NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
21 reportsClear category filter62,000 miles · Feb 24, 2016
Structure
FOR SOME REASON THE RUBBER SEALS ON ALL THE DOORS SEEM TO FAIL AT DIFFERENT POINT. I HAD THE DEALER REPLACE THE DRIVER AND PASSENGER DOOR SEAL 2-3 TIMES (WHILE THE CAR WAS UNDER THE 36,000 MILE MARK). THE BACK DOOR WHERE ONLY REPLACED ONCE EACH. NOW THAT THE CAR IS AT 62,000 MILES, IT LOOKS LIKE 2 DOOR SEALS ARE FALLING APART. …
Read full complaint
FOR SOME REASON THE RUBBER SEALS ON ALL THE DOORS SEEM TO FAIL AT DIFFERENT POINT. I HAD THE DEALER REPLACE THE DRIVER AND PASSENGER DOOR SEAL 2-3 TIMES (WHILE THE CAR WAS UNDER THE 36,000 MILE MARK). THE BACK DOOR WHERE ONLY REPLACED ONCE EACH. NOW THAT THE CAR IS AT 62,000 MILES, IT LOOKS LIKE 2 DOOR SEALS ARE FALLING APART. THIS CREATES A MASSIVE WIND NOISE IN THE CAR. I HAVE NEVER SEEN THIS FAILURE ON ANY CAR I HAVE EVER OWNED. I HAVE A JEEP WRANGLER WITH 100,000 MILES SETTING NEXT TO MY CHEVY ALL THE TIME WITH NO ISSUES
NHTSA ODI #10838096
Mileage unknown · Nov 23, 2015
Structure
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE IS…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT STATED THAT THE LIFTGATE FAILED TO STAY OPEN. THE CONTACT HAD TO MANUALLY HOLD THE LIFTGATE OPEN. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10806276
Mileage unknown · Oct 27, 2015
Structure
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE LIFTGATE FAILED TO FUNCTION PROPERLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF T…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE LIFTGATE FAILED TO FUNCTION PROPERLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10786405
Mileage unknown · Oct 27, 2015
Structure
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE I…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10786404
54,000 miles · Oct 14, 2015
Structure
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. …
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT STATED THAT WHEN THE LIFT GATE WAS OPENED ELECTRONICALLY, IT WENT UP AND, ONCE IT REACHED THE TOP, SHUTTERED AND CLOSED EXTREMELY FAST. THE FAILURE MILEAGE WAS 54,000. UPDATE 01/15/16 MA
NHTSA ODI #10781927
25,000 miles · Jun 17, 2015
Exterior LightingStructureUnknown Or Other
2011 CHEVROLET TRAVERSE- I BOUGHT THE TRUCK IN 2013 CERTIFIED, PRE-OWNED FOR ROUGHLY $35K ALL IN FROM ROBERT CHEVROLET. HAVE HAD SEVERAL ELECTRICAL AND MECHANICAL ISSUES WITH IT OVER THE PAST 2 YEARS. WINDOWS HAVE STOPPED WORKING NUMEROUS TIMES, MIRRORS AS WELL. LEFT TAIL LIGHT HAS GONE OUT 3 TIMES, HEADLIGHTS HAVE HAD IS…
Read full complaint
2011 CHEVROLET TRAVERSE- I BOUGHT THE TRUCK IN 2013 CERTIFIED, PRE-OWNED FOR ROUGHLY $35K ALL IN FROM ROBERT CHEVROLET. HAVE HAD SEVERAL ELECTRICAL AND MECHANICAL ISSUES WITH IT OVER THE PAST 2 YEARS. WINDOWS HAVE STOPPED WORKING NUMEROUS TIMES, MIRRORS AS WELL. LEFT TAIL LIGHT HAS GONE OUT 3 TIMES, HEADLIGHTS HAVE HAD ISSUES AS WELL. MOST RECENTLY MY PASSENGER SIDE STEP RAIL SNAPPED OFF AS MY 13 YEAR OLD 115 LB DAUGHTER STEPPED ON IT. I HAVE 4 CHILDREN, MY YOUNGEST IS ONE AND A HALF YEARS OLD AND ONE CONCERN I HAVE IS THAT THE OTHER SIDE RAIL SNAPS OFF AND AS MY WIFE IS PUTTING MY SON IN CAR THEY FALL ON CONCRETE IF THAT RAIL SHOULD SNAP AS WELL. IN GENERAL, I DO NOT TRUST THIS CAR OR FEEL SAFE IN IT AT ALL. THE ELECTRICAL PROBLEMS SCARE ME THE MOST, GOD FORBID THERE SHOULD BE SOME KIND OF SHORT AND STEERING OR SOMETHING WORSE GOES OUT AND MY WIFE CRASHES WITH ONE OR ALL OF MY 4 CHILDREN IN THE CAR.. MY SALES REP AT ROBERT CHEVROLET HAS BEEN CONTACTED ON SEVERAL OCCASIONS, FOR A YEAR HAS BEEN TELLING US TO COME IN AFTER SEVERAL COMPLAINTS. FINALLY I TOOK OFF OF WORK AND TOLD HIM HE NEEDED TO TAKE A LOOK AT THIS UNSAFE VEHICLE AND IT NEEDED TO BE ADDRESSED. THEY ASSURED ME THEY WOULD TAKE CARE OF IT, EVEN SUGGESTED HE WOULD TAKE ME OUT OF THE CAR AND EAT THE BULK OF THE LOSS. NEEDLESS TO SAY THEY DID NONE OF THAT, INDICATED EVERYTHING THAT'S WRONG WITH THE CAR IS WEAR AND TEAR. I BOUGHT AN EXTENDED POLICY ON THE VEHICLE AS WELL, BASICALLY NOTHING IS COVERED. AND TO BOOT, THEY SUGGESTED I PAY 1200-1500 TO FIX THE VEHICLE. AGAIN I STRESS, THE MONEY ISN'T THE BIGGEST ISSUE, I'M CONCERNED ABOUT THE SAFETY OF THIS VEHICLE.
NHTSA ODI #10725823
72,400 miles · Jul 11, 2014
Air BagsStructureSuspensionCrashInjury
WHILE SITTING AT A STOP SIGN MY TRAVERSE WAS HIT ON THE DRIVER'S SIDE BY THE TIRE AND FENDER. THE SIDE AIR BAG OR FRONT AIRBAGS DIDN'T DEPLOY. THE VEHICLE THAT HIT MY TRAVERSE HAD AIRBAGS THAT DEPLOYED. MY WIFE WAS 4 MONTHS PREGNANT AND DIDN'T HAVE PROPER PROTECTION OF THE MULTIPLE AIRBAGS THIS VEHICLE HAS. SHE INJURED HER KNEE …
Read full complaint
WHILE SITTING AT A STOP SIGN MY TRAVERSE WAS HIT ON THE DRIVER'S SIDE BY THE TIRE AND FENDER. THE SIDE AIR BAG OR FRONT AIRBAGS DIDN'T DEPLOY. THE VEHICLE THAT HIT MY TRAVERSE HAD AIRBAGS THAT DEPLOYED. MY WIFE WAS 4 MONTHS PREGNANT AND DIDN'T HAVE PROPER PROTECTION OF THE MULTIPLE AIRBAGS THIS VEHICLE HAS. SHE INJURED HER KNEE FROM BANGING INTO THE DASH BOARD AND CAUSED GREAT CONCERN ABOUT THE HEALTH OF OUR UNBORN CHILD. THE SAD PART IS NOW WE RECEIVE A LETTER THAT OUR CAR IS PART OF THE RECENT SIDE IMPACT AIR BAG RECALL ON THE CHEVROLET TRAVERSE. THE REASON WHY IT DIDN'T DEPLOY IN THE ACCIDENT IS BECAUSE OF WIRE ISSUES ON THE AIRBAG SYSTEM. UNSAFE AT ANY SPEED. *TR
NHTSA ODI #10609870
24,420 miles · Jun 4, 2014
Air BagsStructureCrashInjury
WHILE STOPPED AT A RAILROAD CROSSING, I WAS REAR ENDED BY A VEHICLE TRAVELING 55 MPH WHICH TOTALED MY CAR BUT THE AIRBAGS DID NOT DEPLOY. *TR
NHTSA ODI #10596075
48,012 miles · Feb 25, 2014
Electrical SystemSeatsStructure
THERE HAS BEEN A LEAK IN MY CHEVY TRAVERSE 2011 FOR A LONG TIME BUT WE HAD NO IDEA BECAUSE IT WAS UNDER THE FOAM IN THE CARPETS. WE FOUND WATER IN OUR BATTERY COMPARTMENT BEHIND THE SEAT. WE HAD TO REMOVE THE SEATS IN THE CAR AND FOUND BLACK MOLD UNDER THE CARPETS. WE HAVE BEEN SO SICK FOR AWHILE(DAUGHTER DIAGNOSED WITH AUTISM) …
Read full complaint
THERE HAS BEEN A LEAK IN MY CHEVY TRAVERSE 2011 FOR A LONG TIME BUT WE HAD NO IDEA BECAUSE IT WAS UNDER THE FOAM IN THE CARPETS. WE FOUND WATER IN OUR BATTERY COMPARTMENT BEHIND THE SEAT. WE HAD TO REMOVE THE SEATS IN THE CAR AND FOUND BLACK MOLD UNDER THE CARPETS. WE HAVE BEEN SO SICK FOR AWHILE(DAUGHTER DIAGNOSED WITH AUTISM) CHEVY/GM WANTS TO CHARGE US 1400+ TO FIX THE PROBLEM THAT HAS PROBABLY BEEN GOING ON SINCE WE PURCHASED THE CAR BRAND NEW IN 2011. I AM SO SADDENED THAT OUR FAMILIES SAFETY IS NOT CHEVY'S PRIORITY. IT HAS 48000 MILES ON IT SO IT IS OUT OF THE WARRANTY WINDOW. NO HELP FROM CHEVY TO TAKE THE RESPONSIBILITY TO FIX THIS ISSUE. HAVE I MENTIONED THEY HAVE HAD MY CAR FOR OVER A WEEK AND STILL CANNOT FIGURE OUT WHERE THE WATER IS COMING FROM??? OH AND THEY DIDN'T HAVE A LONER FOR US EITHER..... *TR
NHTSA ODI #10565843
15,000 miles · Apr 30, 2013
Service BrakesStructure
SHORTLY AFTER PURCHASING BRAND NEW CAR WE NOTICED SMALL RUST-COLORED SPECKS ALL OVER THE VEHICLE, MOSTLY ON THE REAR OF THE CAR. AFTER SEVERAL INSPECTIONS, MUZI FORD IN NEEDHAM, MA DIAGNOSED THIS AS "BRAKE DUST" FROM THE TYPE OF BRAKES ON THIS VEHICLE. THEY SAID THERE WAS NOTHING THAT COULD BE DONE TO PREVENT THE SPECKS, BUT TH…
Read full complaint
SHORTLY AFTER PURCHASING BRAND NEW CAR WE NOTICED SMALL RUST-COLORED SPECKS ALL OVER THE VEHICLE, MOSTLY ON THE REAR OF THE CAR. AFTER SEVERAL INSPECTIONS, MUZI FORD IN NEEDHAM, MA DIAGNOSED THIS AS "BRAKE DUST" FROM THE TYPE OF BRAKES ON THIS VEHICLE. THEY SAID THERE WAS NOTHING THAT COULD BE DONE TO PREVENT THE SPECKS, BUT THAT THE ONLY FIX WAS EXPENSIVE BUFFING/WET SANDING TREATMENTS BY THEIR BODY SHOP THAT WOULD HAVE TO BE DONE 1-2 TIMES PER YEAR, AND THEY ALSO SAID WE SHOULD WASH OUR CAR WEEKLY. OUR VEHICLE IS STILL UNDER WARRANTY. EACH BUFF COSTS APPROX $400. WE BELIEVE THIS IS A DESIGN FLAW THAT THE MANUFACTURER SHOULD COVER. *TR
NHTSA ODI #10510173
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration