NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
22 reportsClear category filterMileage unknown · Jul 17, 2018
Service Brakes
GENERAL MOTORS IS AWARE OF A BRAKE PEDAL RUBBING NOISE ISSUE, HOWEVER THEY DO NOT INFORM OWNERS ABOUT A REMEDY. THE SQUEAKY/RUBBING BRAKE PEDAL NOISE IS A KNOWN ISSUE AS I HAVE BEEN TOLD FOR THIS MODEL AS WELL AS SEVERAL OTHERS ON THE GM LINEUP. I AM ASKING GM TO TAKE RESPONSIBILITY BY DOCUMENTING MY CONCERN AS WELL AS ISSUING A…
Read full complaint
GENERAL MOTORS IS AWARE OF A BRAKE PEDAL RUBBING NOISE ISSUE, HOWEVER THEY DO NOT INFORM OWNERS ABOUT A REMEDY. THE SQUEAKY/RUBBING BRAKE PEDAL NOISE IS A KNOWN ISSUE AS I HAVE BEEN TOLD FOR THIS MODEL AS WELL AS SEVERAL OTHERS ON THE GM LINEUP. I AM ASKING GM TO TAKE RESPONSIBILITY BY DOCUMENTING MY CONCERN AS WELL AS ISSUING A RECALL SO IT MAY BE ADDRESSED BEFORE IT CAUSES SOMETHING TO GO WRONG AND POSSIBLY CAUSE AN ACCIDENT.
NHTSA ODI #11111988
53,000 miles · Jul 9, 2018
Electronic Stability Control (esc)EngineService Brakes
HIGHWAY SPEED, HIT MODERATE POTHOLE AND RECEIVED MULTIPLE ERROR MESSAGES IN THE DISPLAY "ENGINE POWER REDUCED" "SERVICE STABILITRAK" "SERVICE TRACTION CONTROL". ENGINE BARELY RUNNING/RUNNING ROUGH. BRAKES HAVE NO POWER ASSIST. VEHICLE STRUGGLING TO MAINTAIN 20MPH AND HARD TO GET OFF THE FREEWAY. APPEARED TO BE COMPLETE ECU MALFU…
Read full complaint
HIGHWAY SPEED, HIT MODERATE POTHOLE AND RECEIVED MULTIPLE ERROR MESSAGES IN THE DISPLAY "ENGINE POWER REDUCED" "SERVICE STABILITRAK" "SERVICE TRACTION CONTROL". ENGINE BARELY RUNNING/RUNNING ROUGH. BRAKES HAVE NO POWER ASSIST. VEHICLE STRUGGLING TO MAINTAIN 20MPH AND HARD TO GET OFF THE FREEWAY. APPEARED TO BE COMPLETE ECU MALFUNCTION. HAD TO ABANDON CAR IN A PUBLIC PARKING LOT AND HAVE SOMEONE PICK US UP. VEHICLE WAS TOWED TO LOCAL DEALERSHIP AND YET THEY CAN FIND NO FAULT CODES, THUS RELEASING THE CAR WITH NO WORK PERFORMED. THIS PHENOMENON HAS BEEN DOCUMENTED ON YOUTUBE HERE: [XXX] NOTE: THIS IS NOT MY VIDEO, BUT IS THE EXACT SCENARIO I ENCOUNTERED. SIMILAR VIDEO DOCUMENTED HERE: [XXX] MANY OTHER INSTANCES DOCUMENTED ON THE INTERNET IN VARIOUS VEHICLE FORUMS AND ACROSS OTHER GM PLATFORMS. THIS IS AN UNSAFE CONDITION THAT SHOULD BE A BETTER INVESTIGATED ISSUE BY CHEVROLET. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *AN
NHTSA ODI #11110338
Mileage unknown · Jun 24, 2018
Power TrainService Brakes
WHEN APPLYING BRAKES, IT MAKES A SOUND LIKE WATER AND HAS BEEN DOING THAT SINCE PURCHASE 09/17, AND WHEN ACCELERATING THERE'S A JERKING LIKE THE ENGINE IS TRYING TO ENGAGE????? ALL IN MOTION
NHTSA ODI #11103663
Mileage unknown · Jun 12, 2018
Service BrakesSteering
THE STEERING HAS A WHINING NOISE AND THE BRAKE HAS A SQUEAKY NOISE THAT BOTH FEEL UNSAFE TO DRIVE. MANY OWNERS HAVE EXPERIENCED THESE ISSUE ON BUICK ENCLAVE, SATURN OUTLOOK, CHEVY TRAVERSE AND GMC ACADIA AS WELL AS OTHERS. NO SOLUTION HAS BEEN ISSUED BY GM AND SOMETHING NEEDS TO BE DONE TO REMEDY THESE ISSUES.
NHTSA ODI #11101543
40,985 miles · Jan 5, 2018
EngineService Brakes
I BOUGHT THIS CAR USED WITH 39,400 MILES ON IT 4 MTHS AGO. WHILE PRESSING ON THE BRAKE IT MAKES A VERY LOUD AND ANNOYING SQEAKING SOUND. I RETURNED IT TO THE DEALERSHIP TO BE LOOKED AT AND THEY STATED IT IS IN FACT THE MASTER CYLINDER AFFECTING THE BRAKE, AND IT IS A KNOWN CHEVY TRAVERSE PROBLEM THAT SHOULD BE RECALLED.
NHTSA ODI #11060656
70,367 miles · Oct 23, 2017
Service Brakes
I BOUGHT THIS CAR USED, AND SHORTLY AFTER NOTICED THERE WAS A SQUEAKING SOUND WHENEVER YOU DEPRESS THE BRAKE PEDAL. I TOOK IT IN TO THE DEALERSHIP AND THEY DEDUCED IT WAS THE BRAKE BOOSTER. THEY SAID THIS IS A KNOWN ISSUE WITH THE TRAVERSE BUT IT HAD NOT BEEN RECALLED YET. I SPENT OVER $400 GETTING THIS FIXED.
NHTSA ODI #11035771
41,000 miles · Oct 22, 2017
Power TrainService Brakes
41K MILES AND TRANSMISSION SOMETIMES WON'T SHIFT. I EVEN HAD TO PULL OVER TODAY AND SHUT OFF THE CAR AFTER IT WOULDN'T UPSHIFT UP A RESIDENTIAL HILL. 41K MILES AND HAD TO REPLACE FRONT BRAKE PADS ALREADY. THEY HAD PLENTY OF BRAKE LEFT, BUT THEY WERE CRACKED.
NHTSA ODI #11035552
21,000 miles · Nov 24, 2015
Electrical SystemService Brakes
WHILE IN MOTION, THE VEHICLE BEGAN TO SPUTTER, THE DASHBOARD AND RADIO WENT BLANK, THE LOCKS IN THE DOORS WENT UP AND DOWN SEVERAL TIMES. I PRESSED THE BRAKE AND WAS UNABLE TO STOP THE CAR AS I WAS APPROACHING A STOP SIGN. I HAD TO ROLL THROUGH THE STOP SIGN AND NARROWLY MISSED BEING HIT AT THE INTERSECTION. WITHIN A FEW SECO…
Read full complaint
WHILE IN MOTION, THE VEHICLE BEGAN TO SPUTTER, THE DASHBOARD AND RADIO WENT BLANK, THE LOCKS IN THE DOORS WENT UP AND DOWN SEVERAL TIMES. I PRESSED THE BRAKE AND WAS UNABLE TO STOP THE CAR AS I WAS APPROACHING A STOP SIGN. I HAD TO ROLL THROUGH THE STOP SIGN AND NARROWLY MISSED BEING HIT AT THE INTERSECTION. WITHIN A FEW SECONDS, THE VEHICLE REGAINED POWER AND I WAS ABLE TO DRIVE HOME. THIS HAS HAPPENED ON 2 OTHER OCCASIONS WHERE THE CAR HAS LOST ELECTRICAL POWER FOR SEVERAL SECONDS WHILE DRIVING DOWN THE ROAD. I ALSO WENT OUT TO MY STATIONARY PARKED CAR AND TRIED TO START IT ONE MORNING. THE VEHICLE WAS COMPLETELY DEAD, LIKE IT HAD A DEAD BATTERY, BUT THE IGNITION WOULD NOT RELEASE MY KEY OR LET ME TURN THE KEY BACK TO THE OFF POSITION. SO I STARTED TO TRY TO GET TO THE BATTERY TO JUMP TH E VEHICLE OFF, BUT BY THE TIME I GOT READY TO DO THIS, I OPENED THE CAR DOOR AND ALL THE LIGHTS CAME BACK ON AND THE CAR STARTED RIGHT UP (BUT WITHOUT A WORKING RADIO THIS TIME). THIS IS A VERY SERIOUS AND DANGEROUS PROBLEM. WE HAVE ONLY HAD THE CAR FOR A FEW MONTHS AND WE HAVE NOW HAD OUR CAR IN A CHEVY DEALERSHIP FOR 15 DAYS AND THEY HAVE BEEN UNABLE TO REPLICATE THE PROBLEM AND SO THEY ARE TRYING TO SEND THE VEHICLE HOME WITH US WITHOUT ANY OTHER SOLUTION OTHER THAN TO KEEP DRIVING IT (PUTTING MY FAMILY IN DANGER) AND TRY TO RECORD IT WHEN IT HAPPENS AGAIN (SO I CAN PROVE I'M NOT CRAZY OR JUST MAKING THIS STUFF UP).
NHTSA ODI #10806544
18,148 miles · Jul 20, 2015
Power TrainService Brakes
TL* THE CONTACT OWNS A 2014 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE CONTACT WAS ABLE TO AVOID A CRASH BY SWITCHING THE GEAR INTO THE NEUTRAL POSITION. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE CONTACT WAS ABLE TO AVOID A CRASH BY SWITCHING THE GEAR INTO THE NEUTRAL POSITION. THE VEHICLE WAS NOT DIAGNOSED ORE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,148.
NHTSA ODI #10735187
6,500 miles · Sep 12, 2014
Electronic Stability Control (esc)EngineService Brakes
DRIVING NORMALLY AT 55 MPH. CAR SLOWED TO 35 MPH AND ENGINE LIGHT CAME ON, AND DASH READ STABILITRAC SERVICE NEEDED ENGINE POWER SLOWED. I COULD NOT GO OVER 35 MPH ON FREEWAY AND VERY DIFFICULT TO BRAKE. *TR
NHTSA ODI #10632705
Official recalls
7May 10, 2023
General Motors, LLC (GM) is recalling certain 2014-2017 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. GM began mailing final owner letters February 23, 2024 and will continue mailing through December 2025. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N232404980.
Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Apr 30, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence & remedy
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Additional source detail variants (3)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Electrical System: Instrument Cluster/panel
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Fuel System, Gasoline
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Feb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration