IllustrationGM is not honoring coverage from N232432680 for CARB vehicles in non-CARB states. They have failed to tie CARB vehicle vins to the coverage in N232432680.
2016 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
2625–50K
1050–75K
775–100K
3100–150K
3150K+
60 reports with mileage · 109 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Unknown Or Other complaints
20 reports•Vehicle lost power while driving on the highway at speed. The vehicle would not run with gas engine power or EV charge basically died on the road in traffic. After coming to a stop safely but not without some close calls vehicle would not start even with car having fuel of two types in it. •The battery charge would not registe…
Read full complaint
•Vehicle lost power while driving on the highway at speed. The vehicle would not run with gas engine power or EV charge basically died on the road in traffic. After coming to a stop safely but not without some close calls vehicle would not start even with car having fuel of two types in it. •The battery charge would not register, and the car would not start for a little while. Display showed nothing and was only making a dinging sound. Around half hour later the vehicle started, and I drove it to my home and parked it. I have not been driving it as it seems like a safety concern with the battery system and not feeling reliable. I had tried to charge it after the initial event and it did not charge. I did only a little research on cost for battery issues and the cost made me very put off even looking at the car. The car has been sitting sense August of last year. I took the car into a GM repair shop a week ago and the shop told me that the BECM module is weak. I looked this up and found that there is a lot of people having the same issue! Also, there are 19000 cars just like mine who got a recall or Special coverage. I am told I don’t meet the requirements for the coverage even though my car has the issues. They say my VIN is not on the list, clearly this special coverage did not go far enough. There appears to be some gaps in the coverage of this issue there are tons of people having this issue a full recall should be investigated and enacted there is clearly a problem that should be addressed. The fact that most cases do not happen when the car is running seem to put this on everyone’s back burner but people are being harmed financially while GM uses loop holes to not address an issue that could cost people there time, hard earned money, lost wages, even there life if this malfunction causes accidents. There was and is clearly enough to warrant action. Letting GM get away with a half Hearted attempted at fixing this is a crime.
I was driving on the highway when suddenly the car lost power, it was very dangerous. I had to glide to the side of the road. The car will not move forward or back after I stopped, it had to be towed.
2016 Chevy volt started to not shut off with the message that car needed to shift to park. Car is just over 100,000 miles (104,000) spent a few weeks jiggling shifter to get car turned off then made an appointment at Platinum Chevy of Santa Rosa. While waiting we researched the issue to find that the Shift To Park is a known …
Read full complaint
2016 Chevy volt started to not shut off with the message that car needed to shift to park. Car is just over 100,000 miles (104,000) spent a few weeks jiggling shifter to get car turned off then made an appointment at Platinum Chevy of Santa Rosa. While waiting we researched the issue to find that the Shift To Park is a known issue and the Volt has in fact been named in a class action suit. Am currently at crossroad as I cannot get GM to stand behind their product. It’s taken four calls and an escalation to management to find out that they may offer a percentage to fix the problem but because we’re out of warranty it is a customer problem. So, to cap it off, GM has sold us a vehicle with a known safety issue with no recall and will not fix their problem.
On 2023/09/09, my Check Engine Light came on, and my car showed a "Reduced Propulsion" warning. As I continued to drive home, the car later began overheating, requiring me to reduce speed & stop frequently to let the car cool down. The local Chevrolet dealership diagnosed it as a failed EGR valve that caused the "non walk home"…
Read full complaint
On 2023/09/09, my Check Engine Light came on, and my car showed a "Reduced Propulsion" warning. As I continued to drive home, the car later began overheating, requiring me to reduce speed & stop frequently to let the car cool down. The local Chevrolet dealership diagnosed it as a failed EGR valve that caused the "non walk home" fuse to blow, which also disables the car's Engine Coolant Thermostat Heater (hence the overheating). Also three months later, this part is still on backorder with no estimated time of delivery.
Action Required Shift to Park message comes up on the dash after starting the vehicle & shifting into gear out of Park. The message goes away when shifted back into Park, but the vehicle doesn't respond when shifted into gear. Reverse, Neutral, Drive, Low - none will engage. I had to repeat the process of starting the vehicle 28…
Read full complaint
Action Required Shift to Park message comes up on the dash after starting the vehicle & shifting into gear out of Park. The message goes away when shifted back into Park, but the vehicle doesn't respond when shifted into gear. Reverse, Neutral, Drive, Low - none will engage. I had to repeat the process of starting the vehicle 28 times before it would operate as it should. Start Vehicle to View Application message comes up when in Park & trying to shut the vehicle off & will not power down until the driver door is opened. I worried that I'd be stranded if this continued to happen & took the vehicle to Brad Deery Motors in Maquoketa, IA for repair on 4/14/22. I paid $736.71 & the invoice states: 106128 shift to park, diag, intermittent open in the shift park solenoid, replaced shift park solenoid and jumper harness, tested working properly. I brought the vehicle home & had the same messages appear on 4/19/22. I have since read a forum on the Volt & understand that this has been a common issue & found a service bulletin: 19-NA-206, but wondering if there is an actual recall. I plan to contact GM regarding this issue.
Failure of car's keyless remote system. I got my fob and moved the car to where we charged it in the morning. In the afternoon after it was charged I had the same fob and got in to move it back by our front door and the screen gave the message "No remote detected". I assumed the fob battery was dead and changed it and it still w…
Read full complaint
Failure of car's keyless remote system. I got my fob and moved the car to where we charged it in the morning. In the afternoon after it was charged I had the same fob and got in to move it back by our front door and the screen gave the message "No remote detected". I assumed the fob battery was dead and changed it and it still would not recognize the fob. Then I got my wife's fob and it would not recognize that one either. So the keyless remote system in the car had failed in some way. I went online and saw there were plenty of cases of this happening to this model and other Chevy models that used a similar system. There is some issue with this system and it is very dangerous as someone could easily get stranded if they were alone in some remote place and not understanding how to even get in their car as there is no visible keyhole on the door to put the mechanical key. To follow up just as I was going out to the car to read the mileage all of a sudden the fob worked again. Both now work. It has been about 20 hours where it wouldn't work. I tried it many many times over those 20 hours and neither fob would work but now they both do. So this as many have reported , is an intermittent problem but dangerous because at any time you could be locked out of your car and you have to know how to pry off part of the door handle and insert the mechanical key and then place the fob in the special place under the lid in the console to be able to drive. Certainly once it happens to you and you learn all that you can do it in a reasonable time frame but when it happens the first time you are really stuck.
When I shift the car into "park" it will not register as "park" and a message comes up on the dash "shift to park." I'm unable to turn the car off at this point because it's required to be in "park" mode to accomplish this. Jiggling the shift handle will sometimes correct this but it appears to be getting worse over time. I s…
Read full complaint
When I shift the car into "park" it will not register as "park" and a message comes up on the dash "shift to park." I'm unable to turn the car off at this point because it's required to be in "park" mode to accomplish this. Jiggling the shift handle will sometimes correct this but it appears to be getting worse over time. I spoke to a service tech at GM and they said they are aware of the issue and that it is a problem with this model. I was told the only fix was a costly replacement that may or may not solve the problem. A web search indicates there are many Chevy Volt drivers experiencing this same issue.
EXCESSIVE CONDENSATION FROM WATER LEAK BELOW THE FRONT PASSENGER FLOOR. IT WAS WITHIN THE BUMPER TO BUMPER WARRANTY, BUT 3 SEPARATE CHEVY DEALERS DID NOT DIAGNOSE OR FIX PROBLEM UNTIL AFTER WARRANTY EXPIRED. ONE DEALER EVENTUALLY FOUND A BAD WELD RESULTING IN A WATER LEAK AND SEALED IT. UNFORTUNATELY, THE LEAK HAS RETURNED AND T…
Read full complaint
EXCESSIVE CONDENSATION FROM WATER LEAK BELOW THE FRONT PASSENGER FLOOR. IT WAS WITHIN THE BUMPER TO BUMPER WARRANTY, BUT 3 SEPARATE CHEVY DEALERS DID NOT DIAGNOSE OR FIX PROBLEM UNTIL AFTER WARRANTY EXPIRED. ONE DEALER EVENTUALLY FOUND A BAD WELD RESULTING IN A WATER LEAK AND SEALED IT. UNFORTUNATELY, THE LEAK HAS RETURNED AND THERE IS A LOT OF WATER BELOW THE FLOOR AGAIN. THIS REQUIRES REMOVING THE SEATS, TRIM, CARPET, AND FINDING ANOTHER BAD WELD.
WHEN ATTEMPTING TO TURN OFF THE CAR IT SAYS "ACTION REQUIRED: SHIFT TO PARK" AND WILL PROCEED AS BEING LEFT ON, DESPITE BEING IN PARK. THIS OCCURS ABOUT 70% OF THE TIME THE CAR IS DRIVEN AND TAKES SEVERAL TRIES OF TURNING ON THE CAR, MOVING, PARKING, AND TURNING BACK OFF BEFORE THE ENGINE SHUTS OFF WITHOUT THIS WARNING.
Official recalls
117V621000 · Air Bags:frontal
Oct 5, 2017
General Motors LLC (GM) is recalling certain 2015-2016 GMC Canyon and Chevrolet Colorado, and 2016 Chevrolet Volt vehicles. The driver's frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash.
Consequence & remedy
Consequence: An improperly inflated air bag increases the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began November 8, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17387.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.