2017 Chevrolet Volt

While making a 90 mile drive on 7/20, after having depleted the primary battery charge and switched to hybrid mode, a "propulsion power is reduced" warning appeared on the console, along with the Check Engine Light. Other than somewhat reduced power (max displayed of ~40-50 kW), performance otherwise seemed unimpeded. Contacted local dealership to schedule service for earliest available date of 7/26. Car made return 90 mile trip on 7/21 without issue additional issue ("propulsion power is reduced" message remained.) Service identified "numerous codes", but replaced a fuse known to result in the above issue and observed no other issues. Car was driven purely on battery at that time, and for the intervening time until a 170 mile drive on 8/2, where the message and Check Engine Light reappeared, again after battery charge was consumed and car switched to hybrid power mode. Dealership was again contacted to schedule service, slated for the morning of 8/7 (tomorrow, as of this writing). Car reached its destination without further incident. During return 170 mile trip on 8/5, traveling on the highway, car abruptly alerted that the engine was no longer available and entered a severely reduced-power mode. Car had been operating in "mountain mode" (conserving some extra battery charge) as a precaution, so we were able safely exit the highway and pull into a local parking lot, at which point AAA was contacted to tow the car the remaining 120 miles home. Upon arriving home, the car was able to pull into the garage without the "engine not available" alert, but still displaying Check Engine Light and "propulsion power reduced" messages. We have come to understand this is a fairly common issue with Generation II Volts and have been advised by other owners to file this report.

10 months ago, I took my vehicle in to the local chevy dealership because the check engine light was on and I had noticed the vehicle seemed to be running rough. I had also seen a message that said the vehicle was running at reduced propulsion. The dealership told me I had a shorted EGR valve which also cause fuse 3 to blow and ordered the part. Then I waited. My vehicle stopped running on the road once. Just died. I had no battery charge remaining either. That was a safety issue for me and anyone who might hit my car because it was on the road. I sat there for a while and then tried to start it. I wasn't far from home and was able to limp home. I waited for months, contacted the Chevy/GM manufacturer and kept in contact with the dealership. Over the next 10 months was told several different things: part not being made, strike affected part manufacture, part and install price was increasing to $3500, can install Chinese part without warranty, dealership had 2 other people waiting for the part like me, part was not covered under any warranty. I was called a couple days ago to hear that there was a GM manufactured part available for my car but it would be $3500. I asked for a reduction in cost since I had waited so long. I was told they could reduce the price by $500. I said I had been quoted $1200 in 2023 when I took the vehicle in. I was told to share anything I had in writing for that. I found my invoice which showed the purchase cost for the parts ($717.80) which I just sent. I received a call today telling me the dealership has the part and will give it to someone else unless I agree to get it done today for $3500; however, since I did not know the part was even here for me, they will wait one more day to hear if the manufacturer will honor the original quote. For the last 10 months, I had no car to drive or could drive it on battery and hope I didn't run out of charge (~50 miles of battery charge) and get stranded on the road again.

[XXX], while driving on [XXX], check engine light came on with reduced propulsion warning. Continued driving to destination without incidence. Did not drive again until [XXX]. [XXX] while driving using "hold" method of propulsion using internal combustion engine, check engine light remained on, after the engine warmed up, all of the sudden, there was a noticeable reduction of power, followed shortly by the internal combustion engine shutting off while I was entering onto an interstate highway ramp. Fortunately I was able to pull off to the side of the road and back down the ramp without incidence and return home under grossly reduced battery propulsion. July 8, took vehicle to Chevrolet dealership (Baierl Chevrolet, Wexford PA) under battery power. Was told ECM module was bad. ECM module was replaced, error codes cleared, vehicle ran as expected. after driving approximately 50 miles, check engine light with reduced propulsion warning returned. Turned vehicle around and returned to the same dealership. Was told EGR valve was bad while blowing fuse F03 (Non walk home circuit). The dealership did not have a replacement in stock and it would take 7-10 days to obtain a replacement. I had to rent a vehicle out of my own pocket to return home for employment purposes. July 11th, I emailed dealership's service advisor for status of replacement part. Never heard back from service advisor. July 15, 11:24 am, talked to dealership service advisor, was told part was in transit with no estimated delivery date. July 22 called service adviser and left a voice mail message for a return status call. Never received a return call. July 23, called dealership, talked to parts department for part status, was told part had not shipped from warehouse yet and there was no estimate on shipment. After having to return the rental vehicle, I am without a vehicle for my daily required activities. Not an acceptable situations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving down the highway at normal speeds when I noticed the engine temperature began climbing out of the blue, and eventually the CEL light came on before the dashboard read "Propulsion Power Reduced" and eventually the engine stopped entirely and I had to coast to an area on the side of the highway where I could pull over. The battery-only part of the car was drained but there was plenty of gas in the tank, so my only way out was via the ICE. I turned the car off, waited for it to cool down, then turned it back on, only for the same issue to occur within another couple of miles of highway driving. I had to repeat this process until I was able to get to an exit and coast to a business that would let me recharge the battery enough to drive on battery-only where I could park it overnight, as I was not near my home. Eventually I had to get the car towed to a dealership, where I was told it was either an EGR valve or EGR cooler that needed replacing. After the dealership refused to provide any specifics regarding the diagnostics in writing, Chevrolet corporate informed me that it was an EGR valve that was requested and is on global backorder. This issue has not been resolved for a year now, and put me in the extremely dangerous position of losing power entirely on the highway with almost no warning, and no statements to date that would have prepared me to deal with this issue.

On a recent trip on a highway on our 2017 Chevy Volt, the Exhaust Gas Recirculation [EGR] failed and caused "low propulsion" errors. We ended up with a surprise bill of more than a thousand dollars to replace the EGR cooler assembly, but the problem was not resolved. The dealership then said we need to replace the EGR Valve which is estimated above $2700 plus labor. Upon checking the GM-Volt users community this is a reoccurring issue on several thousands of vehicles and the inflated price is due to the fact that GM redesigned the EGR valve to fix their original faulty design. We as consumers shouldn't be responsible for such an outrageous cost and mainly safety due to a design flow by GM. This issue should warrant a recall by GM to fix the issue once and for all.

While driving down the highway a "reduced propulsion" message appeared on the dashboard and the drive became very rough if speed changed, also the engine temperature increased but it did not overheat before we could stop. This was diagnosed as an Exhaust Gas Recirculation (EGR) Valve failure. I spoke to multiple dealers and did research online as well and this is a very common issue on this vehicle. So common that the part is impossible to get and has an eight month wait which means I cannot drive my vehicle. What component or system failed or malfunctioned, and is it available for inspection upon request? EGR Valve How was your safety or the safety of others put at risk? My car had reduced propulsion, engine temperature increased and it suddenly lost speed quickly on highway when my foot was removed from gas pedal. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, Chevrolet is aware of this issue and say we just have to wait 8 months for the part. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No pre-warning a "reduced propulsion" message and a check engine light turned on at the time of the EGR valve failure.

Driving at freeway speeds when suddenly the cars propulsion power failed and I went from 75mph to 45mph with no warning and no way to accelerate. Happened multiple times even after pulling over and turning the car on and off. I was told by the dealership that was a gas engine part and that I could drive it on the electrical engine only. When attempting to drive on the electrical engine, I received a notice of engine failure and had to coast into the driveway of a dealership. I was told the engine “could explode” if I continue to drive it

The contact owns a 2017 Chevrolet Volt. The contact stated while her son was driving approximately 55 MPH, the vehicle lost motive power. The contact stated that the battery system became inoperable. The vehicle was towed to the local dealer, where it was diagnosed that the cells and battery needed to be replaced. The vehicle was not repaired. The dealer informed the contact that parts were on backorder. The manufacturer was contacted and opened a case. The failure mileage was approximately 69,000.