IllustrationTHE STEERING WHEEL VIBRATES AND THERE IS A CLUNKING NOISE MADE THAT SOUNDS LIKE IT IS COMING FROM THE STEERING WHEEL COLUMN WHEN DRIVING. IT OCCURS AT ANY SPEED. IT FEELS LIKE THE STEERING COLUMN IS LOOSE TO A POINT. *TR
2012 Chrysler 200
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chrysler 200 do not stand out strongly from the model-year median of 336.
About this comparison →How this year compares
Owner complaints by model year
Compare all 200 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1020–25K
9125–50K
10450–75K
8975–100K
65100–150K
18150K+
469 reports with mileage · 169 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports4 fire reports23 injury reports
Steering complaints
45 reportsAWFUL POPPING NOISE TO FRONT END WHEN DRIVING. WORSENS OVER TIME . HAD TO SHOP 4 TIMES. THEY NOW ADMIT TO A PROBLEM WITH TIE RODS AT MANUFACTURE. DEALERSHIP IS OFFERING TO FIX WITH A $100 CO-PAY SINCE IT IS NOW OUT OF WARRANTY MILEAGE. I AM WORKING WITH CHRYSLER TO GET THE REST COVERED SINCE IT IS AN UNRESOLVED WARRANTY ISSUE. …
Read full complaint
AWFUL POPPING NOISE TO FRONT END WHEN DRIVING. WORSENS OVER TIME . HAD TO SHOP 4 TIMES. THEY NOW ADMIT TO A PROBLEM WITH TIE RODS AT MANUFACTURE. DEALERSHIP IS OFFERING TO FIX WITH A $100 CO-PAY SINCE IT IS NOW OUT OF WARRANTY MILEAGE. I AM WORKING WITH CHRYSLER TO GET THE REST COVERED SINCE IT IS AN UNRESOLVED WARRANTY ISSUE. *TR
A CLICKING NOISE IN STEERING WHEEL WHILE DRIVING NO MATTER HOW FAST YOU ARE GOING. ALSO, A KNOCKING NOISE WHEN DRIVING OVER BUMPS. SOMETIMES, THE CAR DOES NOT PICK UP SPEED FOR A WHILE WHEN DRIVING UP A HILL. *TR
AFTER DRIVING FOR ABOUT 15 MIN. YOU CAN START HEARING A CLUNKING NOISE COMING FROM THE LEFT SIDE, AND YOU CAN FEEL IT IN THE STEERING WHEEL. DON'T KNOW IF ITS STEERING OR SUSPENSION, BUT I GET EERIE FEELING THE CAR MAY LOCK UP. *TR
AFTER PUTTING ON 4 NEW TIRES AND NEW FRONT BRAKES, WE NOTICED AN ISSUE WITH THE STEERING COLUMN CLUNKING, AND FEELING VERY LOOSE. AFTER THREE TRIPS TO THE SERVICE COUNTER AT A CHRYSLER DEALERSHIP, (YOU WOULD THINK THAT THEY WOULD KNOW WHAT THE PROBLEM WAS), I HAVE FIGURED OUT THE ISSUE THANKS TO YOUTUBE. APPARENTLY, I THERE ARE …
Read full complaint
AFTER PUTTING ON 4 NEW TIRES AND NEW FRONT BRAKES, WE NOTICED AN ISSUE WITH THE STEERING COLUMN CLUNKING, AND FEELING VERY LOOSE. AFTER THREE TRIPS TO THE SERVICE COUNTER AT A CHRYSLER DEALERSHIP, (YOU WOULD THINK THAT THEY WOULD KNOW WHAT THE PROBLEM WAS), I HAVE FIGURED OUT THE ISSUE THANKS TO YOUTUBE. APPARENTLY, I THERE ARE MANY OTHERS HAVING THE SAME ISSUE. AND, I CALLED CHRYSLER DIRECTLY, AND THE GIRL THAT I SPOKE WITH STATED THAT THE PART HAD BEEN RECALLED ON OTHER CHRYSLER PRODUCTS, BUT NOT ON MY CAR. THIS PART NEEDS TO BE RECALLED. YOU FEEL LIKE YOU ARE DRIVING DOWN THE ROAD, AND THE CAR IS FALLING A PART. YOU FEEL LIKE PARTS COULD FLY OFF AT ANY TIME. VERY DISAPPOINTING! AND, JUST OUT OF WARRANTY. PLEASE VIEW THIS WEBSITE TO UNDERSTAND THE ISSUE. IT EXPLAINS IT IN DEPTH. HTTPS://WWW.YOUTUBE.COM/RESULTS?SEARCH_QUERY=CHRYSLER+200+CLUNKING+PROBLEM. *TR
2012 CHRYSLER 200 SHUT OFF WHILE DRIVING 45 MPH DOWN THE HWY WITH 2 CHILDREN IN THE CAR. I LOST POWER STEERING AND MY BRAKES. LUCKILY, I MADE IT TO THE SIDE OF THE ROAD. IT RESTARTED ONCE I TURNED THE KEY TO OFF FIRST, BUT SHUT OFF ON ME A SECOND TIME WHILE IDLING A FEW MINUTES LATER. I HAVE NOT DRIVEN IT SINCE. *JS
MY 2012 CHRYSLER 200 S STALLED ON A MAJOR HIGHWAY. AFTER COMING TO A COMPLETE STOP DUE TO TRAFFIC THE VEHICLE WOULD NOT ACCELERATE, THE STEERING LOCKED UP AND THEN IT SHUT OFF. THERE WERE NO MALFUNCTION LIGHTS OR ANY OTHER TYPE OF WARNING CALLED CHRYSLER AND THEY SAID THAT THERE ARE NO RECALLS FOR THIS DESPITE THERE BEING A NUMB…
Read full complaint
MY 2012 CHRYSLER 200 S STALLED ON A MAJOR HIGHWAY. AFTER COMING TO A COMPLETE STOP DUE TO TRAFFIC THE VEHICLE WOULD NOT ACCELERATE, THE STEERING LOCKED UP AND THEN IT SHUT OFF. THERE WERE NO MALFUNCTION LIGHTS OR ANY OTHER TYPE OF WARNING CALLED CHRYSLER AND THEY SAID THAT THERE ARE NO RECALLS FOR THIS DESPITE THERE BEING A NUMBER OF COMPLAINTS REPORTED. *TR
TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH IN RAINY WEATHER, THE REAR END OF THE VEHICLE BEGAN TO SKID. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE BOTH REAR TIRES WERE REPLACED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS DRIVEN ON WET ROAD SURFACES AT ANY G…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH IN RAINY WEATHER, THE REAR END OF THE VEHICLE BEGAN TO SKID. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE BOTH REAR TIRES WERE REPLACED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS DRIVEN ON WET ROAD SURFACES AT ANY GIVEN SPEED. THE VEHICLE WAS ALSO TAKEN TO AN AUTHORIZED DEALER WHERE A REAR END WHEEL ALIGNMENT WAS PERFORMED AND THE TOW WAS REPLACED. THE FAILURE PERSISTED AND THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.
PURCHASED THIS VEHICLE NEW OFF THE LOT APRIL 2012.THIS ISSUE I CURRENTLY HAVE BECAME AN ISSUE FOR ME IN FEB 2014 WITH THE WINTER WEATHER I ENTERED FREEWAY TRIED TO GAIN SPEED ONCE SPEEDOMETER HIT 50ISH NOTICED THE CAR BEGAN TO BRAKE LOOSE AND SWAY SIDE TO SIDE REALLY QUICK AND SCARY,IMMEDIATELY SLOWED DOWN SENSATION WENT AWAY C…
Read full complaint
PURCHASED THIS VEHICLE NEW OFF THE LOT APRIL 2012.THIS ISSUE I CURRENTLY HAVE BECAME AN ISSUE FOR ME IN FEB 2014 WITH THE WINTER WEATHER I ENTERED FREEWAY TRIED TO GAIN SPEED ONCE SPEEDOMETER HIT 50ISH NOTICED THE CAR BEGAN TO BRAKE LOOSE AND SWAY SIDE TO SIDE REALLY QUICK AND SCARY,IMMEDIATELY SLOWED DOWN SENSATION WENT AWAY COULD NOT DRIVE ABOVE 40MPH, WHILE ALL TRAFFIC AROUND ME ON THE FREEWAY WERE TRAVELING AT A MUCH GREATER SPEEDS I FIGURED IT WAS JUST BY CHANCE I HIT AN ICE PATCH.I ATTEMPTED TO SPEED UP AND ONCE HIT 45MPH THE SIDE TO SIDE SWAY ONCE AGAIN WAS PRESENT EXITED THE FREEWAY AND DO NOT TRAVEL ABOVE 40 IN ANY WET,SNOW,ICY WEATHER BUT REGARDLESS OF SPEED IF I HIT ANYTHING SLICK I SWAY, THE LOW SPEEDS JUST HELP ME MAINTAIN CONTROL OF THE CAR.MY HUSBAND THOUGHT I MUST JUST NEED A WINTER TIRE,(THERE ARE A SET OF 4 GOODYEAR EAGLES ON IT PRESENTLY) UNTIL HE DROVE IT AND DETERMINED THERE WAS DEFINITELY A SERIOUS ISSUE JACKED IT UP TO REVEAL THAT IT WAS THE INNER TIE RODS COMPLETELY WIPED OUT CONTRIBUTING TO THE SWAY.CONTACTED THE DEALERSHIP TO RESOLVE IT(MIND YOU THE MILEAGE WAS NOW AT 37050) WAS TOLD THEY WOULD DO AN INSPECTION FOR $85 AND WOULD CALL CHRYSLER TO SEE IF THEY WOULD HONOR A REPAIR SINCE IT IS OUT OF WARRANTY HOWEVER NO GUARANTEE THAT THE REPAIRS WOULD BE COVERED NON THE LESS A FRONT END ALIGNMENT.I COULD NOT LEAVE MY CAR FOR 3 DAYS FOR DIAGNOSIS NOR AFFORD 85$ THAT WOULD NOT EVEN GO TOWARDS THE REPAIR.I CALLED CHRYSLER ONLY TO BE TOLD THEY CAN NOT GUARANTEE ANYTHING NOR WOULD CHRYSLER CONSIDER ANYTHING UNTIL I HAVE AN INSPECTION DONE THAT THERE ARE NO DISCOUNTS NO COURTESY INSPECTION TO BE HAD.BOUGHT A NEW CAR TO AVOID ISSUES SUCH AS THESE. *TR
TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT WHILE DRIVING 35 MPH IN THE SNOW, THE VEHICLE WOULD SWAY TO THE LEFT AND RIGHT. THE CONTACT STATED THAT HE DECELERATED AND THE SWAYING STOPPED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT WHILE DRIVING 35 MPH IN THE SNOW, THE VEHICLE WOULD SWAY TO THE LEFT AND RIGHT. THE CONTACT STATED THAT HE DECELERATED AND THE SWAYING STOPPED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000... UPDATED 03/24/14 *BF
Official recalls
417V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
11V487000 · Engine And Engine Cooling
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.