IllustrationDuring a drive the car began warning of loss of propulsion. The vehicle is at a dealer waiting for repair since Oct 16, 2023. There is no ETA on back ordered EGR valve that the technician anticipates a fix.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
Fuel/propulsion System complaints
233 reportsAs reported by the dealer the Battery Energy Control Module (BECM) has failed. Car initially did not start but then did start with a check engine light and a "Propulsion Power is Reduced" warning. Vehicle has approximately 56,500 miles. Car could have abruptly stopped or slowed considerably while driving. Chevrolet dealer is bl…
Read full complaint
As reported by the dealer the Battery Energy Control Module (BECM) has failed. Car initially did not start but then did start with a check engine light and a "Propulsion Power is Reduced" warning. Vehicle has approximately 56,500 miles. Car could have abruptly stopped or slowed considerably while driving. Chevrolet dealer is blaming the current UAW strike for complete lack of replacement parts. They also state there is no way to forecast a delivery date of the part. I am out a vehicle for an unknown amount of time with no promise that GM will reimburse me for out of pocket expenses for a rental vehicle.
While driving after the electric battery is used and switches over to gas, I have been getting the check engine, ABS, steering, parking, and brake lights. I have lost power steering, lost the speedometer, lost fuel range, lost stabilitrak, it has randomly turned on the emergency brake while all these other things are happening,…
Read full complaint
While driving after the electric battery is used and switches over to gas, I have been getting the check engine, ABS, steering, parking, and brake lights. I have lost power steering, lost the speedometer, lost fuel range, lost stabilitrak, it has randomly turned on the emergency brake while all these other things are happening, It also has said “shift to park”, propulsion power reduced. I have taken it to the dealer and they read some of the codes but say they can’t find anything wrong and they need to be able to reproduce the problem to find it. I lost all propulsion and pulled over and turned it off and it stopped with a “clunk.” Then I turn it back on and just the check engine light is on. I’m very afraid to drive it but with the lack of vehicles available to buy and the dealer not knowing how to fix it I don’t know what to do.
Random no starts, engine turns on at random, won’t charge, car jerks, hesitation while driving, hard to climb mountain roads, Battery Energy Control Module Lost Communication With Hybrid/EV Battery Interface Control Module 1-12
The vehicle suddenly, and unexpectedly lost propulsion while driving. The vehicle is no longer able to turn on or drive. I contacted several Chevy official dealers and took the car in for repair. They said it is a problem with the hybrid battery system. But the car is no longer manufactured and parts are no longer available. So …
Read full complaint
The vehicle suddenly, and unexpectedly lost propulsion while driving. The vehicle is no longer able to turn on or drive. I contacted several Chevy official dealers and took the car in for repair. They said it is a problem with the hybrid battery system. But the car is no longer manufactured and parts are no longer available. So I am now stuck with a car that is non-operational and not repairable.
When I first purchased the car (used around 30,000 miles), I began to have electrical and propulsion issues where the engine would turn off. After Chevy refused to warranty or lemon the car, eventually the electrical/hybrid issue repeated and caused cooling issues with the car and then water pump went bad. while chevy still refu…
Read full complaint
When I first purchased the car (used around 30,000 miles), I began to have electrical and propulsion issues where the engine would turn off. After Chevy refused to warranty or lemon the car, eventually the electrical/hybrid issue repeated and caused cooling issues with the car and then water pump went bad. while chevy still refused to fix the hybrid and battery issues, that continued issue and then the water pump failing from it then caused overheating that then broke the head gasket
After the battery runs out, the engine loses propulsion and fails to run on gas. The car completely stalls in the middle of traffic. The speed drops from 70+ mph to 0. Extremely dangerous to myself and others. The issue suddenly appeared at the end of December 2022 during a long drive. The engine check light remains on and a war…
Read full complaint
After the battery runs out, the engine loses propulsion and fails to run on gas. The car completely stalls in the middle of traffic. The speed drops from 70+ mph to 0. Extremely dangerous to myself and others. The issue suddenly appeared at the end of December 2022 during a long drive. The engine check light remains on and a warning re: reduced propulsion power is displayed every time the car is turned on. Dealer is unable to fix the issue because they already have multiple cars with the same issue waiting for weeks to be repaired. Recently filed class action law suit suggests that this problem is caused by defective BCEM unit.
The Battery Energy Control Module (BECM) has failed. On two occasions this put me at risk of collision because when the BECM lost communication my car stalled as I was accelerating away from a stop sign. On one occasion, cross traffic had to come to a stop so I could push my car out of the intersection. The car is currently a…
Read full complaint
The Battery Energy Control Module (BECM) has failed. On two occasions this put me at risk of collision because when the BECM lost communication my car stalled as I was accelerating away from a stop sign. On one occasion, cross traffic had to come to a stop so I could push my car out of the intersection. The car is currently at the dealer for repair. The problem has been confirmed to be the BECM. There was no advance warning when this occurred. A message came up during the incident that said, "Propulsion Power Is Reduced" and following the incident, the check engine light illuminated. The warnings appeared at the time of the incident. There was no advance warning.
BECM failure. Initially, it caused the vehicle to operate in a low propulsion state. However, it now prevents the vehicle from starting. Likewise, I have heard it has stopped the engines from working/shut down the engines while people are driving on the highway.
About 3 minutes after I started driving the 2017 Chevy Volt, an error message showed saying "propulsion power is reduced" and I was unable to drive the vehicle as typical. While driving on base at fairly low speed (~15-20mph) in the battery area of the display, the EV range was reading 12mi, and it started going up. When it re…
Read full complaint
About 3 minutes after I started driving the 2017 Chevy Volt, an error message showed saying "propulsion power is reduced" and I was unable to drive the vehicle as typical. While driving on base at fairly low speed (~15-20mph) in the battery area of the display, the EV range was reading 12mi, and it started going up. When it read 20mi, the "Propulsion power reduced" showed on the display and the check engine light came on. I pulled over to a different building, went inside for a few minutes, came back out and restarted the car, and I got a message the Volt wouldn't initialize. After multiple on/off button pushes to start the car, the car finally initialized to where I was able to drive home in the "Propulsion Power Reduced mode", and I was not able to accelerate as expected - the vehicle was very sluggish. I drove home at about 45-50mph. My drive home is about 38 mi one way.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.