NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
178 reportsClear category filter88,508 miles · Aug 29, 2017
Engine
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN WAS FAULTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. A DEAL…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN WAS FAULTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. A DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 88,508.
NHTSA ODI #11020376
60,000 miles · Aug 28, 2017
Engine
MY AUTOMATIC TRANSMISSION WON'T SHIFT TO HIGHER GEARS WHEN I ACCELERATE. I HAVE TO PULL OVER, COME TO A COMPLETE STOP, SHIFT THE CAR INTO PARK AND THEN BACK TO DRIVE. THAT SOMEHOW "RESETS" THE TRANSMISSION AND THE ENGINE BEHAVES NORMALLY AFTER THAT. THIS HAPPENS ALMOST DAILY. FRUSTRATING THING IS THAT MECHANICS HAVE ONLY BEEN AB…
Read full complaint
MY AUTOMATIC TRANSMISSION WON'T SHIFT TO HIGHER GEARS WHEN I ACCELERATE. I HAVE TO PULL OVER, COME TO A COMPLETE STOP, SHIFT THE CAR INTO PARK AND THEN BACK TO DRIVE. THAT SOMEHOW "RESETS" THE TRANSMISSION AND THE ENGINE BEHAVES NORMALLY AFTER THAT. THIS HAPPENS ALMOST DAILY. FRUSTRATING THING IS THAT MECHANICS HAVE ONLY BEEN ABLE TO MAKE IT HAPPEN ONCE. THEY SAY THEY ARE UNABLE TO ID WHAT'S WRONG. I DON'T UNDERSTAND THAT AT ALL. I'M TELLING THEM EXACTLY WHAT'S HAPPENING AND THEY DON'T EVEN KNOW WHERE TO START. AND THE CAR'S COMPUTER DOESN'T KICK OUT AN ERROR MESSAGE. THIS HAPPENS ON ALL KINDS OF ROADS. MY CAR WON'T SHIFT OUT OF 1ST GEAR. IF I DON'T PULL OVER TO "RESET" THE ENGINE, I GET A HOT METAL SMELL FROM THE ENGINE. VERY FRUSTRATING....THE MECHANICS HAVE NO CLUE WHERE TO START LOOKING. THIS HAS BEEN HAPPENING FOR MONTHS. I'VE GONE TO MULTIPLE MECHANICS AND THEY'RE ALL GRASPING AT STRAWS.
NHTSA ODI #11020111
130,000 miles · Aug 24, 2017
Engine
THE ENGINE LIGHT CAME ON AND I TOOK IT TO A SHOP, WHERE THEY TOLD ME THE CODES INDICATE THAT YOUR TIMING CHAIN IS STRETCHED. THERE IS A RECALL ON THIS ISSUE BUT DOES NOT COVER THE 2010 MODEL. I WAS TOLD THAT THE ISSUE HAD BEEN CORRECTED WITH BETTER PARTS, BUT IS HAVING THE SAME ISSUE THE 2007,2008, AND 2009 MODEL YEARS.
NHTSA ODI #11019356
68,000 miles · Aug 7, 2017
Engine
AT 68,000 MILES, THE CHECK ENGINE LIGHT CAME ON, I TOOK IT TO THE LOCAL CHEVY DEALER WHO SAID IT WAS A TIMING CHAIN PROBLEM. THEY SAID THAT IT WOULD COST ABOUT $3200 TO FIX. DOING SOME RESEARCH (OBD2 CODES P0008 AND P0009) THIS IS A COMMON PROBLEM WITH THIS PARTICULAR ENGINE, SPANNING MANY MODELS AND MODEL YEARS.
NHTSA ODI #11013368
94,000 miles · Aug 5, 2017
Engine
MY 2010 CHEVY TRAVERSE WAS BUILT IN SPRING HILL TENNESSEE FACILITY IN 2009. I BOUGHT THIS VEHICLE AT THE END OF FEBRUARY 2010. MY VEHICLE WAS MAINTAINED PER MANUFACTURER INSTRUCTIONS, OIL WAS ALWAYS CHANGED, USUALLY AROUND WHIT 40% OF OIL REMAINING AND ALWAYS BEFORE THE OIL LIFE WAS EXHAUSTED. AT ~91000 MILES CAR DISPLAYED INTER…
Read full complaint
MY 2010 CHEVY TRAVERSE WAS BUILT IN SPRING HILL TENNESSEE FACILITY IN 2009. I BOUGHT THIS VEHICLE AT THE END OF FEBRUARY 2010. MY VEHICLE WAS MAINTAINED PER MANUFACTURER INSTRUCTIONS, OIL WAS ALWAYS CHANGED, USUALLY AROUND WHIT 40% OF OIL REMAINING AND ALWAYS BEFORE THE OIL LIFE WAS EXHAUSTED. AT ~91000 MILES CAR DISPLAYED INTERMITTENT CHECK ENGINE SIGN WHICH BECOME PERMANENT AROUND ~94,000 MILES. I TOOK THE CAR TO MECHANIC WHICH SHOWED MULTIPLE ERRORS, AFTER FIXING CAMSHAFT SENSOR THE CHECK ENGINE SIGN REMAINED AND MECHANIC TOLD ME THAT I HAVE DRIVE CHAIN ERROR. THE ENGINE STARTED LOSING POWER, FAILED TO ACCELERATE. I TOOK THE VEHICLE TO DEALER I BOUGHT FROM, WAS TOLD CAR HAD MULTIPLE ISSUES INCLUDING CATALYTIC CONVERTER AND STARTER, RUSTED LEAKING Y-TIES BUT MOST EXPENSIVE WAS TIMING CHAIN AT ABOVE $2300. BOTH I AND DEALER CONTACTED GENERAL MOTOR CUSTOMER CARE SERVICE. AFTER TAKING MY INITIAL CALL, GM ASSIGNED CASE TO A SERVICE ADVISER WHO NEVER RETURNED MY CALL. SHE APPARENTLY RETURNED DEALER SERVICE MANAGER'S CALL AND ADVISED HIM TO OFFER ME $1000 DISCOUNT AT DEALER'S EXPENSE WHO ADVISED GM CUSTOMER SERVICE THAT GM, AS MANUFACTURER OF DEFECTIVE PART SHOULD TAKE RESPONSIBILITY. GM REFUSED ANY HELP WITH THE REPAIR OF VEHICLE ALTHOUGH THE TIMING CHAIN IS CLEARLY DEFECTIVE..
NHTSA ODI #11013042
78,000 miles · Aug 1, 2017
EnginePower Train
CHECK ENGINE LIGHT CAME ON AT ABOUT 78,000 MILES. DEALER INDICATED IT WAS THE DRIVE CHAIN NEEDED REPAIR ($2000-2500). THIS PROBLEM WAS COVERED BY SPECIAL POLICY #11340B ' SPECIAL COVERAGE ADJUSTMENT ' TIMING CHAIN WEAR " IN 2009 CHEVY TRAVERSE MODELS. MY VEHICLE HAS HAD EXCELLENT MAINTENANCE AND CARE, USUALLY BY THE DEALER. TH…
Read full complaint
CHECK ENGINE LIGHT CAME ON AT ABOUT 78,000 MILES. DEALER INDICATED IT WAS THE DRIVE CHAIN NEEDED REPAIR ($2000-2500). THIS PROBLEM WAS COVERED BY SPECIAL POLICY #11340B ' SPECIAL COVERAGE ADJUSTMENT ' TIMING CHAIN WEAR " IN 2009 CHEVY TRAVERSE MODELS. MY VEHICLE HAS HAD EXCELLENT MAINTENANCE AND CARE, USUALLY BY THE DEALER. THIS SHOULD NOT BE AN ISSUE AT ONLY 78,000 MILES.
NHTSA ODI #11012086
77,000 miles · Jun 15, 2017
Engine
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER (CHEVROLET CADILLAC OF GOLDSBORO) WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MAD…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER (CHEVROLET CADILLAC OF GOLDSBORO) WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 8/3034264137. THE CONTACT WAS ADVISED TO CALL NHTSA TO FILE A COMPLAINT. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.
NHTSA ODI #10995360
100,000 miles · Jun 9, 2017
Engine
CHECK ENGINE LIGHT CAME ON ALONG WITHTRACTION CONTROL. CODE FOR CHECK ENGINE WAS P0008.
NHTSA ODI #10994191
175,000 miles · Jun 8, 2017
Electronic Stability Control (esc)EngineService Brakes
WHILE DRIVING TO WORK,I START HEARING DINGS. I LOOK AT THE DASH AND IT TELLS ME THAT MY TRACTION IS OFF, TO CHECK MY STABILITRACK, AND ALSO THE BRAKE WAS ON. THEN ALL OF THE LIGHTS TURNED BACK OFF EXCEPT THE TRACTION LIGHT. NOW IT FEELS AS THOUGH MY VEHICLE IS BEING PULLED BACKWARDS AS I TRY TO DRIVE. DEFINITELY A LOSS OF POWER.
NHTSA ODI #10993872
88,549 miles · Jun 1, 2017
EnginePower Train
AT 88,000 MILE I HAVE RECIEVED A P0008 CODE - TIMING CHAINS. THIS IS ODD TO HAVE STRETCHED TIMING CHAINS AT THIS MILEAGE. REVIEWING SIMILAR COMPLAINTS ON THE INTERNET, THIS SEEMS TO BE A COMMON PROBLEM WITH 3.6 L ENGINES MADE BEFORE 2011. I CONTACT GM WITH NO AVAIL. BEING SUCH A COMMON COMPLAINT BY MANY WHY ISN'T GM STANDING BEH…
Read full complaint
AT 88,000 MILE I HAVE RECIEVED A P0008 CODE - TIMING CHAINS. THIS IS ODD TO HAVE STRETCHED TIMING CHAINS AT THIS MILEAGE. REVIEWING SIMILAR COMPLAINTS ON THE INTERNET, THIS SEEMS TO BE A COMMON PROBLEM WITH 3.6 L ENGINES MADE BEFORE 2011. I CONTACT GM WITH NO AVAIL. BEING SUCH A COMMON COMPLAINT BY MANY WHY ISN'T GM STANDING BEHIND THIS PROBLEM?
NHTSA ODI #10992759
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration