NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
19 reportsClear category filterMileage unknown · Apr 5, 2020
EnginePower TrainUnknown Or Other
I PURCHASED THE VEHICLE FROM USADOS AUTO SALES AND THE OWNER TOLD ME THE CAR HAD 185,000 ON IT. WELL AFTER PAYING CASH AND WAITING 27 DAYS I FINALLY RECEIVE THE TITLE AND IT SAYS IT HAS 260,000. THE BILL OF SALE HE SIGNED WHEN HE BOUGHT IT ALSO STATED THAT THE ACTUAL MILEAGE WASN'T CORRECT. HE FILED MY BILL OF SALE OUT AND DIDN'…
Read full complaint
I PURCHASED THE VEHICLE FROM USADOS AUTO SALES AND THE OWNER TOLD ME THE CAR HAD 185,000 ON IT. WELL AFTER PAYING CASH AND WAITING 27 DAYS I FINALLY RECEIVE THE TITLE AND IT SAYS IT HAS 260,000. THE BILL OF SALE HE SIGNED WHEN HE BOUGHT IT ALSO STATED THAT THE ACTUAL MILEAGE WASN'T CORRECT. HE FILED MY BILL OF SALE OUT AND DIDN'T INFORM ME OR EVEN RIGHT BACK THERE FORM HE LIED TO ME AND SAID IT WAS 185,000 SO I CONTACTED HIM AND HE SAID IT WAS SOMETHING HE OVERLOOKED TO JUST WRITE ON MY BILL OF SALE THE ACTUAL MILEAGE AND I TOLD HIM NO I WOULD YOU HAVE SPENT $2500 ON A VEHICLE WITH 260,000 MILES AND HE REFUSES TO HELP ME. NOW THE VEHICLES CHECK ENGINE LIGHT IS ON. IT LEAKING OIL AND THE RADIO DOESN'T WORK AND IT KEEPS BLOWING FUSES.
NHTSA ODI #11320269
158,000 miles · May 25, 2019
EngineUnknown Or Other
IF GM KNOWS ABOUT THE EXHAUST MANIFOLDS ON THESE TRAILBLAZERS THAT WARP AND LEAK EXHAUST WHY ARE THEY NOT FIXING THEM.IT'S A ON GOING PROBLEM
NHTSA ODI #11209908
Mileage unknown · Nov 23, 2018
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
I HAVE A 2006 CHEVY TRAILBLAZER WITH ONLY A LITTLE OVER 80,000 MILES ON IT. I HAVE BEEN HAVING ISSUES WITH THE STABILITRAK SYSTEM. I WILL GET READ OUTS ABOUT THE STABILITRAK NEEDS TO BE SERVICED OR THE STABILITRAK HAS KICKED IN WHEN IT HASN'T. THE STABILITRAK WILL TRY TO IN GAUGE FOR NO APPARENT REASON WHEN APPLING THE BRAKES. …
Read full complaint
I HAVE A 2006 CHEVY TRAILBLAZER WITH ONLY A LITTLE OVER 80,000 MILES ON IT. I HAVE BEEN HAVING ISSUES WITH THE STABILITRAK SYSTEM. I WILL GET READ OUTS ABOUT THE STABILITRAK NEEDS TO BE SERVICED OR THE STABILITRAK HAS KICKED IN WHEN IT HASN'T. THE STABILITRAK WILL TRY TO IN GAUGE FOR NO APPARENT REASON WHEN APPLING THE BRAKES. IT HAPPENS WHEN I AM BACKING OUT OF MY DRIVEWAY, COMING TO A STOP OR JUST APPLYING THE BRAKES TO SLOW DOWN. IT HAPPENS ON ALL TYPE OF ROAD SURFACES. THIS HAPPENS WHEN IT IS BRIGHT AND SUNNY OUTSIDE, ON DRY ROADS, HIGHWAYS, STREETS, DIRT ROADS AND DAY OR NIGHT. IT DOES IT AT FAST SPEEDS AND VERY LOW SPEEDS. IT MAKES A STRANGE NOISE WHEN THIS HAPPENS HOWEVER THE STABILITRAK DOESN'T FULLY IN GAUGE. THE REPAIR SHOP LOOKED AT IT AND TOLD ME THAT THEY THINK THE COMPUTER MODAL IS NOT COMMUNICATING WITH THE STABILITRAK SYSTEM. THIS STARTED A FEW WEEKS AGO. SO I'M NOT SURE HOW THIS WILL AFFECT THE BRAKES WHEN DRIVING ON THE SNOW AND ICY ROADS. I HAVE SEEN OTHER COMPLAINTS ON THE SAME TYPE OF ISSUES.
