2016 Chevrolet Volt

While I driving in the past week, a warning that "propulsion power reduced" appeared on my dashboard several times. The last time that I had driven the car, the heater would not turn off, and the smell of burnt rubber filled the car and then dissipated soon after. The car would only run in it's gas engine mode, and not switch over to electric mode, as it usually would. The next morning, the car would not start. The dash board would light up as if the car started, but when I shifted into drive, a warning appeared on the dash, "Shift to park", as it would when the car is not running. I could not start the vehicle. After plugging the vehicle in, a warning appeared on the console stating that "Charging is not available". The car was towed to the dealership. Their diagnosis showed that the Battery Energy Control Module had failed and must be replaced. They later confirmed that an electric cable needed to be replaced that was "corroded", but they could not confirm the cause of the corrosion because the cable was disposed of already. After researching online, I found that GM issued a Special Coverage bulletin: N232432680, citing a common malfunction of the Battery Energy Control module in 2016 to 2018 Chevy Volts that "causes a reduced power mode, a no start condition, or a no charge condition." The Special Coverage was to extend the warranty to 15 years or 150,000 miles. After inquiring the dealer about the Special Coverage, they claimed that our car is not covered under the warranty. After calling customer service, they claimed the coverage comes from NHTSA, and GM only issues orders by VIN, and therefore cannot cover the issue. After calling NHTSA, I was told the special coverage is not a national recall, and is internal to GM. The GM dealership still claims that the control module on our car is not covered under the warranty, and have denied the request for a manager inspection or investigation.

Battery Energy Control Module Malfunction. It is a known issue with this system failing on the chevy volt. There is a service bulletin on this problem. 18-NA-261 is the service bulletin. The car will not start and when it does start it has loss of power while driving. Chevy is only fixing certain VIN numbers even thou it pulls up the same codes in their bulletin. Chevy only gave extended warranties to certain VIN numbers also. Extra warranty bulletin N232432680. This is a major component for the high voltage battery which drives the vehicle. The dealership wants $5000.00 to repair this.

The contact owns a 2016 Chevrolet Volt. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled. The accelerator pedal was released, and the vehicle returned to normal operation. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Action Number: PE23022 (Electrical System) and Special Coverage: N232432680 (Battery Energy Control Module Malfunction); however, the vehicle was not covered under the Special Coverage. The manufacturer was made aware of the failure. The failure mileage was approximately 71,000.

Component/System Failed: The engine of my 2016 Chevrolet Volt experienced a sudden internal crack, leading to complete engine failure. The engine is available for inspection upon request. Safety Risk: The engine failure rendered the vehicle completely inoperable, posing potential risk if it had occurred while driving. Sudden loss of engine power could have caused a crash or left me stranded in traffic, endangering myself and others. Problem Reproduction / Confirmation: The failure was confirmed by a GM dealership, which performed a full inspection and documented the engine crack. The dealership verified that the crack was sudden and not caused by negligence or improper maintenance. Inspections by Others: The vehicle has been inspected by the dealership, and all reports are available. I have also submitted the issue to GM corporate for warranty review. No police or insurance representatives have reviewed this, as this was a mechanical failure with no collision. Warning Lamps or Symptoms: No warning lights, messages, or unusual symptoms appeared prior to the failure. The engine appeared to operate normally until the sudden failure. Upon failure, low oil and low propulsion error message appeared on dash. Current no dash lights are on in the vehicle. Assessment of Cause: Based on dealership inspection and documentation, the failure appears sudden and possibly related to a defect in emissions-related engine components. No external damage or user error contributed to the failure.

Driving at 75 MPH on the freeway the power completely cuts off an a message appears on my dash "Propulsion Power is Reduced" - Pressing the gas barely gives any power, Imagine being in the middle of flowing traffic doing 75 mph to close to 20 mph. Research shows me this is a KNOWN issue with GM and the problem is with the BECM control module. There is also the issue of the EGR valve which apparently is tied into the BECM. I brought to the Chevy dealer and they said the BECM NEEDS to be replace ASAP because GM knows this is a dangerous situation and GM extended the warranty on this part to 150,000 miles. My vehicle is at 152,400 miles and they will not cover this. This is a serious issue that should be a recall that forces GM and Chevy to pay for this fix as it is something they have been aware of for years and it is a major accident waiting to happen. Please make them issue a recall for the BECM fix.

The contact owns a 2016 Chevrolet Volt. The contact stated that while operating vehicle the "Propulsion Error” was displayed, and the message "Shift to Park" was displayed while driving. Additionally, the vehicle occasionally failed to immediately start. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the Battery Energy Control Module (BECM) was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in the Manufacturer’s Extended Warranty Coverage related to the failure. The failure mileage was 98,500.

•Vehicle lost power while driving on the highway at speed. The vehicle would not run with gas engine power or EV charge basically died on the road in traffic. After coming to a stop safely but not without some close calls vehicle would not start even with car having fuel of two types in it. •The battery charge would not register, and the car would not start for a little while. Display showed nothing and was only making a dinging sound. Around half hour later the vehicle started, and I drove it to my home and parked it. I have not been driving it as it seems like a safety concern with the battery system and not feeling reliable. I had tried to charge it after the initial event and it did not charge. I did only a little research on cost for battery issues and the cost made me very put off even looking at the car. The car has been sitting sense August of last year. I took the car into a GM repair shop a week ago and the shop told me that the BECM module is weak. I looked this up and found that there is a lot of people having the same issue! Also, there are 19000 cars just like mine who got a recall or Special coverage. I am told I don’t meet the requirements for the coverage even though my car has the issues. They say my VIN is not on the list, clearly this special coverage did not go far enough. There appears to be some gaps in the coverage of this issue there are tons of people having this issue a full recall should be investigated and enacted there is clearly a problem that should be addressed. The fact that most cases do not happen when the car is running seem to put this on everyone’s back burner but people are being harmed financially while GM uses loop holes to not address an issue that could cost people there time, hard earned money, lost wages, even there life if this malfunction causes accidents. There was and is clearly enough to warrant action. Letting GM get away with a half Hearted attempted at fixing this is a crime.

While driving the car displayed “reduced propulsion power” on the dash and then I lost all drive power and could not switch the plug in hybrid from electric to gas engine mode. The vehicle had to be towed to the dealer who stated that the battery electronics control module and perhaps the battery needed to be replaced. The check engine light came on slightly before the incident.