NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
44 reportsClear category filter130,000 miles · Mar 11, 2019
EngineUnknown Or OtherFire
ON FEBRUARY 14 2019, I WENT OUTSIDE TO WARM UP MY CAR. 10 MINUTES LATER WHILE THE CAR WAS STILL PARKED THE WHOLE ENGINE WAS ENGULFED IN FLAMES. FIRE DEPARTMENT WAS CALLED TO PUT OUT THE FIRE. NO RECENT WORK HAD BEEN DONE TO THE VEHICLE. THE ONLY WORK EVER DONE IN THE 4 YEARS I OWNED IT WERE, NEW TIRES, NEW BATTERY (IN THE BACK S…
Read full complaint
ON FEBRUARY 14 2019, I WENT OUTSIDE TO WARM UP MY CAR. 10 MINUTES LATER WHILE THE CAR WAS STILL PARKED THE WHOLE ENGINE WAS ENGULFED IN FLAMES. FIRE DEPARTMENT WAS CALLED TO PUT OUT THE FIRE. NO RECENT WORK HAD BEEN DONE TO THE VEHICLE. THE ONLY WORK EVER DONE IN THE 4 YEARS I OWNED IT WERE, NEW TIRES, NEW BATTERY (IN THE BACK SEAT) AND OIL CHANGES.
NHTSA ODI #11186020
94,000 miles · Jan 15, 2019
Unknown Or Other
THREE MONTHS AGO, THE BACK MOON ROOF MADE A LOUD BANG AND SHATTERED WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 50 MILES PER HOUR. THERE WAS NO IMPACT TO THE MOON ROOF OR OTHER VEHICLES IN THE AREA. WE HAD IT REPLACED AT A LOCAL CHEVROLET DEALER. THIS MORNING ON MY WAY TO WORK, THE SAME THING HAPPENED TO THE MOON ROOF T…
Read full complaint
THREE MONTHS AGO, THE BACK MOON ROOF MADE A LOUD BANG AND SHATTERED WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 50 MILES PER HOUR. THERE WAS NO IMPACT TO THE MOON ROOF OR OTHER VEHICLES IN THE AREA. WE HAD IT REPLACED AT A LOCAL CHEVROLET DEALER. THIS MORNING ON MY WAY TO WORK, THE SAME THING HAPPENED TO THE MOON ROOF THAT HAD BEEN REPLACED. I WAS DRIVING AT APPROXIMATELY 70 MILES PER HOUR WITH NO OTHER VEHICLES AROUND ME.
NHTSA ODI #11170119
40,000 miles · Sep 29, 2018
Unknown Or Other
THE "SERVICE TRACTION CONTROL" MESSAGE APPEARS ON THE DASHBOARD AND THE ENGINE POWER IS REDUCED. THE CAR LIMPS ALONG AT VERY LOW SPEED WITH NO POWER AVAILABLE. VERY DANGEROUS.
NHTSA ODI #11132278
90,000 miles · Dec 24, 2017
Electronic Stability Control (esc)Unknown Or Other
STABILITY/TRACCION CONTROL ERRORS. THIS ERROR MAKE THE ENGINE TO LOSE POWER AND EVEN TO PUT THE CAR AT COMPLETE STOP. IT IS DANGEROUS BECVAUSE IT CAN HAPPEN ANY TIME EVEN IN THE HIGHWAY.
NHTSA ODI #11056324
3 miles · Jul 20, 2017
Power TrainUnknown Or OtherWheels
WHEN I DRIVE CAR WHEELS, TRANSMISSION AND POWER TRAIN FREEZE UP FOR APPROXIMATELY 30 SECONDS TO A MINUTE INTERMITTENTLY WHILE I DRIVE. THIS IS HAPPENING WITH MORE FREQUENCY WHILE I DRIVE. IT HAPPENS WHETHER I AM DRIVING 5 MPH OR 65 MPH.
NHTSA ODI #11006658
63,593 miles · Jul 15, 2017
Electronic Stability Control (esc)Unknown Or Other
WHEN TRAVELING TO ANY DESTINATION UTILIZING CITY STREET OR A HIGHWAY, WHETHER TRAFFIC IS HEAVY OR MOVING FAST OR SLOW, MY VEHICLE IS ALWAYS BEING CUT IN FRONT OF , CUT OFF WITH INTENT. CAUSING ME TO APPLY BRAKES WHETHER I AM TRAVELING AT 35 MPH , 45, 55, 60, 70, EVEN IN A SCHOOL ZONE AT 15 MPH. ALSO, I HAVE CONCERNS ABOUT TH…
Read full complaint
WHEN TRAVELING TO ANY DESTINATION UTILIZING CITY STREET OR A HIGHWAY, WHETHER TRAFFIC IS HEAVY OR MOVING FAST OR SLOW, MY VEHICLE IS ALWAYS BEING CUT IN FRONT OF , CUT OFF WITH INTENT. CAUSING ME TO APPLY BRAKES WHETHER I AM TRAVELING AT 35 MPH , 45, 55, 60, 70, EVEN IN A SCHOOL ZONE AT 15 MPH. ALSO, I HAVE CONCERNS ABOUT THE DRIVER SEAT,
NHTSA ODI #11005513
32,500 miles · May 30, 2017
EngineUnknown Or Other
THE CHECK ENGINE LIGHT KEEPS COMING ON, BUT NO PROBLEM CAN BE FOUND BY THE DEALERSHIP. THE TRANSMISSION KEEPS "JERKING" OR IT EVEN FEELS LIKE IT IS FALLING OUT. I'VE READ THAT IT CAN TAKE A WHILE FOR THE VEHICLE TO "LEARN" HOW YOU DRIVE, BUT THIS DOESN'T FEEL RIGHT. ALMOST TOO SCARED TO DRIVE. I WAS STOPPED AT A STOP LIGHT AND …
Read full complaint
THE CHECK ENGINE LIGHT KEEPS COMING ON, BUT NO PROBLEM CAN BE FOUND BY THE DEALERSHIP. THE TRANSMISSION KEEPS "JERKING" OR IT EVEN FEELS LIKE IT IS FALLING OUT. I'VE READ THAT IT CAN TAKE A WHILE FOR THE VEHICLE TO "LEARN" HOW YOU DRIVE, BUT THIS DOESN'T FEEL RIGHT. ALMOST TOO SCARED TO DRIVE. I WAS STOPPED AT A STOP LIGHT AND MY VEHICLE STALLED (I DIDN'T REALIZE THIS UNTIL I TRIED TO GO AT A GREEN LIGHT) AND WOULDN'T MOVE...EVEN WHEN I DIDN'T HAVE IT IN PARK. I HAD TO TURN IT OFF AND ON TWICE BEFORE MY VEHICLE WOULD MOVE. I'VE HAD ELECTRICAL PROBLEMS WITH THE VEHICLE AS WELL. IT'S ONLY A 2014. THIS SHOULD NOT BE HAPPENING!
NHTSA ODI #10992116
Mileage unknown · Apr 28, 2017
Air BagsUnknown Or Other
THE AIR BAG SERVICE LIGHT WENT OFF ON 3/27/17 AFTER GETTING NEW TIRES. ALSO A COUPLE OF MONTHS AGO THE CAR WENT OUT OF PARK WHILE MY DAUGHTER WAS IN THE PASSENGER SIDE, I RAN OUT TO STOP IT!
NHTSA ODI #10981184
62,000 miles · Apr 23, 2017
Unknown Or Other
I WAS DRIVING ON THE INTERSTATE GOING 65 MPH AND THE VEHICLE SUDDENLY LOSS POWER THEN COMPLETELY SHUT OFFF. IT DISPLAYS SEVERAL MESSAGES SAYING LOSS ENGINE POWER, LOSS OF TRACTION CONTROL. ONCE I GOT THE TRAVERSE TO THE MEDIAN, IT RESTARTED AND SOUNDED LIKE A VERY OLD PICK UP TRUCK. I RESTARTED IT AGAIN AND IT SOUNDED NORMAL. I …
Read full complaint
I WAS DRIVING ON THE INTERSTATE GOING 65 MPH AND THE VEHICLE SUDDENLY LOSS POWER THEN COMPLETELY SHUT OFFF. IT DISPLAYS SEVERAL MESSAGES SAYING LOSS ENGINE POWER, LOSS OF TRACTION CONTROL. ONCE I GOT THE TRAVERSE TO THE MEDIAN, IT RESTARTED AND SOUNDED LIKE A VERY OLD PICK UP TRUCK. I RESTARTED IT AGAIN AND IT SOUNDED NORMAL. I CALLED FOR A TOW TRUCK , THAT TOWED IT DIRECTLY TO THE DEALERSHIP. THEY KEPT IT TWO DAYS AND SAID THEY COULDN'T DUPLICATE THE PROBLEM AND CHARGED ME $100 DIAGNOSTIC FEE. THIS HAPPEN 2 MORE TIMES AFTER THIS ON THE INTERSTATE (65MPH AGAIN) AND WHILE I WAS PARKING IN A PARKING LOT (2 MPH) AGAIN, IT WAS SENT TO THE DEALERSHIP AND THEY STATED THE SAME THING ...COULDN'T DUPLICATE THE PROBLEM. NOTE, IT WAS SENT TO 2 SEPARATE CHEVY DEALERSHIP IN DIFFERENT COUNTIES. I CONTACTED GENERAL MOTORS AND THEY HAVE NOT ISSUED A RECALL, ANY ADVICE ON HOW TO FIX THIS OR ANY COMPENSATION. SIMPLY GAVE ME A CASE NUMBER .
NHTSA ODI #10980022
1 miles · Nov 2, 2016
Electrical SystemPower TrainUnknown Or Other
SLIGHTLY IN MOTION ABOUT 5 MPH AND SOMETIMES AROUND 50 MPH, THE DIC WILL RESET WITHIN A SPLIT SECOND, THE RADIO WILL CUTOFF AND ALL DASHBOARD SIGNS WILL COME ON MOMENTARILY LIKE A RESET. THIS IS A POSSIBLE ELECTRICAL ISSUE DUE TO FAULTY IGNITION SWITCH, FAULTY ENGINE CONTROL MODULE, IGNITION SWITCH HARNESS SHORTED OR EVEN POOR E…
Read full complaint
SLIGHTLY IN MOTION ABOUT 5 MPH AND SOMETIMES AROUND 50 MPH, THE DIC WILL RESET WITHIN A SPLIT SECOND, THE RADIO WILL CUTOFF AND ALL DASHBOARD SIGNS WILL COME ON MOMENTARILY LIKE A RESET. THIS IS A POSSIBLE ELECTRICAL ISSUE DUE TO FAULTY IGNITION SWITCH, FAULTY ENGINE CONTROL MODULE, IGNITION SWITCH HARNESS SHORTED OR EVEN POOR ELECTRICAL CONNECTION CAUSING VOLTAGE DIFFERENCE
NHTSA ODI #10923829
Official recalls
7May 10, 2023
General Motors, LLC (GM) is recalling certain 2014-2017 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. GM began mailing final owner letters February 23, 2024 and will continue mailing through December 2025. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N232404980.
Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Apr 30, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence & remedy
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Additional source detail variants (3)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Electrical System: Instrument Cluster/panel
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Fuel System, Gasoline
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Feb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration