IllustrationCAR STALLED OUT WHILE DRIVING. THIS HAPPENED SEVERAL TIMES. SOMETIMES WHILE DRIVING ON A STRAIGHT ROAD AND SOMETIMES WHEN MAKING A SHARP TURN TO PARK. CAR HORN ALSO STARTED GOING OFF ON IT'S OWN WHILE DRIVING. HAD TO HAVE THE TIPM MODULE REPLACED. THIS IS A SAFETY ISSUE.
2012 Chrysler 200
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chrysler 200 do not stand out strongly from the model-year median of 336.
About this comparison →How this year compares
Owner complaints by model year
Compare all 200 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1020–25K
9125–50K
10450–75K
8975–100K
65100–150K
18150K+
469 reports with mileage · 169 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports4 fire reports23 injury reports
What owners actually said
638 reportsTL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT PASSENGER SIDE BLOWER FAILED TO BLOW HOT AIR WHICH CAUSED THE DEFROSTER TO BECOME INOPERABLE. AS A RESULT, THERE WAS LIMITED VISIBILITY FOR THE DRIVER. THE VEHICLE WAS TAKEN TO PAT CLEMMONS INC LOCATED AT 1720 S. MARSHALL ST. BOONE IA, (515)432-5150 TO BE DIAGNOSE…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT PASSENGER SIDE BLOWER FAILED TO BLOW HOT AIR WHICH CAUSED THE DEFROSTER TO BECOME INOPERABLE. AS A RESULT, THERE WAS LIMITED VISIBILITY FOR THE DRIVER. THE VEHICLE WAS TAKEN TO PAT CLEMMONS INC LOCATED AT 1720 S. MARSHALL ST. BOONE IA, (515)432-5150 TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE HEATER COIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
STARTED WITH THE ABS AND TRACTION CONTROL LIGHTS COMING ON, MY CRUISE CONTROL STOPPED COMING ON AND A WEEK LATER I PULLED OUT OF THE BANK AND STOPPED ALONE SIDE OF THE CURB AND THE CAR JUST SHUT OFF, NO RESTARTING AT ALL NOTHING HAPPENS, THE RIGHT INFO PANEL SAID NO BUS, ITS AT THE CHRYSLER DEALER SHIP NOW AND THEY CAN FIND NOTH…
Read full complaint
STARTED WITH THE ABS AND TRACTION CONTROL LIGHTS COMING ON, MY CRUISE CONTROL STOPPED COMING ON AND A WEEK LATER I PULLED OUT OF THE BANK AND STOPPED ALONE SIDE OF THE CURB AND THE CAR JUST SHUT OFF, NO RESTARTING AT ALL NOTHING HAPPENS, THE RIGHT INFO PANEL SAID NO BUS, ITS AT THE CHRYSLER DEALER SHIP NOW AND THEY CAN FIND NOTHING WRONG WITH IT AT ALL, EVEN THOUGH IT WONT COME ON.
I OWN A 2012 CHRYSLER 200, I LOVE MY CAR; HOWEVER, THE HEAD LIGHTS ARE POINTING TOWARDS THE GROUND MAKING IT ALMOST IMPOSSIBLE TO SEE ANYTHING IN FRONT OF ME WHILE DRIVING. I'VE CHANGED REPLACED THE HEADLIGHT BULBS AS WELL AS CLEANED THE HEADLAMP. UNKNOWN 2. DURING THE WINTER MONTHS MY CAR MAKES THE GRINDING NOISE WHEN STARTI…
Read full complaint
I OWN A 2012 CHRYSLER 200, I LOVE MY CAR; HOWEVER, THE HEAD LIGHTS ARE POINTING TOWARDS THE GROUND MAKING IT ALMOST IMPOSSIBLE TO SEE ANYTHING IN FRONT OF ME WHILE DRIVING. I'VE CHANGED REPLACED THE HEADLIGHT BULBS AS WELL AS CLEANED THE HEADLAMP. UNKNOWN 2. DURING THE WINTER MONTHS MY CAR MAKES THE GRINDING NOISE WHEN STARTING UP.
I ONLY HAVE HEAT ON THE DRIVERS SIDE OF THE CAR. WE JUST HIT OUR 100,000 BUMPER TO BUMPER WARRANTY. HAD THE CAR IN THE SHOP TWICE WITH COOLANT SMELLS. MECHANICS NEVER FOUND A PROBLEM. EVERYWHERE I READ THERE ARE TONS OF COMPLAINTS ABOUT THIS ISSUE. THIS IS A $1000.00 REPAIR! A FLUSH IS $150-170. WE HAVE ALREADY DONE THIS. I'M R…
Read full complaint
I ONLY HAVE HEAT ON THE DRIVERS SIDE OF THE CAR. WE JUST HIT OUR 100,000 BUMPER TO BUMPER WARRANTY. HAD THE CAR IN THE SHOP TWICE WITH COOLANT SMELLS. MECHANICS NEVER FOUND A PROBLEM. EVERYWHERE I READ THERE ARE TONS OF COMPLAINTS ABOUT THIS ISSUE. THIS IS A $1000.00 REPAIR! A FLUSH IS $150-170. WE HAVE ALREADY DONE THIS. I'M READY TO TRADE IT IN BUT I DO LOVE MY CAR. NOT SURE ABOUT HOW I FEEL ABOUT CHRYSLER KNOWING ABOUT A ISSUE AND NOT OFFERING ASSISTANCE WITH THE REPAIR. MAYBE THEY BETTER SEND OUT A MASSIVE REBATE TO OLD OWNERS IN HOPES OF THEM STAYING A CUSTOMER.
CAR WAS IN MOTION LEAVING A SHOPPING AREA, TURNING RIGHT AND ACCELERATING ONTO A 4 LANE HIGHWAY. AS 45 MPH WAS ACHIEVED, THE CAR DECELERATED AND STALLED. THE CHECK ENGINE LIGHT AND THE ELECTRONIC THROTTLE CONTROL LIGHT CAME ON. I LOOKED UP THE ETC INFORMATION AND READ I MAY BE ABLE TO TRY AGAIN TO DRIVE THE CAR. I DID TRY A…
Read full complaint
CAR WAS IN MOTION LEAVING A SHOPPING AREA, TURNING RIGHT AND ACCELERATING ONTO A 4 LANE HIGHWAY. AS 45 MPH WAS ACHIEVED, THE CAR DECELERATED AND STALLED. THE CHECK ENGINE LIGHT AND THE ELECTRONIC THROTTLE CONTROL LIGHT CAME ON. I LOOKED UP THE ETC INFORMATION AND READ I MAY BE ABLE TO TRY AGAIN TO DRIVE THE CAR. I DID TRY AND ROLLED ON THE SHOULDER FOR ABOUT 1/4 MILE BEFORE HAVING TO ACCELERATE THOUGH AN INTERSECTION. AT THAT POINT, CAR REPEATED THE ABOVE FAILURE AND STALLED. I WAS ABLE TO MAKE A RIGHT TURN AND COAST INTO A PARKING LOT. THE CAR WAS TOWED. WHILE WAITING ON THE TOW, I READ SEVERAL REPORTS OF THE SAME ISSUE OCCURRING IN THIS MODEL VEHICLE, OFTEN WHILE DRIVING ON THE INTERSTATE OR IN OTHER DANGEROUS LOCATIONS LIKE AN INTERSECTION. THIS FAILURE HAPPENED WITH NO WARNING - NO SPUTTERING, HESITATION OR WARNING LIGHTS UNTIL THE FAILURE OCCURRED. THIS FAILURE COULD RESULT IN SERIOUS INJURY OR DEATH. IT LOOKS TO ME TO BE A KNOWN ISSUE AND SHOULD BE SUBJECT TO RECALL.
TOOK CAR IN TO DEALERSHIP YEARS AGO TO HAVE HEAD REST AND AIRBAGS FIXED. RECEIVED A NOTICE BY INPUTTING MY VIN THAT THESE FIXES WERE INCOMPLETE . ALSO DISCOVERED THAT THE 3.6 PENTASTAR ENGINE FROM THE FACTORY HAD SUBSTANDARD ENGINE BEARINGS WHICH COULD RESULT IN THE ENGINE SEIZURE AND THE REMEDY WAS FOR THE FACTORY TO REPLACE TH…
Read full complaint
TOOK CAR IN TO DEALERSHIP YEARS AGO TO HAVE HEAD REST AND AIRBAGS FIXED. RECEIVED A NOTICE BY INPUTTING MY VIN THAT THESE FIXES WERE INCOMPLETE . ALSO DISCOVERED THAT THE 3.6 PENTASTAR ENGINE FROM THE FACTORY HAD SUBSTANDARD ENGINE BEARINGS WHICH COULD RESULT IN THE ENGINE SEIZURE AND THE REMEDY WAS FOR THE FACTORY TO REPLACE THE ENGINE. MY 2012 CHRYSLER 200 WAS MANUFACTURED DURING THIS TIME FRAME, YET WAS NEVER NOTIFIED BY THE MANUFACTURER OF THIS DANGEROUS CONDITION.
2012 CHRYSLER 200 6XX,XXX MILES. CAR WILL SHIFT TO NEUTRAL WHILE IN OPERATION; SHIFTS OUT OF GEAR WHEN ACCELERATING CAUSING SEVERAL NEAR ACCIDENTS WHILE IN TRAFFIC. HAS LEFT VEHICLE IMMOBILE IN ROADWAY.
OUR CAR STARTED OVER HEATING & SMOKE STARTED COMING OUT, THE CAR WAS BEEPING & THE GAUGE FOR THE HEAT WAS SKY ROCKETING TO THE H. WHITE SMOKE STARTED COMING OUT OF THE LEFT SIDE OF THE ENGINE & THEN THE CAR WAS MAKING A KNOCKING SOUND. AT THE STOPLIGHT WAITING TO TURN OUR CAR ENDED UP SHUTTING OFF & NOT STARTING.
MY CHRYSLER 200 WAS PURCHASED ABOUT TWO MONTHS AGO SINCE I PURCHASED IT FROM FLORIDA AND I RESIDE IN ALABAMA I WAS TOLD BY THE LOCAL DEALERSHIP IN MOBILE THAT THEY COULD NOT DIAGNOSE OR REPAIR IT BECAUSE THEY HAVE NO HISTORY. MY CAR IS RANDOMLY STALLING AND LOOSING ALL POWER TO ENGINE WHEN ATTEMPTING TO STOP OR SLOW DOWN THERE I…
Read full complaint
MY CHRYSLER 200 WAS PURCHASED ABOUT TWO MONTHS AGO SINCE I PURCHASED IT FROM FLORIDA AND I RESIDE IN ALABAMA I WAS TOLD BY THE LOCAL DEALERSHIP IN MOBILE THAT THEY COULD NOT DIAGNOSE OR REPAIR IT BECAUSE THEY HAVE NO HISTORY. MY CAR IS RANDOMLY STALLING AND LOOSING ALL POWER TO ENGINE WHEN ATTEMPTING TO STOP OR SLOW DOWN THERE IS NO CODES ON DASHBOARD. PCM WAS REPLACED STILL SAME ISSUE. IT IS VERY LIKELY THIS WILL CAUSE AN ACCIDENT ESPECIALLY BECAUSE THERE IS NO WARNING. IT CUT OFF TONIGHT ON MY WAY HOME FROM WORK WHILE I WAS DRIVING AT 35MPH. THIS IS DANGEROUS
Official recalls
417V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
11V487000 · Engine And Engine Cooling
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.