IllustrationThe vehicle’s service airbag warning light is illuminated. The dealership diagnostic indicates that the passenger seat sensor needs to be replaced. Based on my research, this was also an issue with the Volt’s 1st Gen models.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
What owners actually said
697 reportsWhen placing my car into Park and then powering it off I get an error message telling me to shift to park to shut vehicle off even though it is in park. Problem is two fold: I cant turn the car off and the result is a battery that runs dead. Very frustrating and if the car isnt off it could accidentally be put into gear by a chi…
Read full complaint
When placing my car into Park and then powering it off I get an error message telling me to shift to park to shut vehicle off even though it is in park. Problem is two fold: I cant turn the car off and the result is a battery that runs dead. Very frustrating and if the car isnt off it could accidentally be put into gear by a child.
The vehicle often will not turn off after pressing the power button, even though it is in the Park position the vehicle stays on with the console message “Shift to Park” displayed. Normally releasing and the re-engaging the foot brake and toggling the shifter lock resolves the problem, but today (Nov 22, 2021) the vehicle did no…
Read full complaint
The vehicle often will not turn off after pressing the power button, even though it is in the Park position the vehicle stays on with the console message “Shift to Park” displayed. Normally releasing and the re-engaging the foot brake and toggling the shifter lock resolves the problem, but today (Nov 22, 2021) the vehicle did not recognize that the vehicle was in Park when in a city parking lot after approximately 10 minutes of attempting to turn off the vehicle. If the vehicle does not recognize that the shifter is in park and does not turn off, the battery may drain, and if one needs to leave the vehicle, the operator cannot be sure the vehicle will remain in position. No warning lights appear for the vehicle on turning on the vehicle.
The car will not shift
I'm having a shift to park issue with this chevy volt, it won't register with the system I'm in park mode. I'm also having an adaptive cruise control issue as it's telling me adaptive cruise control is unavailable at this time. The adaptive cruise control is a hit or miss.
The car doesn't shut off. I get an error: "shift to park". Started yesterday, 11/9/21. I have to jiggle the gear selector to get it to shut off. I'm sure that is going to stop working for me. I've seen that their have been various lawsuits regarding this issue. Not sure what my next step is.
shift-to-park problem. This is a noted problem with these Volt's. The Dealer is charging around $450 to fix this problem. With more than a couple of service bulletins on this, it is a troublesome issue.
My Chevy Volt has the "Shift to Park" error. It intermittently will not turn off, which means you also cannot start it. This left me stranded at night in a county park, which closed before the tow truck could arrive. The car has 40,205 miles and the dealer says this problem is not under warranty because it is a "bumper to bum…
Read full complaint
My Chevy Volt has the "Shift to Park" error. It intermittently will not turn off, which means you also cannot start it. This left me stranded at night in a county park, which closed before the tow truck could arrive. The car has 40,205 miles and the dealer says this problem is not under warranty because it is a "bumper to bumper" issue covered only under the 36,000 mile warranty. As categorized by NHTSA, this is an electrical and power train issue and is a glaring defect that is essential to the car even functioning and should not happen on a car with 40,000 miles.
Car does not sent park position when lever is pushed in park position. This results in car not being turned off and drains the battery.
When attempting to turn my car off, a message is displayed saying "SHIFT TO PARK". My car is already in park, and jiggling the gear shifter will generally get rid of the message. Sometimes this can take several minutes. It is not possible to turn my car off when this message is displayed, and the battery will die if the car is l…
Read full complaint
When attempting to turn my car off, a message is displayed saying "SHIFT TO PARK". My car is already in park, and jiggling the gear shifter will generally get rid of the message. Sometimes this can take several minutes. It is not possible to turn my car off when this message is displayed, and the battery will die if the car is left with this message displayed. The car is available for inspection upon request. It is being repaired in the next few days though. The problem has been confirmed by a local mechanic. The problem has a class action lawsuit against GM for the issue: https://www.carcomplaints.com/news/2021/gm-shift-to-park-lawsuit-vehicles-cant-be-shut-off.shtml#:~:text=The%20car%20does%20not%20detect%20park%20mode%20and,and%20Maryland%20plaintiff%20Juanita%20Crawford%20%282017%20Chevrolet%20Malibu%29. The problem first appeared approximately 2 weeks ago without any prior notice or warnings, at 44,000 miles.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.