IllustrationMy vehicle shut down in the middle of the road. GM diagnosed it as a faulty BECM.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
Power Train complaints
219 reportssame issue as PE23022 and TSB 18-NA-261 Called 51 parts wharehouses and Chevy dealers to locate part. They all report the same: part is not available and no idea when it will be come available. vehicle is not mobile without working part. Vehicle has lost propulsion while driving. Twice I was lucky no one was behind or on the s…
Read full complaint
same issue as PE23022 and TSB 18-NA-261 Called 51 parts wharehouses and Chevy dealers to locate part. They all report the same: part is not available and no idea when it will be come available. vehicle is not mobile without working part. Vehicle has lost propulsion while driving. Twice I was lucky no one was behind or on the side of me that I could pull off to the side of the road or a parking lot.
1 month ago was driving on toll and Population power is reduced came on, vehicle was reaving high and felt like power was being reduced/speed, was going 70 and had to immediately decrease speed and get off toll and found closest Chevy shop. Looked at dash and vehicle should have had at least 10 energy miles but it had immediate…
Read full complaint
1 month ago was driving on toll and Population power is reduced came on, vehicle was reaving high and felt like power was being reduced/speed, was going 70 and had to immediately decrease speed and get off toll and found closest Chevy shop. Looked at dash and vehicle should have had at least 10 energy miles but it had immediately dropped down to 0. Before taking to Chevy, I had a quick inspection done by a Valvoline shop and they told me the battery had to be replaced. Carvana (Silverrock) warranty refused to do the repair under their coverages as “batteries were not covered under warranty” Had it towed from Valvoline to Chevy. Found out Chevy battery was under warranty so it was taken there. Vehicle was checked in and didn’t have an eta as hybrid battery was on back order with no ETA. 3 weeks later the part was received and it was a control module not a battery as the “battery was not failing at the time”. Service called and said vehicle was ready for pick up. Had vehicle for 1 week and was at work starting it up and after 9 hours sitting started it up and low population came back on and vehicle started idling higher than before then after a minute looked at back of car and a large cloud of while smoke started forming from back of vehicle. Immediately turned off car and called gmc roadside assistance to have vehicle towed to another dealership where is it sitting again for diagnosis with no eta.
Car won't start show codes U2622, U2621, U2620, U2619, P0AFA.
While driving in 60 degree weather, the vehicle’s check engine light lit on the dash and the vehicle abruptly stopped. I was able to push the vehicle safely in heavy traffic. I contacted Onstar who gave me the vehicle diagnosis. Onstar advised the following codes appeared POACA (Hybrid/ electric vehicle powertrain control module…
Read full complaint
While driving in 60 degree weather, the vehicle’s check engine light lit on the dash and the vehicle abruptly stopped. I was able to push the vehicle safely in heavy traffic. I contacted Onstar who gave me the vehicle diagnosis. Onstar advised the following codes appeared POACA (Hybrid/ electric vehicle powertrain control module requested malfunction indicator lamp illumination), P1AEE ( the electric propulsion system is not performing as expected. Please service immediately), and P1AEF (the electric propulsion system is not performing as expected).
Car stopped operation while out doing errands. Car had to be parked and restarted and made it back home. Car would not start again. Had to have it towed to dealership, BECM needs replaced for $2000. Warranty should cover, but part is backordered. Not sure when it will be fixed and with the recent freezing temperatures could have…
Read full complaint
Car stopped operation while out doing errands. Car had to be parked and restarted and made it back home. Car would not start again. Had to have it towed to dealership, BECM needs replaced for $2000. Warranty should cover, but part is backordered. Not sure when it will be fixed and with the recent freezing temperatures could have been dangerous.
Vehicle stopped running, will not restart. ODB codes show failure of the BECM. Check engine light illuminated, READY indication turned off. Vehicle does not display battery or fuel status. We were left stranded by this failure.
While driving the car in electric mode, a chime came on and flashed 'propulsion power is reduced', then it went into engine mode and the car decelerated quickly from posted 70mph speed to less than 40mph even though I pushed the accelerator pedal and reved the engine high. While in this low power driving mode, a warning came on…
Read full complaint
While driving the car in electric mode, a chime came on and flashed 'propulsion power is reduced', then it went into engine mode and the car decelerated quickly from posted 70mph speed to less than 40mph even though I pushed the accelerator pedal and reved the engine high. While in this low power driving mode, a warning came on saying the collision detection system was disabled. The concern is the person behind me had no warning since my brake lights did not come on. He sped around me with a bit of road rage. The problem temporarily goes away when you turn the ignition off and back on. I took it to the dealer and the said it needed a new EGR Cooler 4 hours labor $1500. Chevy Dealer pulled two codes P0401 Exhaust Gas Recirculation "A" Flow Insufficient Detected P1E00 Hybrid/EV Powertrain Control Module 2 I paid them the $165 diagnosis fee and got my car back and just plan to restart when it occurs. In another instance, I was pulling out from a parking lot into a busy road in electric mode and the car lost ALL power leaving me exposed in the line of traffic. Error messages on the dash said to 'service BECM' and 'shift to park'. The car was not drivable and had to be towed. Call me if you need any more information. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle suddenly would not function. All systems became inoperable. When serviced it was determined to be a sudden failure of the BECM module which required total replacement. Part was on national back order leaving vehicle unusable for weeks.
Loss of Motive Power due to EGR Valve. I was driving down the highway when I experienced a loss of motive power and the Volt entered a reduced power state while in moving traffic. After the EV battery ran out and the ICE turned on, the following message showed up on the instrument panel "Propulsion Power Is Reduced" and the chec…
Read full complaint
Loss of Motive Power due to EGR Valve. I was driving down the highway when I experienced a loss of motive power and the Volt entered a reduced power state while in moving traffic. After the EV battery ran out and the ICE turned on, the following message showed up on the instrument panel "Propulsion Power Is Reduced" and the check engine light turned on. The Volt slowed down and would not accelerate to the speed of the moving traffic. I was able to get off the highway and drive home under reduced power which was still not safe. The engine ran very rough on the way home and was not able to maintain speed high enough for the flow of traffic on the roads. The dealer diagnosed the issues as a failed EGR Valve. The part was on backorder for about a month. In that time, a GM trained technician deemed the car operable (according to GM standards) and said that I could take it back and drive it on electricity only. Unfortunately, that meant that the EV range is about 40 miles in winter after a full charge and running out of electricity would again result in a hazardous loss of power. The behavior of the car under this reduced propulsion is Identical to the one in investigation PE23022 - Loss of Motive Power due to the Battery Energy Control Module. The Chevy Volt EGR Valve issue is a common problem reported in other NHTSA complaints and Volt forum posts and I am surprised that there has not been a recall. I hope that this issue is investigated same as the BECM issue. Some examples: NHTSA ID Number: 11558668 NHTSA ID Number: 11557845 NHTSA ID Number: 11557876 NHTSA ID Number: 11557995 NHTSA ID Number: 11483673 [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.