IllustrationFOR UNKNOWN REASON CHECK AIRBAG LIGHT CAME ON. NO ONE SITS IN PASSENGER SEAT AND THE SEAT HAS NOT BEEN WET.
2011 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
725–50K
550–75K
1075–100K
8100–150K
1150K+
38 reports with mileage · 11 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
Air Bags complaints
8 reportsSINCE THE SPRING OF 2020, "SERVICE AIR BAG" WARNING COMES ON INTERMITTENTLY, RELATED TO PASSENGER SEAT AIRBAG. WARNING GENERALLY COMES ON AT STARTUP, IF IT APPEARS. NO FLUIDS HAVE BEEN SPILLED ON THE SEAT, AND NO VISIBLE DAMAGE TO THE SEAT. I AM THE SECOND OWNER, PURCHASED FROM FRIEND, CAR HAS ALWAYS BEEN GARAGED AND SERVICED R…
Read full complaint
SINCE THE SPRING OF 2020, "SERVICE AIR BAG" WARNING COMES ON INTERMITTENTLY, RELATED TO PASSENGER SEAT AIRBAG. WARNING GENERALLY COMES ON AT STARTUP, IF IT APPEARS. NO FLUIDS HAVE BEEN SPILLED ON THE SEAT, AND NO VISIBLE DAMAGE TO THE SEAT. I AM THE SECOND OWNER, PURCHASED FROM FRIEND, CAR HAS ALWAYS BEEN GARAGED AND SERVICED REGULARLY. ONLINE SEARCH SUGGESTS THAT OTHER OWNERS HAVE SAME ISSUE, AND THAT DIAGNOSIS AND REPAIR CAN BE $500 TO $1000. I HAVE NOT HAD A CHEVROLET DEALER DIAGNOSE THIS ISSUE SINCE IT IS INTERMITTENT. CURRENT MARKET VALUE OF VEHICLE (55K MILES, OTHERWISE EXCELLENT CONDITION, A GREAT CAR TO DRIVE) MAKES COST OF REPAIR DIFFICULT TO JUSTIFY, ESPECIALLY IF IT COULD HAPPEN AGAIN WITHOUT WARNING.
THE AIRBAG LIGHT HAS TURNED AND AIRBAG SENSOR IS BAD. PASSENGER AIRBAG WILL NOT ILLUMINATE AND WORK FOR SOMEONE SITTING IN THE PASSENGER SEAT. THE CAR HAS NOT BEEN IN AN ACCIDENT.
'SERVICE AIRBAG' CHIME AND LIGHT COMING ON, ROUTINELY, EVEN WITH OR WITH ANYBODY IN THE PASSENGER SEAT. I HAVE NOT TAKEN THE CAR TO A DEALER YET SINCE I HAVE BEEN READING FORUM INPUT ABOUT THIS ISSUE AND SEEING HUGE COST TO REPAIR. CAR HAS ONLY 81K MILES AND HAS NEVER BEEN FLOODED OR HAD WATER ON THE SEAT(PASSENGER).
AIR BAG WARNING LIGHT IS ILLUMINATED DUE TO A FAILED SENSOR IN THE PASSENGER SEAT. HAD TO REPLACE WITH A USED SEAT.
AIR BAG WARNING LIGHT IS ILLUMINATED DUE TO A FAILED SENSOR IN THE PASSENGER SEAT. HAD TO REPLACE WITH A USED SEAT.
SERVICE AIRBAG LIGHT COMES ON AT STARTUP. ITS THE PASSENGER SIDE AIR BAG SENSOR IN SEAT, SOUNDS LIKE ITS THE PRESSURE PLATE TO ACTIVATE AIR BAG IS BAD. SOUNDS LIKE A COMMON THING WITH THE VOLT?
THE CAR HAS PROCEEDED TO HAVE MULTIPLE ISSUES, WITH THE MOST PREDOMINANT AND LIFE THREATENING ISSUE BEING AN AIRBAG FAILURE...TWICE. OTHER ISSUES: RADIO, DOOR LOCKS, AND PARK ASSIST ENGAGE/DISENGAGE ON THEIR OWN. BRAKES NOT CATCHING CAUSING CAR TO ROLL. POWER FAILURE AND WON'T START. APRIL 2013, THE VEHICLE WAS T-BONED AT A R…
Read full complaint
THE CAR HAS PROCEEDED TO HAVE MULTIPLE ISSUES, WITH THE MOST PREDOMINANT AND LIFE THREATENING ISSUE BEING AN AIRBAG FAILURE...TWICE. OTHER ISSUES: RADIO, DOOR LOCKS, AND PARK ASSIST ENGAGE/DISENGAGE ON THEIR OWN. BRAKES NOT CATCHING CAUSING CAR TO ROLL. POWER FAILURE AND WON'T START. APRIL 2013, THE VEHICLE WAS T-BONED AT A RATE OF SPEED OVER 45MPH. THE AIRBAGS FAILED TO DEPLOY; CAUSED PERSONAL INJURY. GM SENT OUT AN INSPECTOR, AND PULLED THE DATA. RESPONSE BACK WAS ?NO EVENT RECORDED? AND WAS DISMISSED. OBVIOUSLY SOMETHING HAPPENED, ESPECIALLY CONSIDERING THE CAR WAS IN THE BODY SHOP FOR 6 MONTHS BEING REPAIRED. JANUARY 2014 WHILE DRIVING DOWN THE HIGHWAY THE CAR LOSES POWER, AND WON'T ACCELERATE OVER 19MPH, THE CHECK ENGINE LIGHT ENGAGED AND ?REDUCED PROPULSION? MESSAGE FLASHING. ONSTAR DIAGNOSED THE VEHICLE INSTANTLY, AND SAID THE VEHICLE MAY BE UNSAFE TO DRIVE DUE TO THE TRANSMISSION AND ENGINE FAULT. WE REACHED OUT TO CLASSIC CHEVROLET GRAPEVINE, AND THEY WOULD NOT ASSIST US, EVEN THOUGH THE VEHICLE IS UNDER WARRANTY. JANUARY 2014, A SECOND COLLISION, A TRUCK CLIPPED THE FRONT OF THE CAR SPEED WAS OVER 35MPH, THE TIRE BLEW, AND SUDDEN DECELERATION, RESULTING IN $14,000+ IN DAMAGES AIRBAGS FAILED TO DEPLOY, AND CAUSING RE-INJURY. GM SENT OUT IT'S THIRD PARTY COMPANY TO INSPECT, AND AN EVENT WAS RECORDED THIS TIME, HOWEVER WAS A ?NON-EVENT? EVENT. GM STATES A EVENT WAS RECORDED, BUT COULD NOT EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY. IN FEBRUARY 2014 WE REACHED OUT TO GM DIRECTLY, ASKING FOR CLARIFICATION, AND ASSISTANCE REGARDING OUR FLAWED 2011 CHEVROLET VOLT, AND WERE TOLD THEY ?RESEARCHED AND EVALUATED OUR CONCERN, AND FULFILLED ITS OBLIGATION? TO US. HOWEVER, THEY DID NOTHING. ANSWERED NO QUESTIONS, OFFERED NO RESOLUTION OR FIX. GM HAS A HISTORY OF NOT INVESTIGATING FATAL FLAWS, AND COVERING UP ITS NEGLIGENCE. *TR
Official recalls
115V145000 · Electrical System:ignition; Engine And Engine Cooling:engine:gasoline
Mar 13, 2015
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE11037 · Post-Crash Ev Fire Hazard
Opened Nov 25, 2011 · Closed Jan 20, 2012
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The subject vehicles, which employ emerging technology, are range-extended electric vehicles that utilize a high voltage (HV) battery to provide energy for propulsion. The HV battery is lithium-ion based technology that has a nominal full charge of 390 VDC, a 16 kWh capacity, and a control system that incorporates liquid (antifreeze) cooling and various electronic devices (control modules, sensors, wiring, etc) to monitor and manage the HV battery. The HV battery, portions of the cooling system, and the control system are contained within a common enclosure.During an NCAP oblique side pole impact test conducted by NHTSA in May 2011, the pole struck and deformed the sill plate under the driver's door at a location where there is a structural member. The lateral member displaced inward, pierced the HV battery enclosure and battery, and caused a battery coolant leak. Thereafter, the Agency conducted a rollover test (the rollover test consists of four 90-degree rotate-and-hold movements about the vehicle's longitudinal axis). In that test, the HV battery and electronics were exposed to coolant that leaked as a result of the crash. The vehicle fire that occurred three weeks later and the additional testing NHTSA conducted are discussed in a report titled 2011 Chevrolet Volt Battery Fire Incident Report a copy of which is available in the public file. The report indicates that intrusion induced coolant leakage, and subsequent rollover that saturates electronic components, were the only test conditions which resulted in a subject vehicle HV battery fire.GM announced its intention to conduct a free-of-charge customer satisfaction campaign (CSP) on the subject vehicles on January 5, 2012. The action affects 14,735 vehicles produced prior to December 21, 2011. The CSP addresses three areas related to the issue under investigation. The first involves a modification/strengthening of the structure of the vehicle in the area where battery intrusion occurred in the May 2011 test. The second involves adding a sensor that detects excessive HV battery coolant loss, and control system software that then alerts the driver and prevents recharging of the HV battery. When the battery cannot be recharged, it will be depleted to a lower energy state as the vehicle continues to operate on the internal combustion engine. Lastly, a tamper-proofing device will be added to the system to prevent consumers from adding coolant. GM discusses these revisions in its response to an Information Request (IR) issued by NHTSA, noting that vehicles produced in calendar year 2012 and later will be manufactured to this condition.In December 2011, and at the same test facility, NHTSA repeated the May 2011 side impact test using a model year 2012 Volt modified to the structural condition described in the CSP. The test did not produce intrusion of the HV battery, a coolant leakage, or a fire (see test 7611, available at www.nhtsa.gov/Research/Databases+and+Software). In its IR response, GM describes four (4) additional side impact tests of modified subject vehicles it recently conducted using various build configurations and impact speeds (including higher speeds). GM reports that none produced HV battery intrusion, coolant leakage, or a fire.As noted in the complaint counts above, ODI has not identified a crash occurring in consumer's use of the vehicle that has resulted in a vehicle fire, or produced coolant leakage. ODI notes that side impact crashes with pole-like structures, such as would strike the sill plate, occur fairly infrequently, and such crashes with rollovers are even less frequent. A defect trend has not been identified at this time, and further investi