IllustrationINTERMITTENT FAILURE OF WINDSHIELD WIPERS . FUNCTION ERRATICALLY OR WILL NOT TURN OFF. *TR
2004 Chevrolet Trailblazer
Owner reports · Recalls · Investigations
More warning signs than most Trailblazer years
Owner complaints for the 2004 Chevrolet Trailblazer are substantially higher than the model-year median of 87.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailblazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
16325–50K
27450–75K
17675–100K
137100–150K
61150K+
899 reports with mileage · 182 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 627 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
56 crash reports31 fire reports47 injury reports
What owners actually said
1,081 reportsSPEEDOMETER GETS STUCK ON HIGHER SPEED AND RPM METER GETS STUCK ON A HIGH LEVEL THEN STOPS WORKING THEN STARTS WORKING AGAIN BUT ON WRONG RPM LEVEL. HAVE TO RESTART VEHICLE 5-10 TIMES FOR IT TO GO DOWN. GM WANTS ME TO PAY FOR DIAGNOSIS THEN DECIDE WHETHER ITS COVERED OR NOT. GM SHOULD PAY FOR THE WHOLE THING SINCE ITS A COMMON P…
Read full complaint
SPEEDOMETER GETS STUCK ON HIGHER SPEED AND RPM METER GETS STUCK ON A HIGH LEVEL THEN STOPS WORKING THEN STARTS WORKING AGAIN BUT ON WRONG RPM LEVEL. HAVE TO RESTART VEHICLE 5-10 TIMES FOR IT TO GO DOWN. GM WANTS ME TO PAY FOR DIAGNOSIS THEN DECIDE WHETHER ITS COVERED OR NOT. GM SHOULD PAY FOR THE WHOLE THING SINCE ITS A COMMON PROBLEM WITH ALL THE CHEVY TRAILBLAZER. THE TRAILBLAZER ISN'T THAT OLD AND ONLY HAS 39,000 MILES ON IT. ALREADY HAD TO REPLACE A MASTER DOOR WINDOW/ LOCK SWITCH WHICH COST ME $400. VERY DISAPPOINTED WITH GM WITH MY TRAILBLAZER AND GM NOT DOING ANYTHING ABOUT THE LOUSY PRODUCT THEY PRODUCE. *TR
DRIVING ALONG AND ALL OF A SUDDEN THE SPEEDOMETER READS ZERO. ALL OTHER GAUGES WORK FINE. HAD DEALER FIX IT FOR 466.00 GM HAS BULLETIN OUT FOR THE PICKUPS AND SUVS BUT NOT THIS VEHICLE THAT USE THE SAME COMPONENTS. *TR
TL*THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING 45 MPH, THE SPEEDOMETER FAILED AND THE DIAL MOVED TO ZERO. NO REPAIRS HAVE YET BEEN MADE TO THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 56,000.
IN AUGUST 2008 MY SPEEDOMETER STARTED TO MALFUNCTION. IT WOULD NOT WORK FOR A FEW DAYS AND THEN GO BACK TO NORMAL. BY OCTOBER IT QUIT WORKING AT ALL. MY SERVICE ENGINE LIGHT ALSO STAYS ON. I HAVE ALSO EXPERIENCED SOME POWER SURGES THAT SEEM TO AFFECT THE LIGHTING SYSTEM. I ALSO HAD TO PROBLEM COMMENTED ON BY SEVERAL PEOPLE WIT…
Read full complaint
IN AUGUST 2008 MY SPEEDOMETER STARTED TO MALFUNCTION. IT WOULD NOT WORK FOR A FEW DAYS AND THEN GO BACK TO NORMAL. BY OCTOBER IT QUIT WORKING AT ALL. MY SERVICE ENGINE LIGHT ALSO STAYS ON. I HAVE ALSO EXPERIENCED SOME POWER SURGES THAT SEEM TO AFFECT THE LIGHTING SYSTEM. I ALSO HAD TO PROBLEM COMMENTED ON BY SEVERAL PEOPLE WITH THE LOW BEAM LIGHTS GOING OUT. I CHECKED ALL THE FUSES AND THEY WERE IN WORKING ORDER. I TOOK THE VEHICLE TO THE DEALERSHIP AND THEY SAID THE BULBS WERE BLOWN AND REPLACED THEM. I QUESTIONED THAT STATEMENT SOMEWHAT BECAUSE I HAD REPLACE ONE OF THE BULBS NOT A MONTH EARLIER. THE LIGHTS HAVE WORKED FINE SINCE EXCEPT FOR POWER SURGES. *TR
WE HAVE HAD A PROBLEM WITH OUR SERVICE ENGINE LIGHT COMING ON WITHIN THE PAST 2 WEEKS IN OUR 2004 TRAILBLAZER. AFTER GETTING IT DIAGNOSED IT IS BEING CAUSED BY THE FAN SPEED BEING TOO HIGH. AFTER DOING SOME RESEARCH THIS VEHICLE HAS HAD NUMEROUS REPAIRS FOR THE SAME ISSUE. WHY HAS GM NOT WARRANTED THIS!? WE HAVE GOTTEN CRAPPY SE…
Read full complaint
WE HAVE HAD A PROBLEM WITH OUR SERVICE ENGINE LIGHT COMING ON WITHIN THE PAST 2 WEEKS IN OUR 2004 TRAILBLAZER. AFTER GETTING IT DIAGNOSED IT IS BEING CAUSED BY THE FAN SPEED BEING TOO HIGH. AFTER DOING SOME RESEARCH THIS VEHICLE HAS HAD NUMEROUS REPAIRS FOR THE SAME ISSUE. WHY HAS GM NOT WARRANTED THIS!? WE HAVE GOTTEN CRAPPY SERVICE FROM THE DEALERSHIP AND WHILE OUR VEHICLE IS OUT OF WARRANTY NOW IT IS PAID FOR OUR WE WOULD HAVE GOTTEN RID OF IT ALREADY. *TR
TL*THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. SPORADICALLY, WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS COMPLETELY FAILED. THE CONTACT'S VISIBILITY WAS REDUCED. THE TECHNICIAN STATED THAT THE RELAY WAS THE CAUSE OF THE FAILURE; HOWEVER, THE REPAIR WOULD HAVE TO WAIT BECAUSE THE PARTS WERE ON BACKORDER. THE VEHICLE HAS N…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. SPORADICALLY, WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS COMPLETELY FAILED. THE CONTACT'S VISIBILITY WAS REDUCED. THE TECHNICIAN STATED THAT THE RELAY WAS THE CAUSE OF THE FAILURE; HOWEVER, THE REPAIR WOULD HAVE TO WAIT BECAUSE THE PARTS WERE ON BACKORDER. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 80,000.
MY SPEEDOMETER STOP WORKING. ONE DAY WHILE DRIVING, I CHECKED MY SPEED ONLY TO REALIZE THE SPEEDOMETER WAS NOT WORKING. A FEW DAYS LATER IT STARTED WORKING AGAIN. NOW THE NONE OF THE GAUGES (SPEEDOMETER, ODOMETER , ECT.) ARE WORKING. *TR
I PURCHASED A 2004 CHEVY TRAILBLAZER. EVERYTIME I FILL THE TANK I HAVE A STRONG ORDER OF GAS. I TOOK MY VEHICLE TO THE DEALERSHIP TODAY AND THEY TOLD ME THAT I HAVE A LEAK IN MY GAS TANK AND THAT I NEED A NEW GAS TANK. I SEARCHED AND FOUND THAT THERE ARE ALOT OF COMPLAINTS REGARDING THIS SAME ISSUE WITH OTHER TRAIL BLAZER OWNERS…
Read full complaint
I PURCHASED A 2004 CHEVY TRAILBLAZER. EVERYTIME I FILL THE TANK I HAVE A STRONG ORDER OF GAS. I TOOK MY VEHICLE TO THE DEALERSHIP TODAY AND THEY TOLD ME THAT I HAVE A LEAK IN MY GAS TANK AND THAT I NEED A NEW GAS TANK. I SEARCHED AND FOUND THAT THERE ARE ALOT OF COMPLAINTS REGARDING THIS SAME ISSUE WITH OTHER TRAIL BLAZER OWNERS. I WOULD LIKE FOR GM TO COMPENSATE OR PAY FOR THE REPAIRS THAT I HAD NO IDEA ABOUT. I WOULD NOT HAVE PURCHASED THE VEHICLE IF I KNEW THAT IT HAD A COMPLAINT OF THIS MAGNITUDE. THIS IS A COSTLY REPAIR. EVEN AT THE PRICE OF GAS - I DO NOT HAVE MONEY TO WASTE PURCHASING IT FOR IT TO JUST LEAK OUT MY VEHICLE. I AM ALSO REQUIRED TO TAKE THE VEHICLE THROUGH EMISSIONS BUT CAN NOT UNTIL THE "SERVICE ENGINE SOON" LIGHT GOES OFF. IT WON'T GO OFF UNTIL THE GAS TANK IS FIXED. MY LICENSE IIS IN JEOPARDY BECAUSE OR STATE (ILLINOIS) REQUIRES THAT THIS IS DONE WITHIN A CERTAIN TIME PERIOD. I HAVE ALREADY RECEIVED 1 TICKET FOR THIS BECAUSE MY PLATES CAN NOT BE RENEWED AS WELL UNTIL THE EMISSIONS HAS PASSED. *TR
THE LOW BEAM HEADLIGHT QUIT WORKING AFTER FURTHER INVESTIGATION FOUND ALL FUSES TO BE IN GOOD WORKING ORDER AS WELL AS ALL RELAYS AND THE DIMMER SWITCH, AFTER CHECKING THE BULBS IN THE LOW BEAM ASSEMBLY THE BULBS WERE NOT CHARRED OR BURNT AND THE FILAMENT WAS STILL IN CONTACT AS NORMAL, AFTER READING SOME EXCERPTS ON ANOTHER WEB…
Read full complaint
THE LOW BEAM HEADLIGHT QUIT WORKING AFTER FURTHER INVESTIGATION FOUND ALL FUSES TO BE IN GOOD WORKING ORDER AS WELL AS ALL RELAYS AND THE DIMMER SWITCH, AFTER CHECKING THE BULBS IN THE LOW BEAM ASSEMBLY THE BULBS WERE NOT CHARRED OR BURNT AND THE FILAMENT WAS STILL IN CONTACT AS NORMAL, AFTER READING SOME EXCERPTS ON ANOTHER WEBSITE THIS IS AN ALL TO FAMILIAR INCIDENT. LUCKILY WE WERE NOT DRIVING AT NIGHT AND NO ONE WAS INJURED THANKFULLY. ITS TIME FOR A RECALL BEFORE SOMEONE IS INJURED AND OR KILLED FROM THIS TYPE OF MANUFACTURING MALFUNCTION. *TR
Official recalls
205V198000 · Exterior Lighting:turn Signal
May 5, 2005
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
04V527000 · Exterior Lighting:brake Lights
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04032 · Brake Lamp Failure
Opened Apr 6, 2004 · Closed Aug 3, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON MODEL YEAR (MY) 2002-04 CHEVROLET TRAILBLAZER VEHICLES.GM REPORTS THAT OTHER VEHICLES SHARING THIS PLATFORM AND BRAKE LAMP DESIGN ARE THE MY 2002-2004 CHEVROLET TRAILBLAZER EXT; GMC ENVOY, XL, XUV; OLDSMOBILE BRAVADA AND 2004 BUICK RAINIER.COMPLAINTS ALLEGE THAT THE REAR BRAKE LAMP DOES NOT OPERATE WHEN THE BRAKE PEDAL IS DEPRESSED.THERE IS NO INDICATION TO THE DRIVER FROM INSIDE THE VEHICLE THAT ONE OR MORE BRAKE LAMPS BULBS ARE NOT FUNCTIONING.GM FOUND THAT HEAT FROM THE BULB COULD DEFORM THE LAMP SOCKET, PRODUCE ELECTRICAL ARCING AND AN INOPERATIVE BULB.TO CORRECT THE CONDITION, GM CHANGED THE BULB TO A BULB THAT TRANSMITS LESS HEAT TO THE SOCKET AND CHANGED THE SOCKET TO A THERMOPLASTIC POLYMER TO IMPROVE THERMAL STABILITY.THESE CHANGES WERE IMPLEMENTED INTO PRODUCTION VEHICLES ON OCTOBER 1, 2003.GM IMPLEMENTED A SPECIAL POLICY BY NOTIFYING CONSUMERS THAT IF THEY SHOULD EXPERIENCE A BRAKE LAMP FAILURE TO GO TO THEIR GM DEALERSHIP TO HAVE THE CIRCUIT BOARD CONTAINING THE BRAKE LAMP REPLACED ALONG WITH NEW BULBS.THIS POLICY IS GOOD FOR THE FIRST 6 YEARS OR 72,000 MILES OF THE LIFE OF THE VEHICLE.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-021 AND INCLUDE THE ABOVE MENTIONED VEHICLES.