NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
219 reportsClear category filterMileage unknown · Dec 3, 2023
EngineFuel/propulsion SystemPower Train
My Volt will suddenly lose propulsion. The air conditioner will stop working and the car will not properly accelerate. There has also been multiple occasion where the car will not power on. Additionally, there has been multiple occasions where the car won’t charge. The failed component is most likely the battery engine control m…
Read full complaint
My Volt will suddenly lose propulsion. The air conditioner will stop working and the car will not properly accelerate. There has also been multiple occasion where the car will not power on. Additionally, there has been multiple occasions where the car won’t charge. The failed component is most likely the battery engine control module. My safety and that of others is at risk because of the sudden loss of power and inability to maintain highway speeds. The issue was confirmed at the dealer. The check engine light goes on even after erasing codes, and there are 13 permanent codes related to this issue with no direct resolution. This is a recurring problem.
NHTSA ODI #11558204
Mileage unknown · Dec 2, 2023
Electrical SystemPower Train
Becm module is failing currently we have an engine check light that illuminates every other drive. Started November 26th. We experienced reduced propulsion message . We have experience the car not going into gear to drive or go reverse. It seems these issues occur at random. Check light codes are u2619-u2624. A dealership will …
Read full complaint
Becm module is failing currently we have an engine check light that illuminates every other drive. Started November 26th. We experienced reduced propulsion message . We have experience the car not going into gear to drive or go reverse. It seems these issues occur at random. Check light codes are u2619-u2624. A dealership will be taking a look at the car on Monday
NHTSA ODI #11558052
Mileage unknown · Dec 1, 2023
Power TrainService Brakes
BECM failure resulted in a situation where the vehicle drove with erratic surging power delivery throwing engine codes P1E00, U2603,U2604, U2605,U2606 Regen braking in this vehicle has a dedicated control on the steering wheel which applies only regen braking no friction brakes. When battery state of charge is high this can res…
Read full complaint
BECM failure resulted in a situation where the vehicle drove with erratic surging power delivery throwing engine codes P1E00, U2603,U2604, U2605,U2606 Regen braking in this vehicle has a dedicated control on the steering wheel which applies only regen braking no friction brakes. When battery state of charge is high this can result in a situation where the regen braking button abruptly (i.e. during one extended activation of the button) delivers less brake force than the user is demanding.
NHTSA ODI #11557979
Mileage unknown · Dec 1, 2023
Electrical SystemFuel/propulsion SystemPower Train
-- My 2017 Chevrolet Volt experienced a failure of the Battery Energy Control Module (BECM) in the powertrain system. This failure prevented my vehicle from being driven. The BECM and related battery pack components were replaced under warranty by a Chevrolet dealership. Those parts, to my knowledge, are not available for inspec…
Read full complaint
-- My 2017 Chevrolet Volt experienced a failure of the Battery Energy Control Module (BECM) in the powertrain system. This failure prevented my vehicle from being driven. The BECM and related battery pack components were replaced under warranty by a Chevrolet dealership. Those parts, to my knowledge, are not available for inspection. -- From a safety perspective, my vehicle was luckily parked when the failure occurred. Many Volt owners have reported -- via online Volt forums and on Reddit at r/volt -- that the failure has occurred while the vehicle is in motion, resulting in a safety issue when the vehicle loses power and stops in the middle of a street or highway. -- A Chevrolet dealership confirmed my vehicle's BECM failure through diagnosis and code reading (see attached documentation). In my case, the BECM initially failed and I lost the ability to drive my vehicle when it was stopped in a parking lot (while I was on vacation, 225 miles from my home). I left the dead vehicle in the parking lot overnight. The next day I was able to start the vehicle and drive it to the nearest EV-certified Chevrolet dealership, where the BECM permanently failed in the dealership's service entrance. I watched the dealership service staff push the dead vehicle into the service bay. It should be noted that I was lucky -- the replacement BECM part was available from GM to the dealership in two days. NHTSA will receive complaints from other Volt owners who waited weeks and MONTHS for a replacement part and repair, all the while their vehicle could not be driven. -- My vehicle's BECM was inspected, the failure diagnosed, and the part replaced by a Chevrolet technician at a Chevrolet dealership (see attached documentation). -- The BECM failure on my vehicle happened immediately with no warning. When I could not drive my vehicle, I saw cryptic "propulsion lost" and "shift transmission to park" error messages on the instrument panel.
NHTSA ODI #11557972
Mileage unknown · Dec 1, 2023
Electrical SystemFuel/propulsion SystemPower Train
BECM failure, covered by warranty but required towing that I had to pay out of pocket. Have been waiting a week for the repair to be completed and the dealer is refusing to provide a loaner vehicle.
NHTSA ODI #11557918
Mileage unknown · Dec 1, 2023
Power Train
The vehicle stopped operating on the highway suddenly and without warning and would not restart. I had it towed to the Chevrolet dealer. They determined power train parts were required which were backordered. They are unclear on which parts. The car has been at the dealer for 2 months waiting for parts. They have no estimate on …
Read full complaint
The vehicle stopped operating on the highway suddenly and without warning and would not restart. I had it towed to the Chevrolet dealer. They determined power train parts were required which were backordered. They are unclear on which parts. The car has been at the dealer for 2 months waiting for parts. They have no estimate on when they will have the parts. I am concerned about the reliability issue and also that they don't have the parts to fix it for months on end.
NHTSA ODI #11557889
Mileage unknown · Dec 1, 2023
Electrical SystemEnginePower Train
BECM issues causing vehicle to lose power, not go in to park, will not remote start, battery failure, and not turning on or not turning off when prompted.
NHTSA ODI #11557847
Mileage unknown · Oct 6, 2023
EngineFuel/propulsion SystemPower Train
Random no starts, engine turns on at random, won’t charge, car jerks, hesitation while driving, hard to climb mountain roads, Battery Energy Control Module Lost Communication With Hybrid/EV Battery Interface Control Module 1-12
NHTSA ODI #11548743
Mileage unknown · Aug 31, 2023
Electrical SystemPower Train
The shifter of the car will NOT go into park! It takes forever. Have to shut it off, start it back up, and keep trying to get it to work. It's insane! This has to be recalled. Literally thousands of people are having this exact same problem. It's all over the internet. And I wouldn't mind if it were a simple $50 repair, but this…
Read full complaint
The shifter of the car will NOT go into park! It takes forever. Have to shut it off, start it back up, and keep trying to get it to work. It's insane! This has to be recalled. Literally thousands of people are having this exact same problem. It's all over the internet. And I wouldn't mind if it were a simple $50 repair, but this is a $500 to $600 thing to fix and it's just not right. The gear shift cable is not long enough. Chevy knows this because they've manufactured a cable extension that needs to be installed. What does that tell you? Manufacturers defect! Please recall these vehicles for this problem and get them to repair their factory mistake. Thank you. Sincerely & Respectfully, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11541979
Mileage unknown · Aug 16, 2023
Power Train
My Chevrolet Volt at 66,XXX miles had a battery energy control module (BECM). We bought the vehicle used three months ago from a dealer, but are just now seeing that the BECM is a very common complaint for Chevrolet Volts. This issue leaves the driver stranded and the vehicle bricked without the unit being able to be moved as …
Read full complaint
My Chevrolet Volt at 66,XXX miles had a battery energy control module (BECM). We bought the vehicle used three months ago from a dealer, but are just now seeing that the BECM is a very common complaint for Chevrolet Volts. This issue leaves the driver stranded and the vehicle bricked without the unit being able to be moved as it cannot be moved into neutral in order to be moved to safety.
NHTSA ODI #11538895
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration