IllustrationPassenger airbag sensor intermittent error. Says service airbag. Goes off after someone has been sitting in vehicle and exits vehicle. Not reliably reproducible but seems to be happening with greater frequency.
2013 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2925–50K
6050–75K
4775–100K
33100–150K
6150K+
213 reports with mileage · 95 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
Air Bags complaints
161 reportsPassenger Airbags failed to engage when occupied during accident, drivers side activated. Results in injured passenger
According to NHTSA's own filing - Action PE19013 - GM's response to the action was to "establish a cost reduction program". I have now had this exact problem diagnosed, and repaired at a cost of $1,133. Neither GM, nor the Chevrolet dealership where I had the repair done had any information or provided and discounts or cost redu…
Read full complaint
According to NHTSA's own filing - Action PE19013 - GM's response to the action was to "establish a cost reduction program". I have now had this exact problem diagnosed, and repaired at a cost of $1,133. Neither GM, nor the Chevrolet dealership where I had the repair done had any information or provided and discounts or cost reduction. Either NHTSA has lied in its report, or GM has lied to NHTSA in order to close this incident. I should have the cost of this repair "reduced".
Passenger airbag sensor mat is malfunctioning Leaking water from passenger side AC, drain line or structure
The passenger presence sensor module has developed a fault. The service airbag soon warning pops up when a front seat passenger gets out of the seat. I can manually recreate the problem by pressing down on the seat bottom cushion and then when I release pressure the warning reappears and then goes away after 10 seconds. I will n…
Read full complaint
The passenger presence sensor module has developed a fault. The service airbag soon warning pops up when a front seat passenger gets out of the seat. I can manually recreate the problem by pressing down on the seat bottom cushion and then when I release pressure the warning reappears and then goes away after 10 seconds. I will now need to replace the module and get the vehicle reprogrammed, or find a junkyard seat and hope it doesn't have the same problem. You really should have required GM to do more on this issue when you investigated it! From what I understand, there is not a 'cost reduction program' for having the dealer replace this defective part. This seems to be a very common problem that has perhaps gone underreported, but is obviously going to happen given the design of the sensor pad where it develops a fatigue failure.
I have the failure from PE19013. I read in the closing that "GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program...; ODI is closing this Preliminary Evaluation." I contacted two dealerships who are unaware of this program. I then conta…
Read full complaint
I have the failure from PE19013. I read in the closing that "GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program...; ODI is closing this Preliminary Evaluation." I contacted two dealerships who are unaware of this program. I then contacted the Chevy Support Center, who said to contact the dealership when I asked for an alternative contact. I then asked to speak to a supervisor with a promised call back, that did not occur. Attached is the transcript of the chat with Chevy Support Center. The two issues: 1. The safety issue still exists and disables the air bags when occupied by a person of proper size for the airbags. 2. The reduced cost program is something that both dealerships and the Chevy Support System is unaware of itself. The investigation was closed on the premise of a support system that is impossible to find information on.
Passenger Sensor fails to turn on when an occupant of normal size is in the passenger seat, precluding air bag deployment. This is a very common issue with 2013 models.
PASSENGER AIRBAG ERROR INDICATOR. I took my 2013 Volt to the dealer who indicated it was a sensor error in the seat and requires a 1000.$ seat and sensor replacement. My Volt has 80K miles and no collisions or accidents. There is no justifiable reason for me to replace the front seat for 1000.00 due to a poorly designed wire ha…
Read full complaint
PASSENGER AIRBAG ERROR INDICATOR. I took my 2013 Volt to the dealer who indicated it was a sensor error in the seat and requires a 1000.$ seat and sensor replacement. My Volt has 80K miles and no collisions or accidents. There is no justifiable reason for me to replace the front seat for 1000.00 due to a poorly designed wire harness or sensor. I won't risk having a front seat passenger due to this malfunction. Furthermore I can't sell the vehicle. Why has the NHTSA closed this complaint?
passenger occupancy sensor malfunction. Passenger airbag turns off intermitently even while occupied by an adult. I have not been to dealership, but understand it is a $1000 repair. This is also happening in a 2012 volt that I own.
When an adult passenger >100lb is sitting in the front passenger seat, the service airbag light comes on and the dashboard says "Service Airbag". This lasts for 30-60 seconds at random times at all speeds from 0 to 60+ mph. The dealer reported that this will cost roughly $1000 for labor in addition to the heavily backordered par…
Read full complaint
When an adult passenger >100lb is sitting in the front passenger seat, the service airbag light comes on and the dashboard says "Service Airbag". This lasts for 30-60 seconds at random times at all speeds from 0 to 60+ mph. The dealer reported that this will cost roughly $1000 for labor in addition to the heavily backordered part costing $400 and not being available for weeks.
Official recalls
323V516000 · Air Bags:frontal:driver Side:inflator Module
Jul 27, 2023
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
18V397000 · Hybrid Propulsion System
Jun 14, 2018
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Consequence & remedy
Consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
15V145000 · Electrical System:ignition; Engine And Engine Cooling:engine:gasoline
Mar 13, 2015
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE19013 · Passenger Sensing System
Opened Sep 17, 2019 · Closed Jul 2, 2021
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification:front Passenger
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.