I will get a "shift to park" message on the dash when parking the car and trying to turn it off. When it happens, the car will not turn off and claims it is not in park. The shifter is physically in the park position, but the car does not recognize it. I have to shift it in and out of park multiple times to get it to recogniz…
Read full complaint
I will get a "shift to park" message on the dash when parking the car and trying to turn it off. When it happens, the car will not turn off and claims it is not in park. The shifter is physically in the park position, but the car does not recognize it. I have to shift it in and out of park multiple times to get it to recognize that it is in park. On a few occasions, I have had to leave it on and lock the doors because it just would not recognize that the car was in park.
NHTSA ODI #11479473
Mileage unknown · Aug 13, 2022
Forward Collision AvoidancePower Train
The vehicle stopped on its own without obstacles. The vehicle fails to stop under adaptive cruse control and you have to disengage to stop or it will hit the car in front. When stepping on break during adaptive cruse it lurching forward before breaking takes over causing a hazzard. When you shif to park it doesn't register and w…
Read full complaint
The vehicle stopped on its own without obstacles. The vehicle fails to stop under adaptive cruse control and you have to disengage to stop or it will hit the car in front. When stepping on break during adaptive cruse it lurching forward before breaking takes over causing a hazzard. When you shif to park it doesn't register and will kill battery. Adaptive cruse does not keep it centered in clearly marked lanes.
NHTSA ODI #11479102
Mileage unknown · Jul 26, 2022
Power Train
This Chevy Volt experiences transmission's shift-to-park error. This error prevents car from turning off due to not recognizing the shift gear is in the park position. After placing the shift into park and turning the power button off, the car turns back on again and flashes the shift-to-park error message. This apparently is …
Read full complaint
This Chevy Volt experiences transmission's shift-to-park error. This error prevents car from turning off due to not recognizing the shift gear is in the park position. After placing the shift into park and turning the power button off, the car turns back on again and flashes the shift-to-park error message. This apparently is a malfunction of gear shift which has been widely reported on GM-Volt community board on 2nd generation Volts.
NHTSA ODI #11475848
Mileage unknown · Jul 24, 2022
Power Train
A lot of times when i turned off the car "shift to park" message comes on. First time i've noticed this was about few months back. Then, it happened maybe 2-3 times, but now It has been happening constantly. Almost every time i turned off the car.
NHTSA ODI #11475581
Mileage unknown · Jul 15, 2022
EngineFuel/propulsion SystemPower Train
from all my reading and my own knowledge and what I have read on forums from others who have had the same issue, this problem is due to the cars BECM (battery energy control module) going bad unexpectedly. apparently this has happened to many other people driving the generation 2 Chevy volt at varying mileages. On the highway on…
Read full complaint
from all my reading and my own knowledge and what I have read on forums from others who have had the same issue, this problem is due to the cars BECM (battery energy control module) going bad unexpectedly. apparently this has happened to many other people driving the generation 2 Chevy volt at varying mileages. On the highway on her way home from work, my wife experienced a large loss of power and the car started shuddering and switching between the electric and gas powertrain as well as slowing down quite a bit. the dash showed a notification of "propulsion power reduced". the car also lost power to many of its accessories. she ended up having to pull over on the side of a busy highway and turn the car on and off again till it would finally work and managed to limp it home along back roads. if she had not had a shoulder to pull on to she would have been stuck in the middle of the highway. the car had absolutely zero issues before this, but since the incident has had a check engine light illuminated and is unable to charge unless the codes are reset. it is drivable again after getting some codes cleared but as it poses a serious hazard we are trying to find a temporary car till we can get this fixed. our car has about 100900 miles on it, but these failures happen as soon as 25k-50k on a lot of vehicles. it has not been inspected by anyone yet as it happened yesterday.
NHTSA ODI #11474143
Mileage unknown · Jul 12, 2022
Power Train
When I put my car in park , it tells me to shift to park and will not turn off
NHTSA ODI #11473531
Mileage unknown · Jun 13, 2022
Power Train
Sometimes after I have shifted to park and push the power button, an error message displays on the dash reading “shift to park” and the car’s power will not shut off. This happens frequently. It will usually take multiple tries of shifting to drive and back to park before the car will recognize it.
NHTSA ODI #11469017
Mileage unknown · May 30, 2022
Fuel/propulsion SystemPower Train
2016-2018 Volts are have a hung issues with the Battery Engine Control Module (BECM). When it fails, the car stops driving and will shift itself to park. Mine lucky failed when I was stopped but the car is unable to move when it fails. It will not drive on the motor or the battery.
NHTSA ODI #11466630
Mileage unknown · May 25, 2022
Power Train
When parking and turning off the vehicle, I get a message saying "shift to park" even though the vehicle is in park already. This keeps all the electronics and the car still partially "on."
NHTSA ODI #11466148
Mileage unknown · May 18, 2022
Power Train
When attempting to turn off ignition, “shift to park” message appears even though the gear shift is already in park. Unable to power vehicle off. Already had dealer replace gear shift wiring harness when this issue occurred the first time.
NHTSA ODI #11465149
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration