NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
63 reportsClear category filterMileage unknown · Mar 8, 2024
Electrical SystemFuel/propulsion System
Chevy has put out a "special coverage" (number XXX) on 2016 to 2018 volts on the BECM issue that is currently being investigated. I need to make the note that upon trying to fulfill this warranty/ special coverage on my 2016 volt, they are finding loopholes to not cover a huge handful of 2016 to 2018 volts that have the exact sa…
Read full complaint
Chevy has put out a "special coverage" (number XXX) on 2016 to 2018 volts on the BECM issue that is currently being investigated. I need to make the note that upon trying to fulfill this warranty/ special coverage on my 2016 volt, they are finding loopholes to not cover a huge handful of 2016 to 2018 volts that have the exact same BECM issue and components as the volts that are covered. Although I'm not positive, it seems to me that they are not granting special coverage to all volts that have a PZEV warranty in place as it's redundant. However, 75% of us with PZEV warranties are in non CARB states and cannot utilize the warranty. So they are leaving us within this category who have the exact same BECM issues as every other 2016 to 2018 volt out of being eligible for the new coverage, while making it look like they are fixing the entire issue. They are secretly leaving a handful of us dry and without this coverage. Not only that, they are refusing/ unable to give me accurate information as to what vehicles qualify for this warranty if not all 2016 volts which is against the Magnuson-Moss warranty act and illegal on their part. They forced me to pay $2500 for this repair after telling me I would be covered by warranty and obviously would have held my car had I not paid. After telling me it was free. Somebody needs to probe deeper into this and make sure that Chevy is honoring what they claim because it appears to me they are secretly trying to [XXX] a percentage of 16 to 18 volt owners who have the exact same issues and components as the cars that are covered. This is a safety issue as my car died and temporarily stranded me several times before this repair as you guys already know is an issue with the 16 volts that Chevy has refused to acknowledge until recently. Chevy case number reference: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11576310
Mileage unknown · Feb 26, 2024
Electrical SystemEngineFuel/propulsion System
I got the “propulsion power is reduced” warning at ~83.5k miles on the odometer, while visiting friends 4 hours from home. Pulled over and called 3 local dealerships and all servicing departments are closed on Sunday so knew there was nothing I could do except try to limp back to my friends house safely and reevaluate. On the 20…
Read full complaint
I got the “propulsion power is reduced” warning at ~83.5k miles on the odometer, while visiting friends 4 hours from home. Pulled over and called 3 local dealerships and all servicing departments are closed on Sunday so knew there was nothing I could do except try to limp back to my friends house safely and reevaluate. On the 20 minute drive back, the engine cut out on the freeway and the car immediately started slowing down. I coasted to the next freeway exit safely with my hazards on. The scary part was that I had no power after the ”engine unavailable” warning popped up since the battery was completely drained already. I was able to get it towed to the closest chevy dealership and leave the keys for them. I am waiting to hear the official diagnosis from the dealership once they take a look. The cause is still unknown but this sounds like a similar series of events for BECM failure.
NHTSA ODI #11574102
Mileage unknown · Jan 5, 2024
EngineFuel/propulsion SystemVehicle Speed Control
My car will lose all power as I'm driving, switch between gas/ elec and almost stall, it will accelerate when I take my foot OFF the gas , it will lose power on a turn.. it's random. form what I understand it's the BECM and it happened just after 100k miles. I have 105k.
NHTSA ODI #11563877
Mileage unknown · Jan 3, 2024
Electrical SystemFuel/propulsion SystemPower Train
I picked up my vehicle from Wasler Polar Chevrolet on 7/26/2023 after they claimed to have "repaired" my vehicle. After receiving my vehicle, about 5 miles away from the dealership, my vehicle suddenly quit keeping up with traffic, and lost *all* power equipment. Brakes, steering and acceleration were all unresponsive. The vehic…
Read full complaint
I picked up my vehicle from Wasler Polar Chevrolet on 7/26/2023 after they claimed to have "repaired" my vehicle. After receiving my vehicle, about 5 miles away from the dealership, my vehicle suddenly quit keeping up with traffic, and lost *all* power equipment. Brakes, steering and acceleration were all unresponsive. The vehicle almost sent me under a semi-trailer, but I quickly forced the steering wheel to the left and engaged the emergency brake, which successfully stopped the car. The vehicle bricked itself, and had to be towed back to the dealership.
NHTSA ODI #11563205
Mileage unknown · Dec 16, 2023
Electrical SystemFuel/propulsion SystemPower Train
While driving suddenly the battery power died (1/3 battery life left) and the ICE came on reving very high and check engine lights came on and vehicle slowed. Pulled over at first spot I could find and tired to restart the car. Car would not power down or restart the ice motor and the electric drive motors stopped working and ve…
Read full complaint
While driving suddenly the battery power died (1/3 battery life left) and the ICE came on reving very high and check engine lights came on and vehicle slowed. Pulled over at first spot I could find and tired to restart the car. Car would not power down or restart the ice motor and the electric drive motors stopped working and vehicle would roll backwards once put into drive. Vehicle had to be towed back to dealership. Car would not power down or reset.
NHTSA ODI #11560451
Mileage unknown · Dec 15, 2023
Electrical SystemEngineFuel/propulsion System
Check engine light came on reduced propulsion warning. Took to Chevrolet dealer and they diagnosed EGR value failure while on road trip. Got home Took it to my local dealership and same diagnosed no part available and emissions warranty is good and it is covered but 2 year nationwide backorder by GM. The car only shows 47000 mil…
Read full complaint
Check engine light came on reduced propulsion warning. Took to Chevrolet dealer and they diagnosed EGR value failure while on road trip. Got home Took it to my local dealership and same diagnosed no part available and emissions warranty is good and it is covered but 2 year nationwide backorder by GM. The car only shows 47000 miles without parts I will not be able to use the vehicle after it fails the emissions test for Maryland.
NHTSA ODI #11560251
Mileage unknown · Dec 13, 2023
Fuel/propulsion System
Twice now my vehicle has been affected by an alert that the propulsion system has an issue. Each time the car lost power and I had to immediately get off of the highway or park the vehicle at my home. Currently my car is at a dealership waiting for replacement parts with no ETA. It has been there for 3 months already.
NHTSA ODI #11559836
Mileage unknown · Dec 2, 2023
EngineFuel/propulsion SystemPower Train
Driving 72mph down I5 interstate the display notified me with a check engine light with two errors, enigne propulsion reduced and engine overheating. I pulled over to the side of the road and called a tow. This was a very traumatic event. I had my partner and my 2 year old daughter in the car.I just purchased this used vehicle f…
Read full complaint
Driving 72mph down I5 interstate the display notified me with a check engine light with two errors, enigne propulsion reduced and engine overheating. I pulled over to the side of the road and called a tow. This was a very traumatic event. I had my partner and my 2 year old daughter in the car.I just purchased this used vehicle from a Toyota dealer the same day. It has 63k miles on it and still under powertrain warranty. I literally drove the car 45 miles. TOTAL. I have spent more time towing and fixing this car than actually driving it. This is a total lemon. I need a refund from GM and all the pain and suffering that this caused my family.
NHTSA ODI #11558066
Mileage unknown · Dec 2, 2023
EngineFuel/propulsion System
I had BECM failure and the car suddenly stopped in the middle of the road. They need to make this a safety recall.
NHTSA ODI #11558032
Mileage unknown · Sep 29, 2023
Electrical SystemFuel/propulsion System
Shift to park issue where suddenly I can't start car . Doesn't register park. Have to fiddle with shifter. Then find on reduced propulsion.
NHTSA ODI #11547284
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration