NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
169 reportsMileage unknown · Oct 14, 2024
EngineFuel/propulsion SystemPower Train
Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driv…
Read full complaint
Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driving movement. Quite a safety concern. A "shift to park" error displays on driver display screen. An OBD2 scanner will clear code & after a few attempts remain operational. However intermittent & unpredictable when to expect the loss of traction power.
NHTSA ODI #11619712
Mileage unknown · Oct 11, 2024
Electrical SystemFuel/propulsion SystemPower Train
My 2016 Chevrolet Volt loses power while driving and the "propulsion power reduced" warning message appears. This has happened multiple times in the past few weeks and it is very dangerous losing power while traveling. After taking it to a Chevy dealer for service, they advised that it was an internal failure of the BECM (batt…
Read full complaint
My 2016 Chevrolet Volt loses power while driving and the "propulsion power reduced" warning message appears. This has happened multiple times in the past few weeks and it is very dangerous losing power while traveling. After taking it to a Chevy dealer for service, they advised that it was an internal failure of the BECM (battery energy control module) and that it would need replaced. After searching online it appears that this is a common issue with the Chevy Volt models from 2016 - 2019. So much so that GM extended a special warranty to cover this failure up to 15yrs and 150,000 miles. Unfortunately for reasons I still don't understand, I was informed that my vehicle is not covered under this special warranty despite it specifically being the year and model that is affected. My vehicle currently has 93k miles and was purchased in 2016. So I am just outside the original 8 year 100k mile warranty but thought I was covered under this new special coverage given that this is an issue that GM is clearly aware of. I was also shocked to find out that there apparently was never a recall for this issue. My wife and child normally take this vehicle across town at highway speeds and I'm lucky the issue only happened to me. I fear for those who brought their vehicles and are not aware of the issue and will be told that theirs isn't covered as well.
NHTSA ODI #11619238
Mileage unknown · Oct 9, 2024
EngineFuel/propulsion SystemPower Train
The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.
NHTSA ODI #11619001
Mileage unknown · Oct 4, 2024
Fuel/propulsion System
Our BECM failed while we were driving. It went into limp mode, not allowing the car over 35mph and with no AC in 109 temps. It was a very scary experience. This is a known issue, but the dealer said it isn’t covered under special warranty.
NHTSA ODI #11618151
Mileage unknown · Oct 3, 2024
Electrical SystemEngineFuel/propulsion System
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they st…
Read full complaint
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
NHTSA ODI #11617833
60,000 miles · Sep 27, 2024
Electrical SystemEngine And Engine Cooling
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a rep…
Read full complaint
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
NHTSA ODI #11616955
Mileage unknown · Sep 25, 2024
Engine
The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives ha…
Read full complaint
The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives have provided no estimate of when or if that replacement part will be made available.
NHTSA ODI #11616531
Mileage unknown · Sep 19, 2024
EngineFuel/propulsion System
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if th…
Read full complaint
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
NHTSA ODI #11615410
Mileage unknown · Sep 16, 2024
Electrical SystemFuel/propulsion System
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable…
Read full complaint
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
NHTSA ODI #11614958
89,800 miles · Sep 16, 2024
Electrical SystemService BrakesSteeringCrash
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the …
Read full complaint
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
NHTSA ODI #11614848
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration