IllustrationThe evaporative emissions pipe has a hole in it. This same issue has been previously associated with a recall. The dealer (Andy Mohr Chevrolet - Plainfield) reported that it was fixed in 2020 and declined to do service without me paying for it.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
What owners actually said
697 reportsThe Battery Energy Control Module (BECM) has failed. On two occasions this put me at risk of collision because when the BECM lost communication my car stalled as I was accelerating away from a stop sign. On one occasion, cross traffic had to come to a stop so I could push my car out of the intersection. The car is currently a…
Read full complaint
The Battery Energy Control Module (BECM) has failed. On two occasions this put me at risk of collision because when the BECM lost communication my car stalled as I was accelerating away from a stop sign. On one occasion, cross traffic had to come to a stop so I could push my car out of the intersection. The car is currently at the dealer for repair. The problem has been confirmed to be the BECM. There was no advance warning when this occurred. A message came up during the incident that said, "Propulsion Power Is Reduced" and following the incident, the check engine light illuminated. The warnings appeared at the time of the incident. There was no advance warning.
BECM failure. Initially, it caused the vehicle to operate in a low propulsion state. However, it now prevents the vehicle from starting. Likewise, I have heard it has stopped the engines from working/shut down the engines while people are driving on the highway.
When attempting to turn off the vehicle, an error message "action required - shift to park" appears even though the shifter is in the park position.
About 3 minutes after I started driving the 2017 Chevy Volt, an error message showed saying "propulsion power is reduced" and I was unable to drive the vehicle as typical. While driving on base at fairly low speed (~15-20mph) in the battery area of the display, the EV range was reading 12mi, and it started going up. When it re…
Read full complaint
About 3 minutes after I started driving the 2017 Chevy Volt, an error message showed saying "propulsion power is reduced" and I was unable to drive the vehicle as typical. While driving on base at fairly low speed (~15-20mph) in the battery area of the display, the EV range was reading 12mi, and it started going up. When it read 20mi, the "Propulsion power reduced" showed on the display and the check engine light came on. I pulled over to a different building, went inside for a few minutes, came back out and restarted the car, and I got a message the Volt wouldn't initialize. After multiple on/off button pushes to start the car, the car finally initialized to where I was able to drive home in the "Propulsion Power Reduced mode", and I was not able to accelerate as expected - the vehicle was very sluggish. I drove home at about 45-50mph. My drive home is about 38 mi one way.
The two original equipment hydraulic struts that support either side of the rear trunk lid failed. It is available for inspection. The safety of my husband and I is/was put at risk because when you open the trunk, the lid is not staying up like it did, causing it to crash down on your head, back of neck, shoulder, arm, hand, etc…
Read full complaint
The two original equipment hydraulic struts that support either side of the rear trunk lid failed. It is available for inspection. The safety of my husband and I is/was put at risk because when you open the trunk, the lid is not staying up like it did, causing it to crash down on your head, back of neck, shoulder, arm, hand, etc., causing injury that is potentially fatal. The faulty parts are still in place and not inspected yet by a dealer, service center, police or insurance company. No warnings given for this faulty equipment, hence the danger of its unexpected suddenness. It started about 2 weeks ago. I spoke with General Motors, the Florida DMV and the Chevrolet dealership where the car was purchased and is taken for repairs.
On Sunday night, I was driving around 65 mph on the 405 freeway to take my friend to the airport. I noticed that the car started to give a weird feedback sensation on the pedals and had started to jerk us forward. As I merged onto the two-lane on ramp to the 10 freeway, the car started to rapidly lose power and then completely d…
Read full complaint
On Sunday night, I was driving around 65 mph on the 405 freeway to take my friend to the airport. I noticed that the car started to give a weird feedback sensation on the pedals and had started to jerk us forward. As I merged onto the two-lane on ramp to the 10 freeway, the car started to rapidly lose power and then completely died and went dark. I was unable to use the hazard lights as the car had just gone dark but then it turned back on but would not let me shift it into drive. As I was on a two-lane on-ramp with no shoulder in the dark, we just had to pray that no one would hit us. In doing research, I suspect that this was yet another BECM failure that has been repeatedly happening with this year of Chevrolet Volts. There was most recently a class-action lawsuit filed for this very issue. The car is currently at the dealership awaiting inspection but I am terrified to drive that car again if it even becomes drivable. Especially since there were no warning lights or signs on the vehicle to indicate that this could be an issue and to have it die on the freeway in the way that it did, putting my life and many other lives at risk, I am shocked that there hasn't been a recall for this issue.
Battery Energy Control Module failed. Car stopped unexpectedly while driving which was a huge safety issue. Car has been broken for 3 months waiting for parts which seem to be unavailable.
I pull into a parking space. Place the gear in Park and then attempt to turn the car off by pressing the Power button. I then receive a warning message informing me: Action Required Shift Car to Park The car gear is already in Park and the driver display console also shows the car is in “P” (Park). The car will not lock. I hav…
Read full complaint
I pull into a parking space. Place the gear in Park and then attempt to turn the car off by pressing the Power button. I then receive a warning message informing me: Action Required Shift Car to Park The car gear is already in Park and the driver display console also shows the car is in “P” (Park). The car will not lock. I have to turn the car on and off and switch the gear back and forth placing back into P (Park) several times until the car realizes it’s in Park and allows me to turn it off. This started happening when the car hit about 36,000. The car has approximately 40,000 miles now.
Our vehicle is a 2017 Chevrolet Volt VIN: [XXX], leased/purchased new delivered 12-31-2016. Vehicle experienced an unexpected loss of power when the check engine light came on and we had to immediately pull off the road. The vehicle is currently at the dealership waiting on the Battery Control Module (BCM) P/N: 24296900 and we …
Read full complaint
Our vehicle is a 2017 Chevrolet Volt VIN: [XXX], leased/purchased new delivered 12-31-2016. Vehicle experienced an unexpected loss of power when the check engine light came on and we had to immediately pull off the road. The vehicle is currently at the dealership waiting on the Battery Control Module (BCM) P/N: 24296900 and we have a Case open with [XXX]. We are told the part is not available, only 14 in stock nationwide, and are not being released as they are reserved already. No expected delivery date for the module. Noticed a class action lawsuit may be in the works. Wanted to ensure you had another record of vehicles affected. https://www.classaction.org/news/2016-2019-chevy-volts-suffer-from-battery-energy-control-module-defect-class-action-claims#embedded-document INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.