NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
63 reportsClear category filter78,000 miles · Nov 3, 2021
Electrical System
The contact owns a 2013 Chevrolet Volt. The contact stated while driving at 65 MPH, a warning message appear a propulsion power reduction and the vehicle began to lose power and reduce in speed while the contact was driving. The contact was able to pulled the vehicle over to the side of the road waited a few minutes and restart…
Read full complaint
The contact owns a 2013 Chevrolet Volt. The contact stated while driving at 65 MPH, a warning message appear a propulsion power reduction and the vehicle began to lose power and reduce in speed while the contact was driving. The contact was able to pulled the vehicle over to the side of the road waited a few minutes and restart the vehicle and continue to drive to their residence. The contact took the vehicle to a local dealer who diagnosed the failure as the propulsion battery would need to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was appromaxtley 78,000.
NHTSA ODI #11439205
78,000 miles · Nov 3, 2021
Electrical System
The contact owns a 2013 Chevrolet Volt. The contact stated while driving 65 MPH, the propulsion power reduction message was displayed, and the vehicle began to lose power and the speed was reduced while driving. The contact was able to pull the vehicle over to the side of the road, waited a few minutes, and then restarted the ve…
Read full complaint
The contact owns a 2013 Chevrolet Volt. The contact stated while driving 65 MPH, the propulsion power reduction message was displayed, and the vehicle began to lose power and the speed was reduced while driving. The contact was able to pull the vehicle over to the side of the road, waited a few minutes, and then restarted the vehicle and continued to his residence. The contact took the vehicle to a local dealer to be diagnosed. The contact was informed that the propulsion battery needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.
NHTSA ODI #11439204
105,000 miles · Aug 24, 2021
Electrical System
The contact owns a 2013 Chevrolet Volt. The contact stated that the vehicle would not charge. The contact stated that the "service high voltage charging system" warning message was displayed. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 105,000…
Read full complaint
The contact owns a 2013 Chevrolet Volt. The contact stated that the vehicle would not charge. The contact stated that the "service high voltage charging system" warning message was displayed. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 105,000.
NHTSA ODI #11430338
Mileage unknown · May 23, 2021
Electrical SystemUnknown Or OtherVehicle Speed Control
has had the blank screen display the vehicle is unsafe to drive. One can run out of electrical power and or gas and not know, stop on the highway and be in harms way. no turn signals, no speed indication at all, nothing. this is recall worthy! and needs to be addressed by chevy.
NHTSA ODI #11418222
70,000 miles · May 5, 2021
Electrical SystemEngineFuel/propulsion System
VEHICLE HAS STOPED IN THE MIDDLE OF THE STREET ON SEVERAL OCCASIONS. DURING THIS TIME THE VEHICLE WILL POST AN ERROR ON THE DASH SCREEN. THIS ISSUE HAPPENS WHEN THE VEHICLE TRANSITIONS FROM ELECTRIC FUEL TO GASOLINE, WHEN THE ELECTRIC FUEL IS DEPLETED. CHEVY REFUSES TO REPAIR OR WARRANTY THE VEHICLE, ALSO THE DEALER REFUSES T…
Read full complaint
VEHICLE HAS STOPED IN THE MIDDLE OF THE STREET ON SEVERAL OCCASIONS. DURING THIS TIME THE VEHICLE WILL POST AN ERROR ON THE DASH SCREEN. THIS ISSUE HAPPENS WHEN THE VEHICLE TRANSITIONS FROM ELECTRIC FUEL TO GASOLINE, WHEN THE ELECTRIC FUEL IS DEPLETED. CHEVY REFUSES TO REPAIR OR WARRANTY THE VEHICLE, ALSO THE DEALER REFUSES TO COMPLETE THE NECESSARY RECALLS ON THE VEHICLE. THE VEHICLE DOES NOT RETURN TO NORMAL UNTIL YOU TURN THE VEHICLE ON AND OFF MULTIPLE TIMES.
NHTSA ODI #11415209
43,000 miles · Mar 9, 2021
Electrical SystemPower TrainUnknown Or Other
THE VOLT IS DISPLAYING MANUFACTURER CONTROL ERROR CODE P1 E00$07E8 AND IS NOT CHARGING. ON THE DASH, THE MESSAGE DISPLAYS AS "SERVICE HIGH VOLTAGE CHARGING SYSTEM". THIS IS A SOFTWARE ERROR THAT CHEVROLET NEEDS TO CORRECT ON THE 2013 CHEVROLET VOLTS AT NO COST TO OWNERS.
NHTSA ODI #11400016
1,000 miles · Feb 15, 2021
Electrical SystemEngineFuel/propulsion System
PLEASE SEE ATTACHED DOCUMENT FOR FULL DESCRIPTION OF THE UN-COMMANDED SELF ACCELERATION ISSUES IN MY 2013 CHEVY VOLT INCLUDING MY CONTACT INFORMATION. THANK YOU!
NHTSA ODI #11396357
104,000 miles · Jan 8, 2021
Electrical System
TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE INFOTAINMENT SCREEN STOPPED FUNCTIONING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIR. THE MANUFACTURER HAD NOT BEEN INFORMED O…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE INFOTAINMENT SCREEN STOPPED FUNCTIONING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIR. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.
NHTSA ODI #11387194
60,000 miles · Dec 11, 2020
Air BagsElectrical SystemSeats
THE PASSENGER AIRBAG SEATBELT SENSOR FAULTY AND GIVES NOTICE ON DISPLAY. INTERMITTENTLY STOPS TURNING ON PASSENGER AIRBAG WHEN SOMEONE IS SITTING IN IT. I HAS BEEN DOING THIS FOR ABOUT 3 YEARS AND DOES IT EVERYTIME WHILE DRIVING. I HAVE SEEN HUNDREDS OF POSTS ONLINE WITH THE SAME ISSUE. THIS IS THE SECOND TIME I HAVE FILED …
Read full complaint
THE PASSENGER AIRBAG SEATBELT SENSOR FAULTY AND GIVES NOTICE ON DISPLAY. INTERMITTENTLY STOPS TURNING ON PASSENGER AIRBAG WHEN SOMEONE IS SITTING IN IT. I HAS BEEN DOING THIS FOR ABOUT 3 YEARS AND DOES IT EVERYTIME WHILE DRIVING. I HAVE SEEN HUNDREDS OF POSTS ONLINE WITH THE SAME ISSUE. THIS IS THE SECOND TIME I HAVE FILED THIS SAME COMPLAINT WITH NO RESPONSE.
NHTSA ODI #11383019
80,000 miles · Nov 27, 2020
Electrical SystemStructureUnknown Or Other
THERE IS A DESIGN FLAW IN THE BODY OF THE VEHICLE THAT CAUSES WATER TO LEAK IN AND POOL IN THE FRONT PASSENGER FLOORBOARD. THERE ARE LOTS OF ELECTRICAL COMPONENTS NEAR WHERE THIS WATER POOLS THAT COULD CAUSE A SAFETY ISSUE.
NHTSA ODI #11376637
Official recalls
3Jul 27, 2023
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
Jun 14, 2018
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Consequence & remedy
Consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
Mar 13, 2015
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE19013 · Passenger Sensing System
Opened Sep 17, 2019 · Closed Jul 2, 2021
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification:front Passenger
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Illustration