IllustrationBattery failure is still under warranty but they don’t make batteries any more
2018 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2018 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 50 of 222 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports1 injury reports
What owners actually said
222 reportsReduction of power , impossible to charge the kilometre says 21 kkm drops from 21 to 0 and the mountain settings dont run, I drive on maintenance , when charging at paying station does not charge,
On [XXX], while traveling on [XXX] near Rockingham, NC, the car suddenly decelerated, all of the dash warning lights came as well as a 'Reduced Propulsion' message, stop driving the car immediately. We did, called a tow truck, waited an hour and was towed to Diffenbach Chevrolet in Rockingham. They found multiple trouble code…
Read full complaint
On [XXX], while traveling on [XXX] near Rockingham, NC, the car suddenly decelerated, all of the dash warning lights came as well as a 'Reduced Propulsion' message, stop driving the car immediately. We did, called a tow truck, waited an hour and was towed to Diffenbach Chevrolet in Rockingham. They found multiple trouble codes and a bulletin saying the EGR valve needed to be replaced. (As it happens, these have been on a nationwide backorder for years.) The technician cleaned the valve and the car limped home after it sat at the dealership for a few weeks. BTW, we missed the Iron Maiden concert we were headed to Charlotte for. We then had the car towed from Southport, NC, to Jeff Gordon Chevy in Wilmington, NC. They had it for a while and stated the part was on back order and with no ETA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The Volt experienced a "Shift to Park" error, preventing it from recognizing when it was in park, even when the gearshift was engaged. While this issue was frustrating, it initially didn’t affect the car’s driving capability. I simply had to wiggle the gearshift until the system registered that it was in park. This problem persi…
Read full complaint
The Volt experienced a "Shift to Park" error, preventing it from recognizing when it was in park, even when the gearshift was engaged. While this issue was frustrating, it initially didn’t affect the car’s driving capability. I simply had to wiggle the gearshift until the system registered that it was in park. This problem persisted for a month until one day, the vehicle would no longer shift into any mode, though the "Shift to Park" message remained on the dashboard. The car turned on but would not accelerate. The issue was eventually repaired at the dealership, a process that took about two weeks. During this time, we were not initially offered a rental car. It was only after we called and insisted that the dealership provided one while waiting for the necessary parts. This issue appeared to be a factory defect. While part of the repair was covered under warranty, we still had to pay $685 out of pocket.
Yesterday, my daughter was driving on [XXX] in Seattle traveling around 65mph when the vehicle lost power and reported the error of "shift to park", "Propulsion reduced" and "StabiliTrak failure". Luckily, she coasted to an off-ramp and safely put the vehicle in park. Thankfully she was not involved in an accident, but was ver…
Read full complaint
Yesterday, my daughter was driving on [XXX] in Seattle traveling around 65mph when the vehicle lost power and reported the error of "shift to park", "Propulsion reduced" and "StabiliTrak failure". Luckily, she coasted to an off-ramp and safely put the vehicle in park. Thankfully she was not involved in an accident, but was very shaken by the experience. After doing some research it seems that the Chevy Volt has a known issue with the BECM and GM has failed to issue a recall, putting thousands of lives at risk. After turning the vehicle on and off several times, she was able to get it started and with minimal propulsion on residential streets was able to return to our house. this morning I dropped the vehicle at our local GM dealer for diagnosis and repair, but wanted to file a report, to hopefully prevent this from happening to another unsuspecting driver/child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the EVAP pipe was rubbing against the air conditioning hose connector. The dealer informed the contact that the vehicle was…
Read full complaint
The contact owns a 2018 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the EVAP pipe was rubbing against the air conditioning hose connector. The dealer informed the contact that the vehicle was previously repaired under GM Campaign Number: N192273600; however, the failure persisted. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 84,800.
EGR valve clogged and failed on a long trip, bricked the car and had to tow many miles back to home shop. now have been waiting 9 months and still no idea when the part will be available from Chevrolet. My shop and I have claims to Chevrolet for the part for service but still nothing and is getting so we are inconvenienced in …
Read full complaint
EGR valve clogged and failed on a long trip, bricked the car and had to tow many miles back to home shop. now have been waiting 9 months and still no idea when the part will be available from Chevrolet. My shop and I have claims to Chevrolet for the part for service but still nothing and is getting so we are inconvenienced in travel.
Randomly getting Propulsion power is reduced and loss power while driving. Been force to pull over to the side on the freeway to restart the car.
The contact owns a 2018 Chevrolet Volt. The contact stated that while the vehicle was parked and shifted to park(P), the message "Shift to Park" was displayed on the instrument panel and the vehicle was inoperative. The contact stated that the vehicle was operative while in low power mode; however, the vehicle intermittently fai…
Read full complaint
The contact owns a 2018 Chevrolet Volt. The contact stated that while the vehicle was parked and shifted to park(P), the message "Shift to Park" was displayed on the instrument panel and the vehicle was inoperative. The contact stated that the vehicle was operative while in low power mode; however, the vehicle intermittently failed to charge in low power mode. No warning light was illuminated. However, the vehicle displayed the full battery icon on the display, but 1 EV Mile. The vehicle was taken to an independent mechanic where it was diagnosed that the battery energy control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 11,000.
The BECM (Battery Electric Control Module) failed in November of 2023. Mountain Chevrolet has had my vehicle since then, claiming to be unable to find replacement battery module. The vehicle is available for inspection at Mountain Chevrolet (it has been left unlocked, unprotected, and exposed to the elements for almost 15 month…
Read full complaint
The BECM (Battery Electric Control Module) failed in November of 2023. Mountain Chevrolet has had my vehicle since then, claiming to be unable to find replacement battery module. The vehicle is available for inspection at Mountain Chevrolet (it has been left unlocked, unprotected, and exposed to the elements for almost 15 months now). When the BECM failed, the vehicle lost virtually all power and slowed dramatically from highway speeds to ~20 mph. There were no warnings prior to the failure.
Official recalls
218V673000 · Seat Belts:rear/other
Sep 26, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Cadillac CT6, Escalade ESV, Chevrolet Suburban, Volt, and GMC Yukon XL vehicles. Certain second-row or third-row rear seatbelts retractor assemblies may not automatically lock when the seatbelt is fully pulled out of the retractor, possibly preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If the child seat is not properly secured in the event of a crash, it can increase the risk of injury.
Remedy: GM will notify owners, and dealers will inspect the rear seatbelt retractors and replace them if necessary, free of charge. The recall began November 7, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18315.
18V576000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.