IllustrationTL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE TEMPERATURE ADJUSTMENT WAS DISTRACTING BECAUSE INSTEAD OF THERE BEING TURNING KNOBS TO ADJUST THE TEMPERATURE, THERE WERE DIGITAL BUTTONS INSTEAD. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. *TR
2010 Chevrolet Traverse
Owner reports · Recalls · Investigations
More warning signs than most Traverse years
Owner complaints for the 2010 Chevrolet Traverse are substantially higher than the model-year median of 302.
About this comparison →How this year compares
Owner complaints by model year
Compare all Traverse years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
6925–50K
17250–75K
15575–100K
111100–150K
30150K+
576 reports with mileage · 93 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports6 fire reports11 injury reports
Electrical System complaints
60 reportsTHIS CAR HAS BEEN NOTHING BUT PROBLEMS, HAVE HAD TO THE SERVICE SHOP MANY TIMES WITH "NOTHING FOUND" WILL SIT NOT MOVING AND THE DOOR LOCKS WITH START GOING UP AND DOWN, LACK OF POWER, DRIVERS DOOR MUST BE UNLOCKED MANUALLY, RADIO WILL NOT TURN OFF EVEN WHEN CAR IS OFF AND DRIVER DOOR IS OPEN, CAR WILL NOT TURN OFF EVEN AFTER TH…
Read full complaint
THIS CAR HAS BEEN NOTHING BUT PROBLEMS, HAVE HAD TO THE SERVICE SHOP MANY TIMES WITH "NOTHING FOUND" WILL SIT NOT MOVING AND THE DOOR LOCKS WITH START GOING UP AND DOWN, LACK OF POWER, DRIVERS DOOR MUST BE UNLOCKED MANUALLY, RADIO WILL NOT TURN OFF EVEN WHEN CAR IS OFF AND DRIVER DOOR IS OPEN, CAR WILL NOT TURN OFF EVEN AFTER THE KEY IS OUT OF THE IGNITION SOMETIMES WILL LAST AS LONG AS 20 MINUTES BEFORE IT WILL SHUT OFF. *TR
I HAVE HAD TROUBLE FROM THE BEGINNING AND HAVE HAD IT CHECKED WITH NO ANSWERS FOUND. THE CAR HAS LOCKED BY ITSELF (WITH AND WITHOUT KEYS IN IGNITION), SOMETIMES THE CAR WILL "DING/ALARM" WHEN THE DOOR IS OPEN AND KEYS ARE IN IGNITION AND SOMETIMES IT WON'T, WINDOWS HAVE ROLLED DOWN BY THEMSELVES, WINDOWS WON'T MOVE WHEN LEVER I…
Read full complaint
I HAVE HAD TROUBLE FROM THE BEGINNING AND HAVE HAD IT CHECKED WITH NO ANSWERS FOUND. THE CAR HAS LOCKED BY ITSELF (WITH AND WITHOUT KEYS IN IGNITION), SOMETIMES THE CAR WILL "DING/ALARM" WHEN THE DOOR IS OPEN AND KEYS ARE IN IGNITION AND SOMETIMES IT WON'T, WINDOWS HAVE ROLLED DOWN BY THEMSELVES, WINDOWS WON'T MOVE WHEN LEVER IS PUSHED (ONLY HAPPENED A COUPLE TIMES), BACK UP "BEEP" SOUND (FOR BACK UP CAMERA) KEEPS BEEPING EVEN AFTER CAR IS PUT INTO DRIVE, THE BATTERY DIED AND HAD TO BE TOWED AND BATTERY REPLACED (LESS THAN A YEAR), THE HAZARD LIGHTS CAME ON ONCE WHILE DRIVING, AND ONCE THE LIGHTS CAME ON WITHOUT BEING TOUCHED. *JS
2010 TRAVERSE IS DANGEROUS TO OPERATE, TURN SIGNAL DOES NOT WORK, CAN NOT CONTROL AIR OR HEAT HAVE TO STOP CAR TURN MOTOR OFF AND BACK ON . WILL WORK FOR A WHILE DEALER AND GM DO NOT KNOW WHATS WRONG, MARCH 26/2012 STILL NOT WORKING. *TR
VEHICLE SUDDENLY ACCELERATED AND GAS PEDAL STUCK AT ABOUT 65 MILES PER HOUR. I IMMEDIATELY TOOK MY FOOT OFF THE ACCELERATOR AND BEGIN TRYING TO BRAKE THE VEHICLE. AT THE FIRST AVAILABLE OPPORTUNITY, I PULLED TO THE SIDE OF THE EXPRESSWAY. WHILE KEEPING BOTH FEET ON THE BRAKE, I PLACED THE TRANSMISSION INTO PARK. THE VEHICLE CONT…
Read full complaint
VEHICLE SUDDENLY ACCELERATED AND GAS PEDAL STUCK AT ABOUT 65 MILES PER HOUR. I IMMEDIATELY TOOK MY FOOT OFF THE ACCELERATOR AND BEGIN TRYING TO BRAKE THE VEHICLE. AT THE FIRST AVAILABLE OPPORTUNITY, I PULLED TO THE SIDE OF THE EXPRESSWAY. WHILE KEEPING BOTH FEET ON THE BRAKE, I PLACED THE TRANSMISSION INTO PARK. THE VEHICLE CONTINUED TO REV RPMS AT THE EQUIVALENT OF ABOUT 65 MILES PER HOUR. I USED MY RIGHT HAND TO PULL THE ACCELERATOR UP AND THE ENGINE RETURNED TO A NORMAL IDLE. I NOTICED NO EVIDENCE OF THE FLOOR MAT BEING ON THE ACCELERATOR OR IN A POSITION TO CAUSE THE SUDDEN ACCELERATION OR THE CONTINUED ENGINE RAPID RPMS. THE SAME DAY, THE ACCELERATOR STUCK A SECOND TIME AND REQUIRED ME TO PULL THE GAS PEDAL UP IN ORDER TO GET THE ENGINE TO RETURN TO NORMAL RPMS. *TR
THE REAR CLIMATE CONTROL KNOBS ARE TO HOT TO TOUCH AFTER TURNING THE VEHICLE ON. *TR
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WITH THE AIR CONDITIONER ACTIVATED WHEN SUDDENLY WITHOUT WARNING, THE AIR CONDITIONER BLOWER FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY WERE UNABLE TO LOCATE THE PROBLEM. THE FAILURE RECURRED FOR THE SEC…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WITH THE AIR CONDITIONER ACTIVATED WHEN SUDDENLY WITHOUT WARNING, THE AIR CONDITIONER BLOWER FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY WERE UNABLE TO LOCATE THE PROBLEM. THE FAILURE RECURRED FOR THE SECOND TIME AND THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER WHO SUGGESTED IMMEDIATELY AFTER THE FAILURE, THAT THE ENGINE BE TURNED OFF AND RESTARTED TO RESET THE AIR CONDITIONER BLOWER. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM AND WAS UNABLE TO PROVIDE A REMEDY FOR THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 10/18/11*LJ UPDATED 11/04/11
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT WAS TRAVELING 45 MPH WITH THE AIR CONDITIONER ACTIVATED WHEN THE AIR BECAME HOT. IN ADDITION, THE CONTACT SHUT OFF THE VEHICLE AND WAS UNABLE TO RESTART THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WAS 12,000. UPDATED 01/26/11*LJ THE CONSUMER STATED ALL THE GAUGES D…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT WAS TRAVELING 45 MPH WITH THE AIR CONDITIONER ACTIVATED WHEN THE AIR BECAME HOT. IN ADDITION, THE CONTACT SHUT OFF THE VEHICLE AND WAS UNABLE TO RESTART THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WAS 12,000. UPDATED 01/26/11*LJ THE CONSUMER STATED ALL THE GAUGES DROPPED TO ZERO AND THE WINDOWS WOULD NOT OPEN AFTER THE ENGINE WAS TURNED OFF. THE VEHICLE WOULD NOT RESTART FOR 45 MINUTES. THE VEHICLE WAS FIXED AFTER THE SECOND TIME. UPDATED 04/13/11
TL*THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING, SHE NOTICED A BELL RINGING INSIDE THE VEHICLE AND THE TEMPERATURE GAUGE WAS RISING. THE CONTACT CALLED THE DEALERSHIP WHO STATED THAT THE EMISSION SYSTEM MAY HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP …
Read full complaint
TL*THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING, SHE NOTICED A BELL RINGING INSIDE THE VEHICLE AND THE TEMPERATURE GAUGE WAS RISING. THE CONTACT CALLED THE DEALERSHIP WHO STATED THAT THE EMISSION SYSTEM MAY HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE VEHICLE WAS LOCATED AT THE TIME OF THE COMPLAINT; A MECHANIC STATED THAT THE PROBLEM WAS MOSTLY LIKELY IN RELATION TO THE ELECTRICAL SYSTEM. THE CONTACT CALLED THE MANUFACTURER AND ASKED TO RETURN THE VEHICLE; THE MANUFACTURER REFUSED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 150.
TL*THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE SERVICE STABILITRAK, SERVICE TRACTION CONTROL, PARK ASSIST OFF AND CHECK ENGINE LIGHTS ILLUMINATED. UPON RESTARTING THE VEHICLE, IT FUNCTIONED NORMALLY BUT THE CHECK ENGINE SERVICE LIGHT CONTINUED TO ILLUMINATE. THE VEHI…
Read full complaint
TL*THE CONTACT OWNS A 2010 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE SERVICE STABILITRAK, SERVICE TRACTION CONTROL, PARK ASSIST OFF AND CHECK ENGINE LIGHTS ILLUMINATED. UPON RESTARTING THE VEHICLE, IT FUNCTIONED NORMALLY BUT THE CHECK ENGINE SERVICE LIGHT CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE COMPUTER SYSTEM WAS RESET. THE FAILURE RECURRED THREE TIMES AND WAS TOWED TO AN AUTHORIZED DEALER. WHEN THE SECOND FAILURE OCCURRED, THE CONTACT WAS INFORMED THAT THERE WAS A WIRE UNDERNEATH THE HOOD WHICH WAS MISSING ITS PROTECTIVE COVERING AND NEEDED TO BE RE-COATED. THE WIRE WAS RECOATED AND THE VEHICLE BEGAN TO FUNCTION NORMALLY FOR APPROXIMATELY TWO MONTHS UNTIL THE FAILURE RECURRED TWICE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER ON BOTH OCCASIONS BUT THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 3,500 AND THE CURRENT MILEAGE WAS 9,000. UPDATED 10/05/10. *LJ
Official recalls
521V246000 · Air Bags:critical Fasteners
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
15V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
10V375000 · Seat Belts
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648