Driving at freeway speeds when suddenly the cars propulsion power failed and I went from 75mph to 45mph with no warning and no way to accelerate. Happened multiple times even after pulling over and turning the car on and off. I was told by the dealership that was a gas engine part and that I could drive it on the electrical engi…
Read full complaint
Driving at freeway speeds when suddenly the cars propulsion power failed and I went from 75mph to 45mph with no warning and no way to accelerate. Happened multiple times even after pulling over and turning the car on and off. I was told by the dealership that was a gas engine part and that I could drive it on the electrical engine only. When attempting to drive on the electrical engine, I received a notice of engine failure and had to coast into the driveway of a dealership. I was told the engine “could explode” if I continue to drive it
NHTSA ODI #11591648
Mileage unknown · May 29, 2024
Electrical SystemFuel/propulsion SystemUnknown Or Other
The car stalled at a high rate of speed on a freeway because of EGR failure. Engine check light is on, along with a warning about a critical problem with emissions system that requires immediate attention. The part is out of stock in all dealership within a reasonable reach. The problem is under warranty, but I have made multipl…
Read full complaint
The car stalled at a high rate of speed on a freeway because of EGR failure. Engine check light is on, along with a warning about a critical problem with emissions system that requires immediate attention. The part is out of stock in all dealership within a reasonable reach. The problem is under warranty, but I have made multiple attempts to fix this issue with no success.
NHTSA ODI #11591283
69,000 miles · May 20, 2024
Electrical SystemEngine
The contact owns a 2017 Chevrolet Volt. The contact stated while her son was driving approximately 55 MPH, the vehicle lost motive power. The contact stated that the battery system became inoperable. The vehicle was towed to the local dealer, where it was diagnosed that the cells and battery needed to be replaced. The vehicle wa…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated while her son was driving approximately 55 MPH, the vehicle lost motive power. The contact stated that the battery system became inoperable. The vehicle was towed to the local dealer, where it was diagnosed that the cells and battery needed to be replaced. The vehicle was not repaired. The dealer informed the contact that parts were on backorder. The manufacturer was contacted and opened a case. The failure mileage was approximately 69,000.
NHTSA ODI #11589640
Mileage unknown · May 11, 2024
Electrical System
Intermittently, I can't shut off my Volt. The following message is displayed: "Shift to Park"
Driving at highway speed car would slow down on its own and go into "Reduced Propulsion Mode"
NHTSA ODI #11587827
142,974 miles · Apr 30, 2024
Electrical SystemEngine
The contact owns a 2017 Chevrolet Volt. The contact stated that while his daughter was driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the next morning when he attempted to start the vehicle, the vehicle made an abnormally loud sound. The contact shifted into reverse and the v…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated that while his daughter was driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the next morning when he attempted to start the vehicle, the vehicle made an abnormally loud sound. The contact shifted into reverse and the vehicle stalled. The vehicle was towed to the dealer. The vehicle was diagnosed with a battery malfunction. The vehicle was repaired; however, the check engine warning light remained illuminated. The contact related the failure to Manufacturer Communication Number: 10251431 (Electrical System) and TSB Number: N232422680 (Special Coverage Battery Energy Control Module Malfunction). The manufacturer was made aware of the failure and the contact was informed that the vehicle was not included. The failure mileage was approximately 142,974.
NHTSA ODI #11586186
Mileage unknown · Apr 19, 2024
Electrical SystemEngine
My service engine light came on. After that happened, my engine started to get hot. It got up to 230degF, received a reduced propulsion message and wanted to shut down when going 70mph on the interstate (depended on the construction). Quick reaction on my side before the engine shut down I had "held" the battery (which i do f…
Read full complaint
My service engine light came on. After that happened, my engine started to get hot. It got up to 230degF, received a reduced propulsion message and wanted to shut down when going 70mph on the interstate (depended on the construction). Quick reaction on my side before the engine shut down I had "held" the battery (which i do for long trips to ensure options in event of emergencies). Meaning i still had energy in the battery that could be used to propel the vehicle. I was able to shut down the engine by unholding the battery before losing control of the vehicle due to no propulsion. The electric propulsion took over and I could get off the freeway. Conditions were: I was driving in a rain storm on a very busy interstate around Eau Claire wisconsin right around 5-6pm with lots of road construction. If I would have lost the engine and power, I would have crashed at a high rate of speed. I would have lost steering, windshield wipers and headlights. Investigation showed that fuse F03 (walk home fuse) was blown. Further investigation showed that the EGR Valve circuitry was causing this failure. After unplugging EGR valve and replacing the fuse, engine was able to run and not overheat. Plug the EGR valve back in and the fuse blows again This is a well known issue on these vehicles and has been around since 2019-2020. Lots of data and information available on this issue on the internet. To make the issue worse. No parts are available for replacing this faulty valve at the moment. Only 6 valves available in the whole USA with those promised to other customers (i Called the dealers). Additionally there are more vehicles waiting for these valves.. Vehicle goes to the shop on [XXX] for confirmation of issue and get on a waiting list for the EGR Valve. I can't believe this is allowed to continue with GM. THis needs to be fixed!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11584038
Mileage unknown · Apr 18, 2024
Electrical System
While car will turn on as normal, wheb put I to drive is says "Action Required - Shift to Park". The CEL code indicates, among other things, "EV/Hybrid Battery ppsitive contactor circuit stuck closed". I've read this has happened to may owners. Reading online seems to indicate
NHTSA ODI #11583894
Mileage unknown · Apr 17, 2024
Electrical System
Shift to park warning comes and car will will not shut down I have already had this repaired in 2019
NHTSA ODI #11583712
22,000 miles · Apr 10, 2024
Electrical System
The contact owns a 2017 Chevrolet Volt. The contact stated while driving at approximately 70 MPH, the message "Reduce Propulsion" was suddenly displayed, and the vehicle decelerated to 30 MPH. The vehicle was later taken to the local dealer who diagnosed that the ERG was faulty and needed to be replaced. The vehicle was not yet …
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated while driving at approximately 70 MPH, the message "Reduce Propulsion" was suddenly displayed, and the vehicle decelerated to 30 MPH. The vehicle was later taken to the local dealer who diagnosed that the ERG was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 22,000.
NHTSA ODI #11582166
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration