Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2925–50K
6050–75K
4775–100K
33100–150K
6150K+
213 reports with mileage · 95 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
What owners actually said
308 reports
40,000 miles · Jan 24, 2018
Air Bags
"SERVICE AIRBAG" LIGHTS INTERMITTENTLY. ORIGINAL CAUSE APPEARED TO BE MOVEMENT OF FRONT PASSENGER SEAT; RECENT CAUSES WERE SUDDEN BRAKING AND RANDOM NORMAL SPEED CORNERING. DEALER ATTEMPTED TO REPRODUCE PROBLEM, BUT UNABLE. DEALER HAND TIGHTENED WIRES UNDER SEAT. PROBLEM CORRECTED FOR A FEW WEEKS, THEN RETURNED. SUGGESTED N…
Read full complaint
"SERVICE AIRBAG" LIGHTS INTERMITTENTLY. ORIGINAL CAUSE APPEARED TO BE MOVEMENT OF FRONT PASSENGER SEAT; RECENT CAUSES WERE SUDDEN BRAKING AND RANDOM NORMAL SPEED CORNERING. DEALER ATTEMPTED TO REPRODUCE PROBLEM, BUT UNABLE. DEALER HAND TIGHTENED WIRES UNDER SEAT. PROBLEM CORRECTED FOR A FEW WEEKS, THEN RETURNED. SUGGESTED NEXT STEP BY DEALER: REPLACE PPS MODULE. UNFORTUNATELY, THIS IS $800+ REPAIR WITH NO GUARANTEED OUTCOME. THIS PROBLEM HAS BEEN REPORTED BY OTHER VOLT OWNERS IN INTERNET POSTS. WOULD LIKE TO KNOW IF GM HAS ANY FIXES NOT KNOWN TO DEALER.
NHTSA ODI #11064619
60,000 miles · Jan 19, 2018
Air BagsSeats
SERVICE AIR BAG WARNING DURING OR SHORTLY AFTER SOMEONE SITS IN FRONT PASSENGER SEAT. ALSO SEE THE PASSENGER AIR BAG LIGHT ILLUMINATES "OFF" FOR EXTENDED PERIOD. DEALER STATES IT IS NOT ABLE TO DUPLICATE THE ISSUE. HAS BEEN HAPPENING FOR THE PAST YEAR. BELIEVE THIS IS A KNOWN DEFECT, AND ALSO A SAFETY HAZARD, AS AIR BAG MAY NO…
Read full complaint
SERVICE AIR BAG WARNING DURING OR SHORTLY AFTER SOMEONE SITS IN FRONT PASSENGER SEAT. ALSO SEE THE PASSENGER AIR BAG LIGHT ILLUMINATES "OFF" FOR EXTENDED PERIOD. DEALER STATES IT IS NOT ABLE TO DUPLICATE THE ISSUE. HAS BEEN HAPPENING FOR THE PAST YEAR. BELIEVE THIS IS A KNOWN DEFECT, AND ALSO A SAFETY HAZARD, AS AIR BAG MAY NOT DEPLOY IN A COLLISION.
NHTSA ODI #11063754
70,000 miles · Jan 16, 2018
Service BrakesSteeringCrash
THIS IS THE THIRD INCIDENT SINCE I HAD THIS CAR ALONG WITH CHARGING ISSUE IN THE BEGINNING OF OWNERSHIP THIS CHEVROLET VOLT HAS BEEN BEEN DEEM TOTAL FROM THE ACCIDENT THAT OCCURRED ON JANUARY 6 BECAUSE OF THE STEERING LOCKING UP
NHTSA ODI #11062921
40,000 miles · Jan 9, 2018
Air Bags
WHENEVER SOMEONE SITS IN THE PASSENGER SEAT, THE SERVICE AIRBAG INDICATOR COMES ON. DEALER REVIEWED CODES AND DETERMINED THE AIRBAG SENSOR IS FAULTY. THE SERVICE TECH STATED THE PASSENGER AIRBAG WILL NOT INFLATE UNTIL THIS IS REPAIRED AT A COST OF $850.00. THERE ARE ONLY 56,000 MILES ON THE CAR, BUT THE PROBLEM STARTED AROUND 40…
Read full complaint
WHENEVER SOMEONE SITS IN THE PASSENGER SEAT, THE SERVICE AIRBAG INDICATOR COMES ON. DEALER REVIEWED CODES AND DETERMINED THE AIRBAG SENSOR IS FAULTY. THE SERVICE TECH STATED THE PASSENGER AIRBAG WILL NOT INFLATE UNTIL THIS IS REPAIRED AT A COST OF $850.00. THERE ARE ONLY 56,000 MILES ON THE CAR, BUT THE PROBLEM STARTED AROUND 40,000 MILES.
NHTSA ODI #11061403
85,000 miles · Sep 13, 2017
Air Bags
PAID DEALER $160 TO FIND OUT PASSENGER PRESENCE MODULE HAD FAILED. THEY'RE ASKING FOR ANOTHER $820 (MOSTLY LABOR) TO FIX THE ISSUE BY REPLACING WITH PART #22968438 IN THE PASSENGER SEAT...SO I'M DRIVING AROUND WITH A BAD AIRBAG I GUESS. CAN'T SEE SPENDING 1000.00 RIGHT NOW TO FIX A BLINKING WARNING LIGHT. I SEE ON THE WEB THA…
Read full complaint
PAID DEALER $160 TO FIND OUT PASSENGER PRESENCE MODULE HAD FAILED. THEY'RE ASKING FOR ANOTHER $820 (MOSTLY LABOR) TO FIX THE ISSUE BY REPLACING WITH PART #22968438 IN THE PASSENGER SEAT...SO I'M DRIVING AROUND WITH A BAD AIRBAG I GUESS. CAN'T SEE SPENDING 1000.00 RIGHT NOW TO FIX A BLINKING WARNING LIGHT. I SEE ON THE WEB THAT OTHERS ARE ALSO HAVING THIS PROBLEM, AND WONDER HOW MANY VOLT OWNERS ARE DRIVING WITH BAD AIRBAGS WAITING FOR A RECALL TO BE ANNOUNCED. SEEMS LIKE A PART THAT JUST SHOULDN'T HAVE MUCH WEAR-AND-TEAR, AND SHOULD MAYBE NEVER BECOME AN EXPENSIVE REPAIR ISSUE. ENGINE, TRANNY, TIRES, ETC. - SURE. BUT NOT THE DANG AIRBAG SYSTEM. MY CELL IF YOU WANT MORE DETAILS [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC
NHTSA ODI #11022955
67,000 miles · Jun 21, 2017
Engine
RADIATOR FAILURE/LEAKING AT 67000 MILES. UNKNOWN CAUSE. CAUSED CAR TO OVERHEAT AND HAD TO BE SHUT DOWN TO AVOID FURTHER DAMAGE TO ELECTRICAL/BATTERY COMPONENTS. COST TO REPAIR EXCEEDS $1500.
NHTSA ODI #11000386
35,063 miles · Apr 27, 2017
Fuel/propulsion System
DRIVING IN TRAFFIC, MULTIPLE LANES.." REDUCED POWER" MESSAGE APPEARS ON DASH..CAR SHUTS DOWN IMMEDIATELY...NO STEERING ASSIST...BRAKES OKAY...STUCK IN MIDDLE LANES WITH NO PROPULSION...LUCKILY A FIRETRUCK HAPPENED BY AND WAS PUSHED OFF THE ROAD...CAR TOWED TO DEALER. INFORMED MULTIPLE VOLTS TOWED IN FOR SAME ISSUE. ALSO INFORM…
Read full complaint
DRIVING IN TRAFFIC, MULTIPLE LANES.." REDUCED POWER" MESSAGE APPEARS ON DASH..CAR SHUTS DOWN IMMEDIATELY...NO STEERING ASSIST...BRAKES OKAY...STUCK IN MIDDLE LANES WITH NO PROPULSION...LUCKILY A FIRETRUCK HAPPENED BY AND WAS PUSHED OFF THE ROAD...CAR TOWED TO DEALER. INFORMED MULTIPLE VOLTS TOWED IN FOR SAME ISSUE. ALSO INFORMED EXTREME BACKORDER FOR REPAIR BATTERY ACROSS U. S. TOLD APPROX 2 MONTH WAIT FOR BATTERY SECTION...ONCE THIS BATTERY FAILS WHILE YOU ARE DRIVING, YOU ARE DEAD IN THE WATER...NO POWER STEERING AND UNABLE TO MOVE IN OR OUT OF TRAFFIC...IF THIS DEALER HAS 3 CARS, HOW MANY UNSAFE CARS ARE THERE ACROSS THE COUNTRY?
NHTSA ODI #10981172
122,222 miles · Apr 24, 2017
Electrical System
TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. AFTER FUELING THE VEHICLE, THE INSTRUMENT PANEL BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,222.
NHTSA ODI #10980301
34,000 miles · Apr 6, 2017
Fuel/propulsion System
LOST POWER WHILE DRIVING DOWN THE ROAD!
NHTSA ODI #10970845
65,000 miles · Mar 25, 2017
Structure
TAILGATE STRIKER LATCH P/N 13581431 (ON BODY, NOT TAILGATE) LOOSE FOUND THE 2 SCREWS P/N 11518445 WERE LOOSE AND REAR TAILGATE WAS RATTLING.
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Consequence & remedy
Consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE19013 · Passenger Sensing System
Opened Sep 17, 2019 · Closed Jul 2, 2021
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification:front Passenger
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
2013 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration