NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
608 reports113,000 miles · Dec 15, 2017
Engine
THE TIMING CHAIN NEEDED TO BE REPLACED AT 113,000 MILES. THIS WAS A KNOW FLAW BY GM AS PROBLEMS OCCURRED IN THE 2009 AND 2010 TRAVERSE ENGINE THAT RESULTED IN REIMBURSEMENTS FOR REPAIRS. THE 2011 TRAVERSE HAS THE SAME PROBLEM AND THE COST TO REPAIR IS ABOUT $4,500. GM SHOULD REIMBURSE FOR THIS ISSUE AS THE FLAW HAS NOT BEEN FI…
Read full complaint
THE TIMING CHAIN NEEDED TO BE REPLACED AT 113,000 MILES. THIS WAS A KNOW FLAW BY GM AS PROBLEMS OCCURRED IN THE 2009 AND 2010 TRAVERSE ENGINE THAT RESULTED IN REIMBURSEMENTS FOR REPAIRS. THE 2011 TRAVERSE HAS THE SAME PROBLEM AND THE COST TO REPAIR IS ABOUT $4,500. GM SHOULD REIMBURSE FOR THIS ISSUE AS THE FLAW HAS NOT BEEN FIXED IN 2011 MODEL.
NHTSA ODI #11054977
170,000 miles · Dec 7, 2017
Steering
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE MAKING A RIGHT TURN AT 10 MPH, THE STEERING WHEEL SEIZED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
NHTSA ODI #11053329
Mileage unknown · Dec 4, 2017
Structure
THE PAINT ON THE HOOD IS BUBBLED. I TOOK IT TO THE DEALERSHIP 3 YEARS AGO AND THEY SAID THEY WOULD PAY HALF OF THE COST TO REPAINT. I DID NOT HAVE IT DONE. I HAVE RECENTLY FOUND OUT IT IS A PROBLEM FOR A LOT OF PEOPLE WITH THAT YEAR TRAVERSE.
NHTSA ODI #11052252
11,525 miles · Nov 17, 2017
Electronic Stability Control (esc)
WHILE DRIVING THE SENSOR COMES ON AND SAYS THE STABILITY CONTROL IS OFF. THEN TURNING THE STABILITY CONTROL BACK ON BY THE BUTTON IT RESETS. THEN DRIVING IT AGAIN IT GOES BACK OFF. SOME TIMES IT RESETS BY IT SELF BY TURNING THE CAR OFF AND RESTARTING IT. THEN THE SENOR DOESN'T GO OFF. YET THEN THE NEXT TIME IT IS RESTARTED IT G…
Read full complaint
WHILE DRIVING THE SENSOR COMES ON AND SAYS THE STABILITY CONTROL IS OFF. THEN TURNING THE STABILITY CONTROL BACK ON BY THE BUTTON IT RESETS. THEN DRIVING IT AGAIN IT GOES BACK OFF. SOME TIMES IT RESETS BY IT SELF BY TURNING THE CAR OFF AND RESTARTING IT. THEN THE SENOR DOESN'T GO OFF. YET THEN THE NEXT TIME IT IS RESTARTED IT GOES BACK OFF. DRIVING DOWN ANY ROAD NO WATER OR ICE ON ROAD AT ALL COMPLETELY DRY.
NHTSA ODI #11046903
130,000 miles · Nov 4, 2017
Electrical SystemExterior LightingFire
THE HEADLIGHT ON THE PASSENGER SIDE CAUGHT ON FIRE WHERE IT CONNECTS TO THE WIRING SYSTEM. THE VEHICLE WAS PARKED BUT RUNNING IN A DRIVEWAY. THIS CAUSED ABOUT 2000 IN DAMAGES TO THE VEHICHLE.
NHTSA ODI #11043215
44,000 miles · Oct 27, 2017
EngineExterior LightingCrash
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING 80 MPH, THE HEADLIGHTS AND ALL THE INSTRUMENT PANEL LIGHTING TURNED OFF WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD, TURNED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE BACK HOME ONLY WITH THE HIGH BEAM LIGHTS. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING 80 MPH, THE HEADLIGHTS AND ALL THE INSTRUMENT PANEL LIGHTING TURNED OFF WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD, TURNED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE BACK HOME ONLY WITH THE HIGH BEAM LIGHTS. THE VEHICLE WAS TAKEN TO THE DEALER (RYDELL CHEVROLET, 18600 DEVONSHIRE ST, NORTHRIDGE, CA 91324) WHERE IT WAS DIAGNOSED THAT THE HEADLIGHTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT WHEN DRIVING ON A RAINY DAY AT 15 MPH, THE HEADLIGHTS TURNED OFF AND ALL THE INSTRUMENT PANEL LIGHTS TURNED OFF WITHOUT WARNING. THE FAILURE CAUSED THE CONTACT TO CRASH INTO ANOTHER VEHICLE THAT WAS PARKED ON THE SIDE OF THE ROAD. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE HEADLIGHTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED SEVERAL OTHER TIMES EVEN AFTER THE VEHICLE WAS REPAIRED. ALSO, WHILE DRIVING 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE SAME DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC (ULTIMATE CONNECTIONS, 9517 1/2 SEPULVEDA BLVD, NORTH HILLS, CA 91343) WHERE IT WAS DIAGNOSED THAT THE CRANKSHAFT, OIL PUMP, AND ENGINE MOUNTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-222-1020 AND STATED THAT THEY WOULD REPLACE THE VEHICLE; HOWEVER, THE CONTACT DID NOT HEAR BACK. CASE NUMBER: 8-3184289974 WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.
NHTSA ODI #11040519
133,000 miles · Oct 18, 2017
Electrical SystemEngineSteering
I WAS ON MY WAY HOME FROM DINNER WHEN THE ENGINE STARTED REVVING ON IT'S OWN AND THE CAR BEGAN JERKING. I PULLED TO THE SIDE OF THE ROAD AND THE ENGINE KILLED. I RESTARTED THE VEHICLE AND NOTED THAT THE BATTERY WAS SUPPLING ENOUGH POWER AND THE TEMPERATURE GAGE WAS NORMAL. AT THIS TIME, THE LIGHTS STARTED TO FLICKER, THE RPMS…
Read full complaint
I WAS ON MY WAY HOME FROM DINNER WHEN THE ENGINE STARTED REVVING ON IT'S OWN AND THE CAR BEGAN JERKING. I PULLED TO THE SIDE OF THE ROAD AND THE ENGINE KILLED. I RESTARTED THE VEHICLE AND NOTED THAT THE BATTERY WAS SUPPLING ENOUGH POWER AND THE TEMPERATURE GAGE WAS NORMAL. AT THIS TIME, THE LIGHTS STARTED TO FLICKER, THE RPMS WERE GOING UP AND DOWN FAIRLY QUICKLY AND THE WINDOWS AND LOCKS WERE CLICKING. I WAS ABLE TO GET THE VEHICLE HOME (5 MILES), BUT THE PROBLEMS PERSISTED THE ENTIRE DRIVE. THE SECOND I WOULD LET ME FOOT OFF THE GAS PEDAL, THE ENGINE WOULD KILL. I TOOK IT TO THE MECHANIC AND HE SAID WHEN HE HOOKED IT UP TO THE MACHINE TO SEE WHAT THE PROBLEM WAS, THERE WAS SO MUCH WRONG HE COULDN'T ACTUALLY TELL WHAT WAS CAUSING WHAT. THE COMPUTER AND ENGINE BOTH WERE RECOMMENDED TO BE REPLACED. I LET HIM KNOW AS WELL IT HAD BECOME MORE DIFFICULT IN THE LAST FEW MONTHS TO TURN THE WHEEL WHEN GOING AT A SLOW SPEED AND VIRTUALLY IMPOSSIBLE TO PARK. HE STATED IT IS A KNOWN ISSUE WITH THIS MAKE, MODEL AND YEAR. THE STEERING, THE COMPUTER AND THE ENGINE HE HAS SEEN MULTIPLE CUSTOMERS HAVE PROBLEMS WITH.
NHTSA ODI #11034286
11,295 miles · Oct 13, 2017
Seat Belts
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING INDICATOR INADVERTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LAP PRETENSIONER ON THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED …
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING INDICATOR INADVERTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LAP PRETENSIONER ON THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED HENDRICK CHEVROLET BUICK GMC SOUTHPOINT AT (919) 888-4896 (127 KENTINGTON DR, DURHAM, NC 27713) AND THE CONTACT WAS TRANSFERRED TO THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V266000 (SEAT BELTS). THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 11,295.
NHTSA ODI #11033274
80,000 miles · Oct 12, 2017
Electronic Stability Control (esc)SteeringCrash
MY STABILITRAK HAS BEEN GOING IN AND OUT FOR YEARS WITH NO ISSUES. I HAD IT CHECKED BUT TOLD IT WAS OK. NOW IT HAS STARTED STALLING ON ME. AND I WAS SLIGHTLY REAR ENDED LAST NIGHT ON VACATION. I CALLED THE CHEVROLET 1 800 # AND TOLD NO RECALL ON THIS. HOWEVER ON LINE IS HUNDREDS OF ISSUES WITH THIS MODEL. SO OVER THE LAST 2 WEE…
Read full complaint
MY STABILITRAK HAS BEEN GOING IN AND OUT FOR YEARS WITH NO ISSUES. I HAD IT CHECKED BUT TOLD IT WAS OK. NOW IT HAS STARTED STALLING ON ME. AND I WAS SLIGHTLY REAR ENDED LAST NIGHT ON VACATION. I CALLED THE CHEVROLET 1 800 # AND TOLD NO RECALL ON THIS. HOWEVER ON LINE IS HUNDREDS OF ISSUES WITH THIS MODEL. SO OVER THE LAST 2 WEEKS IT HAS BEEN GOING FREQUENTLY. THE STEERING IS JUST MAKING NOISES AND CRUNCHING SOUNDS WHEN TURNING
NHTSA ODI #11033026
146,000 miles · Oct 10, 2017
Engine
VEHICLE HAD HAD BEEN SHUDDERING AND MISFIRING ON AND OFF FOR QUITE SOME TIME, CHECK ENGINE LIGHT CAME ON, TOOK TO SHOP FOR DIAGNOSIS. SHOP STATED CODES WERE RELATED TO STRETCHED TIMING CHAINS. I THEN TOOK TO DEALER, GOT SAME DIAGNOSIS AND A $2,000 ESTIMATE. HAD REPAIRS DONE. CHECK ENGINE LIGHT HAS NOT COME BACK ON SINCE. CA…
Read full complaint
VEHICLE HAD HAD BEEN SHUDDERING AND MISFIRING ON AND OFF FOR QUITE SOME TIME, CHECK ENGINE LIGHT CAME ON, TOOK TO SHOP FOR DIAGNOSIS. SHOP STATED CODES WERE RELATED TO STRETCHED TIMING CHAINS. I THEN TOOK TO DEALER, GOT SAME DIAGNOSIS AND A $2,000 ESTIMATE. HAD REPAIRS DONE. CHECK ENGINE LIGHT HAS NOT COME BACK ON SINCE. CAR WOULD HESITATE AND LOOSE POWER ATTEMPTING TO ACCELERATE WHEN TAKING OFF IN TRAFFIC. FELT UNSAFE DRIVING, AS I NEVER KNEW WHEN CAR WAS GOING ACCELERATE OR NOT.
NHTSA ODI #11032665
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration