NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
53 reportsClear category filter74,500 miles · May 23, 2018
Electrical SystemElectronic Stability Control (esc)Engine
ON ALL OCCASIONS, MY CAR WAS IN MOTION ON MAJOR CITY STREETS AND SIDE ROADS AND MY DRIVING SPEEDS RANGED FROM 25MPH TO 55MPH. THE FOLLOWING MESSAGES FLASH ACROSS THE DASHBOARD: TRACTION CONTROL OFF, ENGINE POWER IS REDUCED, SERVICE TRACTION CONTROL, SERVICE STABILITRAK. THE CHECK ENGINE LIGHT COMES ON WITH THE STABILITRAK ICON. …
Read full complaint
ON ALL OCCASIONS, MY CAR WAS IN MOTION ON MAJOR CITY STREETS AND SIDE ROADS AND MY DRIVING SPEEDS RANGED FROM 25MPH TO 55MPH. THE FOLLOWING MESSAGES FLASH ACROSS THE DASHBOARD: TRACTION CONTROL OFF, ENGINE POWER IS REDUCED, SERVICE TRACTION CONTROL, SERVICE STABILITRAK. THE CHECK ENGINE LIGHT COMES ON WITH THE STABILITRAK ICON. MY SPEED WAS THROWN DOWN TO THE RANGE OF 10MPH TO 40MPH. THE ENTIRE CAR BEGAN SHAKING AND THE EXHAUST PIPE WAS GIVING LOUD "PUFFING" SOUNDS. THIS HAPPENED SEVERAL TIMES, BUT THE THIRD TIME, I WAS NOT ABLE TO RESTART MY CAR. I HAD IT TOWED TO THE DEALERSHIP I BOUGHT IT FROM. AFTER HAVING IT FOR A MONTH, THEY WERE UNABLE TO FIND THE ISSUE, THEREFORE NOTHING WAS FIXED, AND I WAS TOLD "LET US KNOW IF IT HAPPENS AGAIN." WOW! ...AND IT HAPPENED AGAIN MONTHS LATER - AGAIN THREE SEPARATE TIMES! AGAIN, THE DEALERSHIP SAID THEY RECEIVED NO "ERROR MESSAGES" FOR THAT ISSUE, ONLY FOR MY CAR ALARM BEING FAULTY. GOOD GRIEF! HAD I BEEN ON A FREEWAY DURING ONE OF THESE OCCURRENCES, I WOULD HAVE BEEN REAR-ENDED AND INTO A BAD ACCIDENT; BUT "WE'LL JUST SEE IF IT HAPPENS AGAIN!" I OFFERED THE DEALERSHIP VIDEO AND PICTURES AS PROOF OF THE ISSUE, BUT NOTHING HAS YET BEEN DONE. I HAVE A VIDEO THAT LASTS 1MIN AND 11 SECONDS, BUT ITS TOO LARGE FOR ME TO UPLOAD (EVEN WHEN I SHORTEN IT DOWN TO A MINIMUM 25SECONDS TO GET THE GIST OF THE ISSUE).
NHTSA ODI #11097557
57,000 miles · Jan 18, 2018
Electrical System
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING WHILE BEING OPERATED AT VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS PROVIDED WITH CASE NUMBER: 8-3794078576 AND AN APPOINTMENT WAS SCHEDULED WITH JBA CHE…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING WHILE BEING OPERATED AT VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS PROVIDED WITH CASE NUMBER: 8-3794078576 AND AN APPOINTMENT WAS SCHEDULED WITH JBA CHEVROLET (7327 RITCHIE HWY, GLEN BURNIE, MD) TO GET THE FAILURE DIAGNOSED. A DEALER WAS NOT CONTACTED PRIOR TO THE MANUFACTURER COMMUNICATION. IN ADDITION, THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V614000 (ELECTRICAL SYSTEM); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 57,000.
NHTSA ODI #11063508
76,000 miles · Dec 12, 2017
Electrical SystemEngine
TL* THE CONTACT OWNS A 2013 CHEVROET TRAVERSE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE TRACTION, ENGINE, AND SERVICE STABILITRAK WARNING INDICATORS ILLUMINATED. IN ADDITION, THE STEERING WHEEL SEIZED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO GEORGE MORRE CHE…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROET TRAVERSE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE TRACTION, ENGINE, AND SERVICE STABILITRAK WARNING INDICATORS ILLUMINATED. IN ADDITION, THE STEERING WHEEL SEIZED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO GEORGE MORRE CHEVROLET (10979 ATLANTIC BLVD, JACKSONVILLE, FL 32225) WHERE IT WAS DIAGNOSED THAT THE MOTHERBOARD NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, MONTHS LATER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO GEORGE MORRE CHEVROLET, BUT THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.
NHTSA ODI #11054093
80,000 miles · Nov 12, 2017
Electrical System
BATTERY KEEPS DRAINING. BATTERY WILL CHARGE AND THEN WHEN THE CAR SITS, SOMETHING IS DRAWING POWER OUT. THE CD PLAYER AND NAVIGATION CYCLE CONSTANTLY.
NHTSA ODI #11045482
Mileage unknown · Dec 29, 2016
Electrical System
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS PERTAINING TO THE LOW BEAM LIGHTS, THE INTERIOR LIGHTING, AND THE GAUGES ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED OF THE FAILURES SEVERAL TIMES, BUT WAS UNABLE TO PROVIDE A SOLUTION. THE MANUFACTURER WAS NOTIFIED.…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS PERTAINING TO THE LOW BEAM LIGHTS, THE INTERIOR LIGHTING, AND THE GAUGES ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED OF THE FAILURES SEVERAL TIMES, BUT WAS UNABLE TO PROVIDE A SOLUTION. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS WAITING FOR A REMEDY FROM THE MANUFACTURER TO PROVIDE A SOLUTION TO THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10938522
38,000 miles · Nov 8, 2015
Electrical SystemElectronic Stability Control (esc)
CAR TURNED ITSELF OFF WHILE DRIVING 55 MPH ON HIGHWAY WITH MY CHILDREN IN THE CAR. TRAVERSE RANDOMLY SWITCHES BETWEEN CD AND RADIO BY ITSELF. TRACTION CONTROL WARNING SOUNDS RANDOMLY. SOMETIMES WHEN KEY IS TURNED OFF ALL GOES BLACK ON DASH WITHOUT OPENING THE DOOR. THERE IS NO PATTERN TO ANY OF THIS. ALWAYS TOTALLY RANDOM. I…
Read full complaint
CAR TURNED ITSELF OFF WHILE DRIVING 55 MPH ON HIGHWAY WITH MY CHILDREN IN THE CAR. TRAVERSE RANDOMLY SWITCHES BETWEEN CD AND RADIO BY ITSELF. TRACTION CONTROL WARNING SOUNDS RANDOMLY. SOMETIMES WHEN KEY IS TURNED OFF ALL GOES BLACK ON DASH WITHOUT OPENING THE DOOR. THERE IS NO PATTERN TO ANY OF THIS. ALWAYS TOTALLY RANDOM. I HAVE STARTED PRESSING RECORD ON MY PHONE BEFORE EVERY TIME I START MY CAR FOR THE POSSIBILITY THAT I WILL CATCH ONE OF THE RANDOM INSTANCES ON CAMERA. DEALERSHIP HAS REPLACED MY RADIO FOCUSING ON IT AND IGNORING MY TRACTION CONTROL ISSUE AND POWER LOSS. SINCE THESE ISSUES CANNOT BE TRIGGERED AND ARE COMPLETELY RANDOM I HAD TO CATCH MY RADIO FREEZING UP ON VIDEO TO GET DEALER TO BELIEVE MY ACCUSATIONS. MY CAR HAS BEEN "REPROGRAMMED" TWICE, NEW RADIO INSTALLED, REPAIRED INFORMATION BUTTONS ONCE, THEN INFORMATION BUTTONS REPLACED AND EACH TIME TELLING ME THAT ITS ALL FIXED NOW. WELL, I NOW HAVE VIDEO THAT PROVES DIFFERENTLY. SO WHEN IS THE NEXT TIME MY CAR IS GOING TO SHUT OFF? WILL MY CHILDREN BE WITH ME OR WILL IT ONLY BE A RISK OF THEM LOSING THEIR MOTHER??
NHTSA ODI #10789049
20,000 miles · Oct 21, 2015
Electrical SystemEngine
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE, POWER TO THE ENGINE DIMINISHED, TRACTION CONTROL AND STABILITY CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE RESTARTED AFTER THE VEHICLE WAS PARKED FOR APPROXIMATELY TEN MINUTES AND THE CHECK ENGINE…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE, POWER TO THE ENGINE DIMINISHED, TRACTION CONTROL AND STABILITY CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE RESTARTED AFTER THE VEHICLE WAS PARKED FOR APPROXIMATELY TEN MINUTES AND THE CHECK ENGINE WARNING INDICATOR WAS STILL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED ON THREE OTHER OCCASIONS AND WAS TAKEN TO THE DEALER EACH TIME. THE VEHICLE WAS DIAGNOSED ON THE THIRD VISIT WITH AN UNKNOWN DIAGNOSIS AND WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.
NHTSA ODI #10785036
35,535 miles · Feb 24, 2015
Air BagsElectrical SystemExterior Lighting
I TOOK MY CAR FOR SERVICE ON 2/20/2015 AND THE NEXT DAY THE SERVICE AIRBAG LIGHTS CAME ON STAYED ON EVEN AFTER I TURNED THE CAR OFF AND BACK ON. THE NEXT DAY IT DIDN'T COME BACK ON THE FOLLOWING DAY WHICH WAS 2/22/2015 IT CAME ON AND AGAIN AND STAYED ALL DAY. ON 2/23/2015 DIDN'T COME ON AT ALL THEN CAME BACK ON AGAIN ON 02/24/2…
Read full complaint
I TOOK MY CAR FOR SERVICE ON 2/20/2015 AND THE NEXT DAY THE SERVICE AIRBAG LIGHTS CAME ON STAYED ON EVEN AFTER I TURNED THE CAR OFF AND BACK ON. THE NEXT DAY IT DIDN'T COME BACK ON THE FOLLOWING DAY WHICH WAS 2/22/2015 IT CAME ON AND AGAIN AND STAYED ALL DAY. ON 2/23/2015 DIDN'T COME ON AT ALL THEN CAME BACK ON AGAIN ON 02/24/2015 AND REMAINED ON UNTIL I WROTE THIS COMPLAINT. I CALLED MY DEALER AND THEY GAVE ME AN APPOINTMENT FOR 2 WEEKS ON 3/12/2015 IF SOMETHING IS WRONG WITH THE AIRBAG I'M NOT SAFE AND MY WARRANTY MAY NO LONGER COVER IT AT THAT TIME BEING THIS IS MY ONLY MEANS OF TRANSPORTATION. *JS
NHTSA ODI #10690488
Mileage unknown · Nov 7, 2014
Electrical SystemSteeringCrashInjury
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. ALSO, THE CONTACT MENTIONED THAT THE RADIO FAILED SEVERAL TIMES AND THE SENSORS AND GAUGES INTERMITTENTLY FLICKERED. IN ADDITION, THE CONTACT STATED THAT WHILE TRAVELING 25 MPH ATTE…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. ALSO, THE CONTACT MENTIONED THAT THE RADIO FAILED SEVERAL TIMES AND THE SENSORS AND GAUGES INTERMITTENTLY FLICKERED. IN ADDITION, THE CONTACT STATED THAT WHILE TRAVELING 25 MPH ATTEMPTING TO AVOID DOG, THE CONTACT SWERVED TO THE RIGHT AND CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE BACK AND LEGS. THE CONTACT DID NOT SEEK MEDICAL ATTENTION. THE CONTACT INDICATED THAT THE STEERING WHEEL LOCKED AND THE IGNITION SWITCH WOULD NOT TURN OVER. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10653500
18,949 miles · Sep 21, 2014
Electrical System
THE BATTERY FAILED TO RECHARGE, THE VEHICLE COMPLETELY SHUT DOWN (ELECTRICALLY SPEAKING). MY WIFE AND 2 KIDS WERE STUCK IN A CAR WITH NO AC, NO ABILITY TO RECHARGE HER CELL PHONE TO CALL FOR HELP, ON A HOT 100F DAY. THANKFULLY, SHE WAS ABLE TO CALL A TOW TRUCK. AFTER 2 DAYS IN THE SHOP AT RON BAKER CHEVY IN SAN DIEGO, IT WAS DIS…
Read full complaint
THE BATTERY FAILED TO RECHARGE, THE VEHICLE COMPLETELY SHUT DOWN (ELECTRICALLY SPEAKING). MY WIFE AND 2 KIDS WERE STUCK IN A CAR WITH NO AC, NO ABILITY TO RECHARGE HER CELL PHONE TO CALL FOR HELP, ON A HOT 100F DAY. THANKFULLY, SHE WAS ABLE TO CALL A TOW TRUCK. AFTER 2 DAYS IN THE SHOP AT RON BAKER CHEVY IN SAN DIEGO, IT WAS DISCOVERED THAT THE ALTERNATOR WAS FAULTY. BOTH THE ALTERNATOR AND THE BATTERY WERE REPLACED. *TR
NHTSA ODI #10637814
Official recalls
4Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration