NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
222 reportsMileage unknown · Jan 12, 2024
Electrical SystemEngine
My BECM failed pulling in to my grandpas house. I was able to park the car, but unable to start it afterwords. Prior to failure, the engine would switch between electric, then back to gas, then back to electric This is a very common issue on these vehicles. I am fortunate this did not occur on the highway, as I had just exited …
Read full complaint
My BECM failed pulling in to my grandpas house. I was able to park the car, but unable to start it afterwords. Prior to failure, the engine would switch between electric, then back to gas, then back to electric This is a very common issue on these vehicles. I am fortunate this did not occur on the highway, as I had just exited I 94
NHTSA ODI #11565021
Mileage unknown · Jan 10, 2024
Electrical SystemFuel/propulsion System
"Propulsion power reduced" message along with check engine light, loss of propulsion power from battery, loss of ability to charge battery. OBD2 scanner reveals P1E00, and 12 U26xx fault codes relating to Battery Energy Control Module failure.
NHTSA ODI #11564700
Mileage unknown · Jan 8, 2024
Fuel/propulsion SystemPower Train
The BECM on my 2018 Chevrolet Volt has failed and I am being told it may be months before the dealership will have the part to fix the issue.
NHTSA ODI #11564158
Mileage unknown · Jan 6, 2024
Electrical SystemFuel/propulsion SystemPower Train
After getting some repeated "propulsion power is reduced" display warnings, my 2018 Chevrolet Volt literally died without warning while I was driving it on New Year's Eve and could not be restarted.
NHTSA ODI #11563956
Mileage unknown · Jan 5, 2024
Electrical SystemFuel/propulsion SystemPower Train
Chevy Volt lost power while driving on the highway. No warning. The car has been at the dealership for 3.5 months and they have yet to tell me what the issue is, I have asked every time. Seems as though they don't want me to know. HIghly likely it is is BECM issue. Also, I scheduled the car to be looked at via their app, t…
Read full complaint
Chevy Volt lost power while driving on the highway. No warning. The car has been at the dealership for 3.5 months and they have yet to tell me what the issue is, I have asked every time. Seems as though they don't want me to know. HIghly likely it is is BECM issue. Also, I scheduled the car to be looked at via their app, the day I arrived for the appointment no technician was available, and said I needed to reschedule and bring it back in a week. I just left the car there because it was incredibly unsafe.
NHTSA ODI #11563687
Mileage unknown · Dec 31, 2023
EngineFuel/propulsion SystemPower Train
Initially was receiving intermittent “Recieved Propulsion Power” warning and no check engine light. Did it about every 2 weeks but became worse. Received Reduced Propulsion power warning on a road trip from East TN to Charlotte then showed a check engine light. I continued to Charlotte I had 4 miles left on battery and was ru…
Read full complaint
Initially was receiving intermittent “Recieved Propulsion Power” warning and no check engine light. Did it about every 2 weeks but became worse. Received Reduced Propulsion power warning on a road trip from East TN to Charlotte then showed a check engine light. I continued to Charlotte I had 4 miles left on battery and was running on gas engine when “Engine Not Available” warning came on leaving me with a nearly dead battery for propulsion. Fortunately, there was a very nearby GM dealership in Charlotte which I was able to drop off and flew out of town for the week. I was told by the dealership that it was an O2 sensor and they had replaced it. Picked up the car the next week. I began the 3 hour trip back to East TN and about 30 miles into the trip I received the Reduced Propulsion Power AND Engine Not Available. I had about 10 miles left on the battery so I stopped and stayed at a hotel with a car charger overnight. Resumed trip home that am, but same code was displayed and engine would not come on. Rented a uhaul w/trailer and towed it home. Dropped it off at Champion Chevrolet in Johnson City and they diagnosed it as a faulty EGR valve. I learned that the part has been back ordered and looking at web forums I see people have described the same problem and they have been waiting many months for an EGR to be available. So, nature of complaint is: I got lucky in that I did not get stranded. Fortunately I was in the right place at the right time. I could have easily totally lost propulsion were my battery were fail and don’t know if I could have gotten off the roadway.
NHTSA ODI #11562815
Mileage unknown · Dec 20, 2023
Fuel/propulsion SystemPower Train
On Dec 3, 2023 I got the message "Propulsion Power is Reduced" and the gas engine started even though there was about 53 miles left in the battery. I was able to continue on to my destination use the gas engine. On Dec 8, 2023 I drove the car to La Quinta Chevrolet and they diagnosed the problem as a failed BECM (Battery Energy …
Read full complaint
On Dec 3, 2023 I got the message "Propulsion Power is Reduced" and the gas engine started even though there was about 53 miles left in the battery. I was able to continue on to my destination use the gas engine. On Dec 8, 2023 I drove the car to La Quinta Chevrolet and they diagnosed the problem as a failed BECM (Battery Energy Control Module). On Dec 11 I got the car back and was told the BECM is on backorder and there is no estimated delivery date. Also on 12/3 when I tried to start the car after getting it home I started getting the message "Shift to Park" The dealer was able to fix this before I got it back on 12/11. I've been told I don't qualify for a loaner vehicle so I am left with a car that could stop at any time.
NHTSA ODI #11561063
Mileage unknown · Dec 14, 2023
Electrical SystemEngineFuel/propulsion System
In June of 2023 the car experienced propulsion power reduction. The car was at the dealer awaiting repair for 3 weeks. On Dec. 14,2023 the same thing happened again. The car was also unable to accelerate once mobile. The car has about 90k miles on it.
NHTSA ODI #11560191
Mileage unknown · Dec 13, 2023
Electrical SystemPower TrainUnknown Or Other
Vehicle is 2018 Chevrolet volt with approx 91000 miles, purchased new in California with both PZEV and Voltec warranties in place. Vehicle produced MIL in December, in Colorado, with exterior temperatures ~30 degrees, after attempting to remote start. The resulting OnStar Codes P1AEE, P1AEF, and P0AC4 indicating "the electric pr…
Read full complaint
Vehicle is 2018 Chevrolet volt with approx 91000 miles, purchased new in California with both PZEV and Voltec warranties in place. Vehicle produced MIL in December, in Colorado, with exterior temperatures ~30 degrees, after attempting to remote start. The resulting OnStar Codes P1AEE, P1AEF, and P0AC4 indicating "the electric propulsion system is not performing as expected. Please service immediately." Drove the vehicle to the nearest dealership assuming there could be an unexpected loss of power. Identified PIC6285B as trouble shooting aid for the dealership. The dealership stated they contacted their GM TAC representative and the service foreman and TAC agreed the vehicle needed a transmission flush. No indication that the work would be covered by the bulletin found. Customer contacted Chevrolet EV advisor and confirmed vehicle did not qualify for any warranty as the diagnostics indicated a category 4 issue associated with the bulletin but the repairs required were a transmission flush. This was contrary to the published bulletin, other customer reports, as well as the specific DTCs expected. Customer believes diagnostics would be covered by bulletin or warranty given a repair was identified based on the trouble codes that were pulled. Dealership and GM did not agree with customers belief. Customer forced to pay in order to recover vehicle after 1 week.
NHTSA ODI #11559935
Mileage unknown · Dec 9, 2023
Electrical SystemEngineFuel/propulsion System
Car died while driving down road. Has engine codes to service high voltage system although It showed a full battery it only had 1 mile range and the gas motor wouldn't run.
NHTSA ODI #11559324
Official recalls
2Sep 26, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Cadillac CT6, Escalade ESV, Chevrolet Suburban, Volt, and GMC Yukon XL vehicles. Certain second-row or third-row rear seatbelts retractor assemblies may not automatically lock when the seatbelt is fully pulled out of the retractor, possibly preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If the child seat is not properly secured in the event of a crash, it can increase the risk of injury.
Remedy: GM will notify owners, and dealers will inspect the rear seatbelt retractors and replace them if necessary, free of charge. The recall began November 7, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18315.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration