Electrical SystemFuel/propulsion SystemUnknown Or Other
On Sunday night, I was driving around 65 mph on the 405 freeway to take my friend to the airport. I noticed that the car started to give a weird feedback sensation on the pedals and had started to jerk us forward. As I merged onto the two-lane on ramp to the 10 freeway, the car started to rapidly lose power and then completely d…
Read full complaint
On Sunday night, I was driving around 65 mph on the 405 freeway to take my friend to the airport. I noticed that the car started to give a weird feedback sensation on the pedals and had started to jerk us forward. As I merged onto the two-lane on ramp to the 10 freeway, the car started to rapidly lose power and then completely died and went dark. I was unable to use the hazard lights as the car had just gone dark but then it turned back on but would not let me shift it into drive. As I was on a two-lane on-ramp with no shoulder in the dark, we just had to pray that no one would hit us. In doing research, I suspect that this was yet another BECM failure that has been repeatedly happening with this year of Chevrolet Volts. There was most recently a class-action lawsuit filed for this very issue. The car is currently at the dealership awaiting inspection but I am terrified to drive that car again if it even becomes drivable. Especially since there were no warning lights or signs on the vehicle to indicate that this could be an issue and to have it die on the freeway in the way that it did, putting my life and many other lives at risk, I am shocked that there hasn't been a recall for this issue.
NHTSA ODI #11498415
Mileage unknown · Nov 15, 2022
Unknown Or Other
Our 2017 Volt started experiencing a "Shift to Park" error message on November 2, 2022 when the vehicle is stopped and the transmission shifter has been placed in "Park". Apparently the microswitch responsible for detecting "Park" (GM part # 84955382) has failed and this appears to be a common defect in several models of Chevro…
Read full complaint
Our 2017 Volt started experiencing a "Shift to Park" error message on November 2, 2022 when the vehicle is stopped and the transmission shifter has been placed in "Park". Apparently the microswitch responsible for detecting "Park" (GM part # 84955382) has failed and this appears to be a common defect in several models of Chevrolet. With this error message the vehicle will not turn off and the car cannot be secured properly (both of which are a safety concern). Our vehicle has less than 30K miles on it so it should not be a case of normal wear and tear causing the problem. GM has not issued a recall for this defect yet but we see there are several class action law suits looking to force them to do so. We also note that a number of consumers have reported the error progressing so that it occurs while the vehicle is in operation causing the driver to have to pull to the side of the road when transmission operation ceases. Chevrolet released document ID 5403533 on December 11, 2020, Bulletin #19-NA-206 due to the frequency of this defect detailing the parts needed to effect repairs for several models of Chevrolet. We have discussed this issue with our local Chevrolet dealer and they concur the vehicle should be repaired ASAP to avoid the progression of switch failure in the vehicle. Since the car is out of warranty and in the absence of a manufacturer's recall that will cost approximately $310. We will have this repair done tomorrow (November 15) and will ask the dealer to provide us the defective switch in case you care to inspect it.
NHTSA ODI #11493579
Mileage unknown · Oct 10, 2022
Electrical SystemUnknown Or Other
The car will not turn off and it says it needs to be shifted into “park” after it is already parked. I am left unable to leave my car or lock it when I need to leave which makes this dangerous in case of an emergency where I need to leave the car quickly and cannot without leaving the car on and open.
NHTSA ODI #11488687
Mileage unknown · Sep 18, 2022
Electrical SystemFuel/propulsion SystemUnknown Or Other
At approximately 61,500 miles my Chevy Volt would not start. I had it towed to a repair facility who determined the problem was a faulty BECM (Battery Energy Control Module), but that it would still be covered by the manufacturer's warranty. So I had the vehicle towed to a dealership. The vehicle has been at the dealership for …
Read full complaint
At approximately 61,500 miles my Chevy Volt would not start. I had it towed to a repair facility who determined the problem was a faulty BECM (Battery Energy Control Module), but that it would still be covered by the manufacturer's warranty. So I had the vehicle towed to a dealership. The vehicle has been at the dealership for six weeks as of the time I write this, but report they have yet to diagnose the problem or offer a solution. Doing research online I have found that BECM failure is a common problem among the Chevy Volt, of all model years. And due to "supply chain disruptions" people are having to wait weeks to months for their vehicle to be repaired. Fortunately my vehicle did not fail in a dangerous location, however the BECM failure could happen randomly at any time at any mileage and appears to be a design flaw. Fortunately my vehicle is still covered by the manufacturer's warranty, but in my opinion, repair should be extended to all Chevy Volts.
NHTSA ODI #11485013
Mileage unknown · Jul 7, 2022
Forward Collision AvoidanceUnknown Or Other
Control module battery energy control failure part is unavailable for more then 3 months or more Check engine light on Car can be disabled At any time traveling down Highway Dealer confirmed part needs to be replaced
NHTSA ODI #11472671
Mileage unknown · May 20, 2022
Unknown Or Other
Shift to park error.
NHTSA ODI #11465365
Mileage unknown · Feb 20, 2022
Unknown Or Other
Shift to park notification after being placed in park. Used to only happen occasionally, but is almost every time I turn my car off now
NHTSA ODI #11453161
Mileage unknown · Dec 10, 2021
EngineUnknown Or Other
This car star having many issues with over heat .
NHTSA ODI #11443309
Mileage unknown · Nov 11, 2021
EngineUnknown Or Other
The car will not shift
NHTSA ODI #11440140
Mileage unknown · Oct 10, 2021
Electrical SystemUnknown Or Other
When attempting to turn my car off, a message is displayed saying "SHIFT TO PARK". My car is already in park, and jiggling the gear shifter will generally get rid of the message. Sometimes this can take several minutes. It is not possible to turn my car off when this message is displayed, and the battery will die if the car is l…
Read full complaint
When attempting to turn my car off, a message is displayed saying "SHIFT TO PARK". My car is already in park, and jiggling the gear shifter will generally get rid of the message. Sometimes this can take several minutes. It is not possible to turn my car off when this message is displayed, and the battery will die if the car is left with this message displayed. The car is available for inspection upon request. It is being repaired in the next few days though. The problem has been confirmed by a local mechanic. The problem has a class action lawsuit against GM for the issue: https://www.carcomplaints.com/news/2021/gm-shift-to-park-lawsuit-vehicles-cant-be-shut-off.shtml#:~:text=The%20car%20does%20not%20detect%20park%20mode%20and,and%20Maryland%20plaintiff%20Juanita%20Crawford%20%282017%20Chevrolet%20Malibu%29. The problem first appeared approximately 2 weeks ago without any prior notice or warnings, at 44,000 miles.
NHTSA ODI #11436195
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration