NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
697 reportsMileage unknown · Dec 13, 2023
Electrical SystemFuel/propulsion System
The car regularly reports it is healthy and functioning correctly. It is regularly serviced and there was no advance warning of this problem. While driving the car displayed a message to the driver, something such as "reduced propulsion" and the speed of the car was reduced while the internal combustion engine intermittently rac…
Read full complaint
The car regularly reports it is healthy and functioning correctly. It is regularly serviced and there was no advance warning of this problem. While driving the car displayed a message to the driver, something such as "reduced propulsion" and the speed of the car was reduced while the internal combustion engine intermittently raced in an uncharacteristic manner. The amber Check Engine light was displayed. A review of error codes later found a communication fault developed with the Battery Energy Control Module (BECM). As soon as it was possible, we got the car to the side of the road and shut it off. We then attempted to start the car and it displayed a warning that no key fob was present (but there was a key fob in the car). A few minutes later the car started and we were able to drive it to a service center where error codes were captured. Afterwards, the car drove as normal, and later even the amber Check Engine light was extinguished. The service center explained this could be an intermittent problem where the car will suddenly throw the error message ("low propulsion") and the car will have to be pulled to the side of the road. It will be a few weeks before the service center can do any work on the car. Since the car may start and drive, but suddenly find its speed reduced to far below the speed limit, the car can no longer be safely operated.
NHTSA ODI #11559882
Mileage unknown · Dec 12, 2023
Fuel/propulsion System
The battery energy control module failed mid drive causing my car to come to a stop in the middle of traffic. The car was towed to a dealership mechanic shop where the BECM had indeed failed. There was no signal that is was going to fail it just simply stopped and as it stopped the check engine light came on
NHTSA ODI #11559732
Mileage unknown · Dec 12, 2023
EngineFuel/propulsion System
While driving to work, the vehicle shook a bit and entered into "reduced propulsion mode". The vehicle had a significant reduction in engine power on the road (the propulsion became very jerky), which became dangerous on the highway. There were no previous indicators of any type of issue. After brining the vehicle to the dealers…
Read full complaint
While driving to work, the vehicle shook a bit and entered into "reduced propulsion mode". The vehicle had a significant reduction in engine power on the road (the propulsion became very jerky), which became dangerous on the highway. There were no previous indicators of any type of issue. After brining the vehicle to the dealership, I was told it would be okay to drive until my appointment (which was scheduled for the subsequent week). Two days later, the vehicle would not start. When attempting to start the car, the "Shift to Park" message displayed. I had to get the vehicle towed to the dealership at that point. The dealership mentioned it is likely an issue with the Battery Energy Control Module (BECM). However, I'm still waiting for a resolution.
NHTSA ODI #11559657
Mileage unknown · Dec 11, 2023
Engine
Around the tenth of November my car, a 2017 Premier Volt bought used, began to display an information message that the propulsion power is reduces. It displayed 0 mi EV range, even though I knew I had some left. When I started to drive the engine seemed louder than usual and the check engine light was on. I pulled into a parking…
Read full complaint
Around the tenth of November my car, a 2017 Premier Volt bought used, began to display an information message that the propulsion power is reduces. It displayed 0 mi EV range, even though I knew I had some left. When I started to drive the engine seemed louder than usual and the check engine light was on. I pulled into a parking lot, and checked under the hood just to make sure nothing was obviously smoking or sparking. I turned the car on and off, and drove around the parking lot a few times until it resumed normal functionality, however the check engine light remained. This was after dark, when I got off work, and I drive home on Highway 49. I did not want to drive it home on the highway in the dark until the issue seemed resolved. Since the manual claimed that if I see both reduced propulsion and check engine light I should immediately take the car to my dealer, I made an appointment with them for the sixteenth of November. For the next couple days I continued to have the same issues, propulsion reduced, incorrectly displaying 0 EV miles, and the check engine light coming on. Starting and stopping the car, or driving around the parking lot a couple times seemed to temporarily solve the issues. At the dealer, I was told there is no ETA on the part, and that it is back ordered or wait listed. The issue is with the BCEM or battery energy control module. They provided me with a rental car for the time being. A few weeks have passed, so I called them today, the 11th of December, but there is still no eta. They are still waiting for the BCEM, which is back ordered.
NHTSA ODI #11559563
Mileage unknown · Dec 8, 2023
Electrical System
The battery control module failed and it was replaced at the dealership. The low propulsion mode went into effect twice before it failed and I could not drive it in my driveway. The warning lamp was on but it was on for a while before the failure due to low battery on the key fob. Chevy is aware of the problem and there is a …
Read full complaint
The battery control module failed and it was replaced at the dealership. The low propulsion mode went into effect twice before it failed and I could not drive it in my driveway. The warning lamp was on but it was on for a while before the failure due to low battery on the key fob. Chevy is aware of the problem and there is a class action lawsuit just for the battery control module issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11559178
Mileage unknown · Dec 8, 2023
EngineForward Collision AvoidanceFuel/propulsion System
On 2 separate time periods, "propulsion power reduced" message appears on dash: - 1st incident in November 2022, car would not move after powering off the vehicle. After sitting idle for a week, decided to retry, and car seemed to work normally. Took it in to Chevy service, they replaced the BECM. Car worked fine after this …
Read full complaint
On 2 separate time periods, "propulsion power reduced" message appears on dash: - 1st incident in November 2022, car would not move after powering off the vehicle. After sitting idle for a week, decided to retry, and car seemed to work normally. Took it in to Chevy service, they replaced the BECM. Car worked fine after this - 2nd incident in November 2023, again 'propulsion power reduced' message appeared. This time, however, car would suddenly cut off gas engine (even at highway speed), switching to 100% battery mode, and displaying 'Engine not available' on dashboard. Fuel level indicator would immediately display 'LOW' (even though gas tank was full). Reduced acceleration on battery mode. Car is now in same service center awaiting fix for the past month. Was quite an unsafe situation, especially at highway speeds, and especially given the fact that the battery also may have been at a low state of charge, risking complete vehicle breakdown. Coupled with both of these incidents, the cruise control intermittently shuts off, displaying 'Cruise control unavailable'. Car is lightly utilized, with just over 30k miles on the odometer to date. Additionally, the car is kept in a mild climate (coastal southern california) and parked in a covered spot shielded from sun and temperature extremes.
NHTSA ODI #11559140
Mileage unknown · Dec 8, 2023
Fuel/propulsion System
Battery Energy Control Module failed resulting in significantly reduced and unreliable propulsion power available reducing maneuverability and increasing risk of collision at speeds over 45 mph. Check Engine Light illuminated as well as a “propulsion power reduced” message on the dashboard. The problem was confirmed by a dealer …
Read full complaint
Battery Energy Control Module failed resulting in significantly reduced and unreliable propulsion power available reducing maneuverability and increasing risk of collision at speeds over 45 mph. Check Engine Light illuminated as well as a “propulsion power reduced” message on the dashboard. The problem was confirmed by a dealer and repaired under 8 year / 100000 mile voltec warranty.
NHTSA ODI #11559077
Mileage unknown · Dec 7, 2023
Electrical SystemFuel/propulsion System
The gm repair started the "vehicle power control module" - gm (24296765) is bad. Cause the car to stop, and not restart, 12v won't charge. dealership states the part on back order over 60 days, not expecting it any time soon.
NHTSA ODI #11559045
Mileage unknown · Dec 7, 2023
Electrical SystemPower TrainVehicle Speed Control
This vehicle has a very dangerous malfunction. There was no power when I tried to move out of the way of an out-of-control semi truck while driving on the highway by pressing the pedal. I made every effort to maneuver because I was terrified. But because of the power outage, I could have died. This is really worrying, and I hope…
Read full complaint
This vehicle has a very dangerous malfunction. There was no power when I tried to move out of the way of an out-of-control semi truck while driving on the highway by pressing the pedal. I made every effort to maneuver because I was terrified. But because of the power outage, I could have died. This is really worrying, and I hope you can address the issue raised by Chevy so that someone else might be spared and so that future generations of electric cars are constructed to a standard that includes safety. Thank you.
NHTSA ODI #11558883
Mileage unknown · Dec 5, 2023
Fuel/propulsion System
The EGR valve failed, causing the loss of propulsion message on July 11 2022. This was fixed, however the message was received again in December 2022.
NHTSA ODI #11558668
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration