IllustrationIT IS THE "SHIFT TO PARK" PROBLEM. THE CAR WILL NOT TURN OFF BECAUSE IT DOES NOT RECOGNIZE WHEN IT IS IN PARK. IT HAS BEEN OCCURRING FOR MORE THAN A WEEK AND MAY BE REPAIRED BY REPLACING THE MICROSWITCH OR F-HARNESS RELATED TO THE SHIFT ASSEMBLY. THIS CONDITION HAPPENS WHEN THE CAR IS STATIONARY UPON ATTEMPTING TO TURN IT OFF.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
What owners actually said
697 reports"SHIFT TO PARK" DEFECT. WHEN THE SHIFTER IS PLACED INTO THE "PARK" POSITION AND THE CAR IS TURNED OFF AN INDICATOR STATES "ACTION REQUIRED - SHIFT TO PARK". THE CAR WILL EFFECTIVELY NOT TURN OFF. ONE IS UNABLE TO LOCK THE CAR AND THE LIGHTS WILL STAY ON FOR A FEW MINUTES. WORSE YET, THE PROBLEM IS INTERMITTENT BUT GETS WORSE OVE…
Read full complaint
"SHIFT TO PARK" DEFECT. WHEN THE SHIFTER IS PLACED INTO THE "PARK" POSITION AND THE CAR IS TURNED OFF AN INDICATOR STATES "ACTION REQUIRED - SHIFT TO PARK". THE CAR WILL EFFECTIVELY NOT TURN OFF. ONE IS UNABLE TO LOCK THE CAR AND THE LIGHTS WILL STAY ON FOR A FEW MINUTES. WORSE YET, THE PROBLEM IS INTERMITTENT BUT GETS WORSE OVER TIME. THE POWER MUST BE TURNED ON AND OFF SEVERAL TIMES, OR THE SHIFTER MOVED FROM PARK TO LOW A SEVERAL TIMES IN ORDER FOR THE SHIFTER TO ENGAGE IN "PARK". AS THE PROBLEM GET WORSE OVER TIME IT'S IMPOSSIBLE TO KNOW IF THE CAR OFF AT ALL. THE PROBLEM BEGAN ABOUT A YEAR AFTER I PURCHASED THE CAR NEW. I TOOK THE CAR INTO THE DEALER TO HAVE IT FIXED. THE DEALER INSISTED THAT THEY COULD NOT REPLICATE THE PROBLEM SO COULDN'T DIAGNOSE THE PROBLEM AND FIX IT. A YEAR LATER THE PROBLEM STILL EXISTED, AND AT THAT POINT THE DEALER WAS ABLE TO FIX THE PROBLEM (APPARENTLY BECAUSE BY THEN THE FIGURED OUT THE PROBLEM AND THE FIX). NOW, A YEAR LATER, THE PROBLEM HAS RESURFACED. BECAUSE I AM NO LONGER IN THE WARRANTY PERIOD I'LL HAVE TO PAY FOR THE REPAIR. THIS ISSUE IS CLEARLY A MANUFACTURING DEFECT AS MANY 2016 AND 2017 VOLTS HAVE THE SAME PROBLEM. GM SHOULD ISSUE A RECALL FOR THIS ITEM. IT IS QUITE DANGEROUS TO NOT BE ABLE TO SHUT OFF THE VEHICLE AND NOT KNOW IF IT WILL BE POSSIBLE TO DO SO. MINE BECAME SO BAD ONE TIME THAT I CALLED A TOW SERVICE, BUT WAS FINALLY ABLE TO SHUT OFF THE CAR. CHEVY IS CLEARLY AWARE OF THIS PROBLEM. IT'S APPALLING THAT VOLT OWNERS ARE LEFT TO DEAL WITH THIS POTENTIALLY DANGEROUS PROBLEM AND THAT THERE APPEARS TO NOT BE A PERMANENT FIX (AS MINE IS NOW HAPPENING A SECOND TIME). GM MUST ISSUE A RECALL FOR THIS ITEM. IT IS UNSAFE! REGARDING THE REQUIRED "WHEN DID THIS HAPPEN?" QUESTION BELOW - THERE IS NO SPECIFIC DATE. IT'S AN ONGOING PROBLEM. I PUT IN THE APPROXIMATE DATE THAT THE PROBLEM STARTED.
MY 2017 CHEVY VOLT GIVES ME 'SERVICE AIRBAG' WARNING ALL THE TIME. AND THE DEALER SAYS IT IS NOT COVERED UNDER WARRANTY, BUT THE CAR HAS NEVER MET WITH ANY ACCIDENTS OR SPILLS. SO THERE IS NO REASON FOR CUSTOMER DAMAGE. I SEE THAT THE SAME ISSUE WAS BEEN RAISED BY MANY UNDER PE19013. SO I WOULD WANT GM TO TAKE CARE OF THEIR MANU…
Read full complaint
MY 2017 CHEVY VOLT GIVES ME 'SERVICE AIRBAG' WARNING ALL THE TIME. AND THE DEALER SAYS IT IS NOT COVERED UNDER WARRANTY, BUT THE CAR HAS NEVER MET WITH ANY ACCIDENTS OR SPILLS. SO THERE IS NO REASON FOR CUSTOMER DAMAGE. I SEE THAT THE SAME ISSUE WAS BEEN RAISED BY MANY UNDER PE19013. SO I WOULD WANT GM TO TAKE CARE OF THEIR MANUFACTURING DEFECT RATHER THAN SAYING IT IS NOT COVERED UNDER W
THE SOFTWARE CONTROLLING THE REAR CAMERA, NAVIGATION AND MAIN BATTERY FAILED. THE SYSTEMS BECAME UNUSABLE (THE SCREEN BECAME BLACKED OUT SO THE REAR CAMERA ETC COULD NOT BE USED). ONCE THE UPDATE WAS PERFORMED IT WORKS FINE. CHEVY CHARGED US FOR THE COST OF THIS EVEN THOUGH WE FEEL THIS IS A SAFETY ISSUE AND SHOULD BE A RECAL…
Read full complaint
THE SOFTWARE CONTROLLING THE REAR CAMERA, NAVIGATION AND MAIN BATTERY FAILED. THE SYSTEMS BECAME UNUSABLE (THE SCREEN BECAME BLACKED OUT SO THE REAR CAMERA ETC COULD NOT BE USED). ONCE THE UPDATE WAS PERFORMED IT WORKS FINE. CHEVY CHARGED US FOR THE COST OF THIS EVEN THOUGH WE FEEL THIS IS A SAFETY ISSUE AND SHOULD BE A RECALLED ITEM. AFTER RESEARCHING THE PROBLEM FOUND THIS IS A KNOWN ISSUE
I PURCHASED MY USED 17 CHEVY VOLT 2 MONTHS AGO. SUDDENLY MY CAR STARTED HAVING INTERMEDIATE ISSUES OF SHOWING "SHIFT TO PARK" WHEN THE VEHICLE IS CLEARLY IN PARK MODE. WHEN THIS OCCURS THE VEHICLE CANNOT BE SHUT OFF. I HAVE ATTEMPTED TO CONTACT GM BUT THEY CLAIM THERE ARE NO RECALL OR SERVICE BULLETINS FOR MY VIN/VEHICLE. THERE …
Read full complaint
I PURCHASED MY USED 17 CHEVY VOLT 2 MONTHS AGO. SUDDENLY MY CAR STARTED HAVING INTERMEDIATE ISSUES OF SHOWING "SHIFT TO PARK" WHEN THE VEHICLE IS CLEARLY IN PARK MODE. WHEN THIS OCCURS THE VEHICLE CANNOT BE SHUT OFF. I HAVE ATTEMPTED TO CONTACT GM BUT THEY CLAIM THERE ARE NO RECALL OR SERVICE BULLETINS FOR MY VIN/VEHICLE. THERE ARE COUNTLESS ONLINE COMPLAINTS FROM 17 VOLT OWNERS SHOWING THE SAME ISSUE (THIS IS ALSO OCCURRING WITH OTHER GM MODELS & I AM ALSO SEEING SIMILAR COMPLAINTS ON THIS SITE). GM IS FULLY AWARE OF THIS DEFECT & HAS ONLY ISSUED SERVICE BULLETINS ON SOME VIN # - WHILE THEY SHOULD HAVE CAUSE - BASED ON NUMEROUS COMPLAINTS - THAT THIS IMPACT IS OCCURRING WITH THE MAJORITY OF 17 VOLTS. THIS IS A SAFETY ISSUE WHEN A 3,794 LBS VEHICLE CANNOT BE SHUT OFF. I AM ASKING THAT NHTSA ISSUE A RECALL IN REGARDS TO 2017 CHEVY VOLTS & THE "SHIT TO PARK" ISSUE. WHILE THIS IS AN INTERMEDIATE ISSUE AND SOME DAYS MY CAR SHUTS OF FINE WHILE OTHERS IT TAKES MOVING THE SHIFTER BACK BETWEEN GEARS IN ORDER FOR THE ELECTRICAL COMPONENT TO RECOGNIZE IT'S PARKED - I WILL TRY TO CONTACT MY LOCAL DEALER FOR HELP BUT I AM FILING THIS COMPLAINT TO PUT GM & NHTSA ON NOTICE REGARDING THIS WELL KNOWN DEFECT THAT IS NOT BEING ADDRESSED AND COULD BE A SERIOUS SAFETY ISSUE. GM SHOULD DO THE RIGHT THING AND ADDRESS THIS ISSUE WHICH IS WELL DOCUMENTED - BY PROVIDING A RECALL. PLEASE SEE THESE SIMILAR COMPLAINTS FOR GM ON VARIOUS MODELS SHOWING "SHIFT TO PARK": HTTPS://WWW.CARCOMPLAINTS.COM/NEWS/2018/GMC-ACADIA-SHIFT-TO-PARK-ISSUES-LAWSUIT.SHTML HTTPS://WWW.REDDIT.COM/R/VOLT/COMMENTS/8ET2NW/ACTION_REQUIRED_SHIFT_TO_PARK/ HTTPS://ABC6ONYOURSIDE.COM/ON-YOUR-SIDE/WESTERVILLE-FAMILY-IN-LIMBO-AS-GM-LEAVES-THEM-IN-DARK-OVER-SHIFT-TO-PARK-ISSUE HTTPS://WWW.CRUZETALK.COM/THREADS/SHIFT-TO-PARK-LOCK-PROBLEM.51401/ HTTPS://REPAIRPAL.COM/CANNOT-TURN-OFF-2016-VOLT-ACTION-REQUIRED-SHIFT-TO-PARK-522
SHIFT TO PARK ERROR MESSAGE CONSISTENTLY APPEARING PREVENTING THE CAR FROM EFFECTIVELY TURNING OFF WHEN CAR IS SHIFTED TO PARK.
MY VOLT WAS T-BONED ON THE PASSENGER SIDE OF THE CAR BY A RED LIGHT RUNNER. I HAD JUST STARTED TO ENTER INTO THE INTERSECTION A SECOND OR SO AFTER MY LIGHT TURNED GREEN, SO NOT GOING VERY FAST. THE OTHER CAR WAS GOING 25-35 MPH (APPROX.). THIS WAS ON A CITY STREET, BOTH ONE WAYS STREETS SO THAT DRIVER WAS ABLE TO BUILD UP SOME …
Read full complaint
MY VOLT WAS T-BONED ON THE PASSENGER SIDE OF THE CAR BY A RED LIGHT RUNNER. I HAD JUST STARTED TO ENTER INTO THE INTERSECTION A SECOND OR SO AFTER MY LIGHT TURNED GREEN, SO NOT GOING VERY FAST. THE OTHER CAR WAS GOING 25-35 MPH (APPROX.). THIS WAS ON A CITY STREET, BOTH ONE WAYS STREETS SO THAT DRIVER WAS ABLE TO BUILD UP SOME MOMENTUM. I WAS PUSHED INTO THE CAR TO MY LEFT (DRIVER'S SIDE). THE DAMAGE WAS ENOUGH TO TOTAL THE CAR. THE AIR BAGS WERE NOT DEPLOYED.
MY 2017 CHEVY VOLT HAS AN ADAPTIVE CRUISE CONTROL PROBLEM . IT WILL ONLY WORK WHEN IT WANTS TO BUT WHAT MAKE IT SO DANGEROUS IS THAT IF YOU GET IT TO ENGAGE IT WILL RANDOMLY AND WITHOUT ANY WARNING DISENGAGE ITSELF. IF YOU ARE USING THE 2017 VOLT IN THE LOW GEAR MODE AND THIS HAPPENS THE CAR WILL RAPIDLY DECELERATE WHICH IS VER…
Read full complaint
MY 2017 CHEVY VOLT HAS AN ADAPTIVE CRUISE CONTROL PROBLEM . IT WILL ONLY WORK WHEN IT WANTS TO BUT WHAT MAKE IT SO DANGEROUS IS THAT IF YOU GET IT TO ENGAGE IT WILL RANDOMLY AND WITHOUT ANY WARNING DISENGAGE ITSELF. IF YOU ARE USING THE 2017 VOLT IN THE LOW GEAR MODE AND THIS HAPPENS THE CAR WILL RAPIDLY DECELERATE WHICH IS VERY DANGEROUS AND HAS ALMOST CAUSE THE PEOPLE BEHIND ME TO RUN INTO ME. I HAVE TRIED TO GET THIS FIXED SEVERAL TIMES BUT IT SEEMS NOBODY KNOWS WHAT TO DO WITH IT AND THEY WILL TRY BUT IT JUST GOES RIGHT BACK TO DOING IT AGAIN.
AFTER I SHIFT THE VEHICLE INTO PARK AND PRESS THE BUTTON TO TURN OFF THE CAR, A WARNING COMES UP AND SAYS "SHIFT TO PARK." I CANNOT TURN OFF THE CAR UNTIL THE MESSAGE CLEARS. THE MESSAGE IS CLEARED BY GIGGLING THE SHIFTER (ALREADY IN PARK) BACK AND FORTH. THIS HAPPENS ALMOST EVERY TIME I TURN OFF THE CAR NOW. AFTER A SHORT G…
Read full complaint
AFTER I SHIFT THE VEHICLE INTO PARK AND PRESS THE BUTTON TO TURN OFF THE CAR, A WARNING COMES UP AND SAYS "SHIFT TO PARK." I CANNOT TURN OFF THE CAR UNTIL THE MESSAGE CLEARS. THE MESSAGE IS CLEARED BY GIGGLING THE SHIFTER (ALREADY IN PARK) BACK AND FORTH. THIS HAPPENS ALMOST EVERY TIME I TURN OFF THE CAR NOW. AFTER A SHORT GOOGLE SEARCH, MANY OTHER 2017 OWNERS ARE EXPERIENCING THE SAME ISSUE. PLEASE LOOK INTO ISSUING A RECALL.
WHEN BUCKLING MY 5 YEAR OLD SON INTO HIS BOOSTER SEAT, THE REAR SEATBELT ALWAYS BECOMES WEDGED IN A CAVITY OF THE REAR SEAT. THIS ALSO OCCURS IF MY SON MOVES WHILE WE ARE IN TRANSIT. THIS CAUSES THE SEATBELT TO FAIL TO RETRACT PROPERLY AND THUS HE IS NOT PROPERLY SECURED. I AM AFRAID NOT ONLY FOR HIS SAFETY BECAUSE THE SEATBELT …
Read full complaint
WHEN BUCKLING MY 5 YEAR OLD SON INTO HIS BOOSTER SEAT, THE REAR SEATBELT ALWAYS BECOMES WEDGED IN A CAVITY OF THE REAR SEAT. THIS ALSO OCCURS IF MY SON MOVES WHILE WE ARE IN TRANSIT. THIS CAUSES THE SEATBELT TO FAIL TO RETRACT PROPERLY AND THUS HE IS NOT PROPERLY SECURED. I AM AFRAID NOT ONLY FOR HIS SAFETY BECAUSE THE SEATBELT IS NOT SECURING HIS TORSO PROPERLY. ADDITIONALLY, FROM THIS OCCURRING FREQUENTLY, I AM AFRAID THAT WEAR ON THE SEATBELT (FRAY) WILL COMPROMISE THE SEATBELT MATERIAL CAUSING IT TO FAIL IF EVER IN A CRASH.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.