NHTSA ODI #11153319
110,000 miles · Jul 13, 2018
Unknown Or Other
WHEN DRIVING, THE CAR WILL STOP ACCELERATING, REDUCE SPEED EVEN WHEN I'M ON THE GAS. CAR CAN GO WEEKS WITHOUT PROBLEM, THEN IT HAPPENS. CHEVY CAN'T FIND ANYTHING WRONG. IT HAS HAPPENED ON THE EXPRESSWAY DRIVING 65+ MPH AND IN THE NEIGHBORHOOD DRIVING 20 MPH. HAS BEEN IN SHOP NUMEROUS TIMESTOO DANGEROUS TO DRIVE..
NHTSA ODI #11111212
117,000 miles · Dec 26, 2015
Unknown Or Other
WHILE TRAVELING AT NIGHT ON A LEVEL TWO-LANE HIGHWAY THAT CARRIES HIGH TRAFFIC RATES, THE VEHICLE SUDDENLY LOST ENGINE POWER, BEGAN TO FEEL AS THOUGH THE BRAKES CAME ON, THE DASHBOARD LIGHTS DIMMED, AND THE TRACTION CONTROL SYMBOL STARTED FLASHING. VEHICLES BEHIND ME QUICKLY BRAKED TO AVOID A REAR COLLISION, AS THEIR HEADLIGHT …
Read full complaint
WHILE TRAVELING AT NIGHT ON A LEVEL TWO-LANE HIGHWAY THAT CARRIES HIGH TRAFFIC RATES, THE VEHICLE SUDDENLY LOST ENGINE POWER, BEGAN TO FEEL AS THOUGH THE BRAKES CAME ON, THE DASHBOARD LIGHTS DIMMED, AND THE TRACTION CONTROL SYMBOL STARTED FLASHING. VEHICLES BEHIND ME QUICKLY BRAKED TO AVOID A REAR COLLISION, AS THEIR HEADLIGHT BEAMS RAPIDLY CHANGED DIRECTION AND DIPPED TOWARDS THE PAVEMENT. THEN ABOUT 6~8 SECONDS LATER THE TRACTION CONTROL LIGHT REMAINED ON FULL ILLUMINATION, THEN WENT OUT, AND THE ENGINE SPEED PICKED UP. AS I ALMOST WAS IN A SURPRISE REAR-END COLLISION, I TOOK THE VEHICLE TO THE NEAREST, OPEN CHEVROLET DEALER THE EARLIEST I COULD GET IT DIAGNOSED. IT TURNS OUT THE STEERING SENSOR WAS DEFECTIVE AND HAD TO BE REPLACED AT A COST OF $392.00. SURPRISE POWER LOSS AND SUBSEQUENT BRAKING MAKING A DANGEROUS SITUATION AT HIGHER HIGHWAY SPEEDS IS WHAT MADE ME GET IT REPAIRED AS SOON AS POSSIBLE.
NHTSA ODI #10816229
Mileage unknown · Nov 10, 2015
Unknown Or OtherFire
MY 2006 TRAILBLAZER WAS PARKED OUTSIDE NEXT TO MY HOME FOR 2 HOURS. IT SPONTANEOUSLY CAUGHT ON FIRE WHILE I WAS INSIDE ASLEEP. IT ENDED UP BURNING MY WHOLE HOUSE DOWN. WHEN I WOKE UP TO SEE FLAMES COMING FROM THE CAR INTO MY HOUSE, I CALLED 911 AND GOT MYSELF AND MY CHILDREN OUT OF THE HOUSE. MY CAR AND HOUSE WERE A TOTAL L…
Read full complaint
MY 2006 TRAILBLAZER WAS PARKED OUTSIDE NEXT TO MY HOME FOR 2 HOURS. IT SPONTANEOUSLY CAUGHT ON FIRE WHILE I WAS INSIDE ASLEEP. IT ENDED UP BURNING MY WHOLE HOUSE DOWN. WHEN I WOKE UP TO SEE FLAMES COMING FROM THE CAR INTO MY HOUSE, I CALLED 911 AND GOT MYSELF AND MY CHILDREN OUT OF THE HOUSE. MY CAR AND HOUSE WERE A TOTAL LOSS. I RECENTLY HEARD OF RECALL SAYING DON'T PARK YOUR 2006 TRAILBLAZER NEAR YOUR HOUSE...EVEN WHEN OFF IT MIGHT CATCH ON FIRE. I AM WONDERING IF THIS RECALL IS WHAT MADE MY CAR CATCH ON FIRE. THE EXACT CAUSE WAS NOT DETERMINED...IT WAS JUST DETERMINED IT WAS SPONTANEOUS . I WISH I HAD KNOWN OF RECALL IN 2010, AND WE WOULDN'T HAVE GONE THROUGH THIS NIGHTMARE!
NHTSA ODI #10789711
100,000 miles · Oct 21, 2015
Unknown Or Other
TRACTION CONTROL LIGHT AND THE LIGHT BESIDE IT STAY ON 24/7. I HAVE HAD IT AT MY MECHANIC WHO HAS SENT IT TO THE DEALERSHIP AS WELL AND HAVE REPLACED ALL PARTS BUT THE COMPUTER TO MY CAR. I CANNOT AFFORD TO REPLACE THE COMPUTER AND NOT KNOW IF THAT IS THE FIX. MY HEAD LIGHTS FLICKER AND SOME DAYS TURN OFF WHICH HAVE BEEN RECALLE…
Read full complaint
TRACTION CONTROL LIGHT AND THE LIGHT BESIDE IT STAY ON 24/7. I HAVE HAD IT AT MY MECHANIC WHO HAS SENT IT TO THE DEALERSHIP AS WELL AND HAVE REPLACED ALL PARTS BUT THE COMPUTER TO MY CAR. I CANNOT AFFORD TO REPLACE THE COMPUTER AND NOT KNOW IF THAT IS THE FIX. MY HEAD LIGHTS FLICKER AND SOME DAYS TURN OFF WHICH HAVE BEEN RECALLED BUT WHEN I GIVE MY VIN THE DEALER TELLS ME I HAVE ZERO RECALLS. THEY DO THIS WHEN SITTING STILL, DRIVING SLOW OR EVEN ON THE HIGHWAY. I HAVE CARS THINKING I AM FLASHING THEM SOME TIMES WHEN I AM NOT. IF I ROLL MY WINDOWS UP THEY DIM. I ALSO WAS PULLING OUT OF A PARKING LOT WHEN MY CAR STALLED ON ME. WHEN I COASTED DOWN THE HILL TO STOP, THE CAR STARTED. MY MECHANIC PUT IT ON COMPUTER BUT THE CODE WAS AN "UNEXPLAINED" REASON, BASICALLY NO ONE KNOW WHY OR IF MY CAR WILL DO IT AGAIN. I HAVE HAD ISSUES WITH THIS CAR FROM THE DAY I BOUGHT IT. I HAVE TAKEN IT TO DEALERSHIP OVER THE HEADLIGHTS BUT IT WAS DAYLIGHT AND THEY DID NOT SEE IT SO SAID THEY COULDN'T HELP ME. I AM SO OVER MY CAR, I AM TO THE POINT I WILL NOT OWN ANOTHER GM PRODUCT. I HAVE SEEN 3 RECALLS IN THE NEWS THAT MATCH MY YEAR AND MAKE, BUT MY "VIN" SAYS OTHERWISE. I FEEL LIKE I AM DRIVING A TICKING TIME BOMB. MY COMPUTER LIGHTS HAVE BEEN ON FOR 3 YEARS NOW, HEADLIGHTS HAVE DONE THIS SINCE I BOUGHT THE CAR IN 2008, AND IT STALLED BEGINNING OF SPRING 2015. I JUST WANT A SAFE RELIABLE VEHICLE!
NHTSA ODI #10785095
50,035 miles · Sep 25, 2015
Unknown Or Other
ON 07/08/2011 MILEAGE 50035 TRANSMISSION COOLING LINE RUSTED AND LEAKED SPRAYING TRANSMISSION FLUID ONTO EXHAUST MANIFOLD. LINE WAS REPLACED WITH FACTORY GM LINE. TODAY 09/25/2015 CURRENT MILEAGE 80292 MILES REPLACEMENT LINE RUSTED IN SAME PLACE AND LEAKED, SPRAYING TRANSMISSION FLUID ONTO EXHAUST MANIFOLD.
NHTSA ODI #10777774
Mileage unknown · Sep 21, 2015
SteeringUnknown Or OtherVehicle Speed Control
WHEN I MAKE LEFT OR RIGHT TURNS THE TRUCK SHUTS OFF ALL THE GAUGES READ AS NORMAL EXCEPT FOR THE RPM'S I LOOSE POWER STEARING AND CANNOT EXELERATE IT DOES NOT HAPPEN AT AN SPACIFIC TIME OR PLACE IT IS JUST RANDOM SO I DO NOT KNOW WHEN IT MAY DO THIS SOME DAYS NOTHING HAPPENS OTHER DAYS IT HAPPENS 2-4 TIMES AND IT IS A BIT SCAREY…
Read full complaint
WHEN I MAKE LEFT OR RIGHT TURNS THE TRUCK SHUTS OFF ALL THE GAUGES READ AS NORMAL EXCEPT FOR THE RPM'S I LOOSE POWER STEARING AND CANNOT EXELERATE IT DOES NOT HAPPEN AT AN SPACIFIC TIME OR PLACE IT IS JUST RANDOM SO I DO NOT KNOW WHEN IT MAY DO THIS SOME DAYS NOTHING HAPPENS OTHER DAYS IT HAPPENS 2-4 TIMES AND IT IS A BIT SCAREY WHEN YOU ARE MAKING A LEFT TURN ESPECIAL I AM NOT SURE WHAT THIS IS OR WHAT IS CAUSING IT BUT THIS I HAVE HAD THE BATTERY AND THE ALTERNATER CHECKED AND OTHER COMPONENTS CHECKED OUT BUT THEY COULD NOT FIND ANYTHING AND OF COURSE WHILE THE DEALER HAD IT DID NOT DO IT SO I AM NOT SURE BUT THIS IS DEFFENTLEY SOMETHING THAT NEEDS TO BE LOOKED INTO LIKE I SAY WHEN I MAKE TURNS I LOSE POWER , LOOSE MY STEARING AND THE ABLITY TO ACCELERATE AND ALL GAUGES READ NORMAL EXCEPT THE RPM'S THEY ARE THE ONLY ONE THAT GO DOWN TO ZERO
NHTSA ODI #10766429
Mileage unknown · May 19, 2015
Air BagsSteeringUnknown Or OtherCrashInjury
I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT OUT OF STATE. I WAS TRAVELING DURING THE EVENING HOURS TO TRY TO AVOID HEAVY TRAFFIC. I STARTED HAVING TROUBLE WITH THE DIM LIGHTS AND COULD ONLY PROCEED USING THE BRIGHT LIGHTS. THE NEXT THING I REALIZE IS THAT I AM UNABLE TO CONTROL THE VEHICLE AND STRUCK ANOTHER VEHICLE ON THE ROAD. I …
Read full complaint
I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT OUT OF STATE. I WAS TRAVELING DURING THE EVENING HOURS TO TRY TO AVOID HEAVY TRAFFIC. I STARTED HAVING TROUBLE WITH THE DIM LIGHTS AND COULD ONLY PROCEED USING THE BRIGHT LIGHTS. THE NEXT THING I REALIZE IS THAT I AM UNABLE TO CONTROL THE VEHICLE AND STRUCK ANOTHER VEHICLE ON THE ROAD. I THEN PROCEEDED TO SLIDE DOWN AN EMBANKMENT APPROXIMATELY 30 FEET. MY VEHICLE SUSTAINED ENORMOUS DAMAGE TO THE FRONT AND SIDE OF THE VEHICLE. THE FRONT AIRBAGS DID NOT DEPLOY AND MY VEHICLE WAS DEEMED TOTALED BY MY INSURER.
NHTSA ODI #10717398
Recall campaigns
8Sep 24, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.
Consequence & remedy
Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.
Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.
Aug 14, 2015
General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.
Consequence & remedy
Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.
Jul 2, 2014
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.
Jun 13, 2013
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
Additional source detail variants (2)
Visibility:power Window Devices And Controls
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
Electrical System
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
Aug 16, 2012
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
Additional source detail variants (2)
Visibility:power Window Devices And Controls
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
Electrical System
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Dec 7, 2005
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Oct 5, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
4RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA12004 · Driver's Master Power Window Switch
Opened Jun 11, 2012 · Closed Jun 21, 2013
Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (4)
Electrical System
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Electrical System
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
PE12003 · Driver's Master Power Window Switch
Opened Feb 9, 2012 · Closed Jun 11, 2012
Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
Visibility:power Window Devices And Controls
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration