Airbag warning light illuminated on dash. Vehicle no longer registered the passenger in the front passenger seat. Dealer states diagnostic code indicates OCCUPANT POSITION DETECTION SYSTEM SENSOR is faulty. None in stock and no expected delivery date. Until part is repaired/replaced the vehicle will not detect a front seat pa…
Read full complaint
Airbag warning light illuminated on dash. Vehicle no longer registered the passenger in the front passenger seat. Dealer states diagnostic code indicates OCCUPANT POSITION DETECTION SYSTEM SENSOR is faulty. None in stock and no expected delivery date. Until part is repaired/replaced the vehicle will not detect a front seat passenger so the front seat passenger airbags will NOT deploy in a collision. Dealer states cost of repair to be in excess of $1,100!!
NHTSA ODI #11617102
20,000 miles · Aug 13, 2024
Air Bags
The contact owns a 2017 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the contact became aware that the air bag warning light illuminated. The vehicle was taken to the dealer however, the vehicle was not diagnosed, or repaired. The manufacturer was not made aware of the failure. The failure mileage wa…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the contact became aware that the air bag warning light illuminated. The vehicle was taken to the dealer however, the vehicle was not diagnosed, or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
NHTSA ODI #11608316
Mileage unknown · Sep 15, 2023
Air Bags
The service airbag indicator and airbag light illuminated on my dash. I took the vehicle to the dealership and was told the passenger presence module needs replaced. Without this repair, all airbags in the vehicle are disabled when the light is on. Yes, its been reproduced by the Chevrolet dealer.
NHTSA ODI #11544652
78,000 miles · Mar 24, 2023
Air BagsElectrical SystemCrashInjury
The contact owns a 2017 Chevrolet Volt. The contact stated that while driving approximately 40 mph, another unknown vehicle crashed into his vehicle which went airborne and over the median. There were no warning lights to illuminate. A police report was not filed. There was no reported fire or air bag deployment. The contact su…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated that while driving approximately 40 mph, another unknown vehicle crashed into his vehicle which went airborne and over the median. There were no warning lights to illuminate. A police report was not filed. There was no reported fire or air bag deployment. The contact sustained injuries to his neck and back and medical attention was provided. The vehicle was towed to a body shop who informed him the battery was scratched. The vehicle was towed to the local dealer where the battery electronic module was damaged due to being dropped. The vehicle was not repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 78,000.
NHTSA ODI #11513550
Mileage unknown · May 31, 2022
Air Bags
The airbag warning light is lit and the system says the airbag needs service. It appears to require an $ 800 replacement of a part.
NHTSA ODI #11466827
Mileage unknown · Nov 30, 2021
Air BagsSeats
The vehicle’s service airbag warning light is illuminated. The dealership diagnostic indicates that the passenger seat sensor needs to be replaced. Based on my research, this was also an issue with the Volt’s 1st Gen models.
NHTSA ODI #11442195
41,000 miles · Nov 27, 2020
Air BagsElectrical System
41000 MILES AIRBAG SERVICE LIGHT ON AT ALL TIMES WHEN CAR IS POWERED ON. PASSENGER AIRBAG LIGHT ON OR OFF STATUS IS TOTALLY DARK, NO INDICATION OF STATUS. DOES NOT MATTER IF A PASSENGER IS IN THE SEAT OF NOT OR IF THE CAR IS MOVING OR NOT.
NHTSA ODI #11376728
Mileage unknown · Feb 18, 2020
Air Bags
MY 2017 CHEVY VOLT GIVES ME 'SERVICE AIRBAG' WARNING ALL THE TIME. AND THE DEALER SAYS IT IS NOT COVERED UNDER WARRANTY, BUT THE CAR HAS NEVER MET WITH ANY ACCIDENTS OR SPILLS. SO THERE IS NO REASON FOR CUSTOMER DAMAGE. I SEE THAT THE SAME ISSUE WAS BEEN RAISED BY MANY UNDER PE19013. SO I WOULD WANT GM TO TAKE CARE OF THEIR MANU…
Read full complaint
MY 2017 CHEVY VOLT GIVES ME 'SERVICE AIRBAG' WARNING ALL THE TIME. AND THE DEALER SAYS IT IS NOT COVERED UNDER WARRANTY, BUT THE CAR HAS NEVER MET WITH ANY ACCIDENTS OR SPILLS. SO THERE IS NO REASON FOR CUSTOMER DAMAGE. I SEE THAT THE SAME ISSUE WAS BEEN RAISED BY MANY UNDER PE19013. SO I WOULD WANT GM TO TAKE CARE OF THEIR MANUFACTURING DEFECT RATHER THAN SAYING IT IS NOT COVERED UNDER W
NHTSA ODI #11309931
20,000 miles · Feb 3, 2020
Air BagsCrashInjury
MY VOLT WAS T-BONED ON THE PASSENGER SIDE OF THE CAR BY A RED LIGHT RUNNER. I HAD JUST STARTED TO ENTER INTO THE INTERSECTION A SECOND OR SO AFTER MY LIGHT TURNED GREEN, SO NOT GOING VERY FAST. THE OTHER CAR WAS GOING 25-35 MPH (APPROX.). THIS WAS ON A CITY STREET, BOTH ONE WAYS STREETS SO THAT DRIVER WAS ABLE TO BUILD UP SOME …
Read full complaint
MY VOLT WAS T-BONED ON THE PASSENGER SIDE OF THE CAR BY A RED LIGHT RUNNER. I HAD JUST STARTED TO ENTER INTO THE INTERSECTION A SECOND OR SO AFTER MY LIGHT TURNED GREEN, SO NOT GOING VERY FAST. THE OTHER CAR WAS GOING 25-35 MPH (APPROX.). THIS WAS ON A CITY STREET, BOTH ONE WAYS STREETS SO THAT DRIVER WAS ABLE TO BUILD UP SOME MOMENTUM. I WAS PUSHED INTO THE CAR TO MY LEFT (DRIVER'S SIDE). THE DAMAGE WAS ENOUGH TO TOTAL THE CAR. THE AIR BAGS WERE NOT DEPLOYED.
NHTSA ODI #11306849
37,948 miles · Oct 4, 2019
Air BagsElectrical System
THE SENSING DIAGNOSTIC MODULE FAILED AT ~38K MILES CAUSING THE AIRBAGS TO STOP WORKING. THIS HAPPENED WHEN THE VEHICLE WAS PARKED.
NHTSA ODI #11266038
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration