineService Brakes

Read full complaint

ON MORNING OF 10/24/14 WHEN VEHICLE WAS STARTED A MESSAGE CAME ON STATING "BATTERY SAVING MODE" LOOKED AT MANUAL THERE WAS NO INSTRUCTIONS AS TO WHAT THAT MEANT. THEN THE VEHICLE WAS DRIVEN, WHILE DRIVING THE RPM INDICATOR WOULD MOVE UP ON ITS OWN AND THEN THE BRAKE LIGHT, TRACTION AND ABS WARNING LIGHT CAME ON AND STAYED ON. AFTER THE WARNING CAME ON THE CAR DESPITE PRESSING ON GAS PEDAL WOULD NOT ACCELERATE THEN A RATTLING NOISE CAME ON SO I QUICKLY PROCEEDED TO ATTEMPT TO EXIT THE INTERSTATE FREEWAY. AS I TRIED TO DO THAT THE STEERING STARTED LOCKING UP, I HAD TO PUSH VERY HARD ON THE BRAKE TO SLOW THE CAR DOWN AND STOP IT. THE VEHICLE COMPLETELY SHUT OFF, UNABLE TO TURN ON OR OPERATE ANYTHING. THE VEHICLE COULD NOT BE JUMP STARTED. WHEN THE VEHICLE WAS TOWED TO THE CHRYSLER DEALERSHIP THEY WERE UNABLE TO CHARGE UP THE BATTERY AND NOW THEY BELIEVE AN ALTERNATOR FAILURE MAY BE THE REASON FOR THE ENGINE TO STALL. *TR

NHTSA ODI #10650080

43,590 miles · Oct 24, 2014

Electrical System

Read full complaint

I WAS DRIVING WHEN I SMELLED A "BURNING MARSHMALLOW" SMELL COMING FROM MY CAR. ALMOST IMMEDIATELY, THE ABS LIGHT, A CAR WITH ZIGZAGS ICON, AND THE BRAKE LIGHT FLASHED ON MY SCREEN. FOLLOWED BY THE RADIO, AIR VENTS, AND POWER STEERING SHUTTING ITSELF ON AND OFF. WITHIN 1-2 MILES MY CAR WAS DONE. MY ALTERNATOR WAS TOAST. CHRYSLER REFUSES TO ACKNOWLEDGE THE RECALL ON THE 3.6 L ENGINE, 160 AMP ALTERNATORS. SO UNDER MY EXTENDED WARRANTY THEY PUT ANOTHER OEM ALTERNATOR IN MY CAR. I ASKED THE SERVICE MANAGER AT THE DEALERSHIP THAT CHRYSLER SENT ME TO, REPLACE THE ALTERNATOR WITH A DIFFERENT ONE THAT ISN'T RECALLED. THEY REFUSED BECAUSE CHRYSLER HASN'T "LAUNCHED" THE RECALL YET. HOW RIDICULOUS IS THIS? WHEN THE RECALL IS LAUNCHED I WILL HAVE TO AGAIN REPLACE THE ALTERNATOR. APPROX. NOV. 28, 2014. HOPEFULLY I WON'T EXPERIENCE A FRYING OUT ALTERNATOR BEFORE THEN. VIN [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10649662

Mileage unknown · Oct 19, 2014

Electrical SystemExterior Lighting

Read full complaint

ON OCTOBER 11, 2014 I HAD DRIVEN MY CAR TWICE THAT DAY. THAT EVENING WHILE DROPPING MY LITTLE COUSIN BACK HOME, MY CAR STARTED SPUTTERING, LIGHTS STARTED BLINKING AND THE CAR CUT OFF AND WOULD NOT TURN BACK ON. IT WAS COMPLETELY DEAD, NO POWER OR NOTHING. I AM HIGHLY DISAPPOINTED IN CHRYSLER. I HAVE HAD THIS CAR NOT EVEN FIVE MONTHS AND THIS HAS HAPPENED. NOW IT'S JUST SITTING IN MY YARD AND I AM HAVING TO CATCH A TAXI TO WORK. IT TO BEAUTIFUL OF A CAR TO JUST SIT THERE. I TOOK IT TO THE DEALERSHIP AND THEY COMPLETED A DIAGNOSTIC AND SAID IT WAS THE ALTERNATOR AND THEY WANT $800.00 TO REPAIR. CAN'T AFFORD TO FIX IT, BECAUSE ALL OF MY MONEY IS GOING TOWARDS TAXI FARE, AND THE WARRANTY DOESN'T COVER REPAIRS. JUST IMAGINE IF I WERE DRIVING WITH MY KIDS IN THE CAR AND THIS HAPPENED. *TR

NHTSA ODI #10648679

48,000 miles · Oct 15, 2014

Electrical SystemEngineFire

TL* THE CONTACT OWNS A 2011 CHRYSLER 300. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE ENGINE STALLED AS THE BATTERY SAVER WARNING INDICATOR ILLUMINATED AND SMOKE STARTED TO EMIT FROM THE VENT. THE PROBLEM RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. T…

Read full complaint

NHTSA ODI #10644867

Official recalls

19V018000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2019

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.

18V021000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

17V435000 · Electrical System:alternator/generator/regulator

Jul 10, 2017

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

16V352000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence & remedy

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

14V634000 · Electrical System:alternator/generator/regulator

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Consequence & remedy

Consequence: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

13V118000 · Air Bags

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Chrysler 300, Dodge Challenger, and Dodge Charger vehicles manufactured April 11, 2011, through December 14, 2011. The affected vehicles may have improperly sized terminal crimps on the seat side-airbag wiring harness which may cause the seat side-airbags to malfunction and illuminate the airbag warning light.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment the airbags may not operate as designed, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace both driver and passenger seat airbag wiring harnesses, free of charge. The recall began on April 22, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N07.

12V197000 · Electrical System:wiring:fuses And Circuit Breakers; Service Brakes, Air:antilock:control Unit/module

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence & remedy

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Service Brakes, Air:antilock:control Unit/module

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 300 AND DODGE CHARGER VEHICLES. THESE VEHICLES MAY LOSE ABS/ESC SYSTEM FUNCTION DUE TO AN OVERHEATED POWER DISTRIBUTION CENTER.

Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL RELOCATE THE ABS/ESC SYSTEM FUSE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module