NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
65 reportsClear category filterMileage unknown · Jul 6, 2004
Engine And Engine CoolingEquipmentExterior Lighting
CONSUMER WAS STOPPED BY A POLICE OFFICER, WHO INFORMED CONSUMER THAT THE TAIL LIGHTS WERE OUT. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TAIL LIGHTS NEEDED TO BE REPLACED. ALSO, VEHICLE STALLED WHILE DRIVING AT ANY SPEED. *AK THE VEHICLE WOULD HESITATE AND SKIP UPON ACCELERATION, AT…
Read full complaint
CONSUMER WAS STOPPED BY A POLICE OFFICER, WHO INFORMED CONSUMER THAT THE TAIL LIGHTS WERE OUT. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TAIL LIGHTS NEEDED TO BE REPLACED. ALSO, VEHICLE STALLED WHILE DRIVING AT ANY SPEED. *AK THE VEHICLE WOULD HESITATE AND SKIP UPON ACCELERATION, AT STOP SIGNS. TRAFFIC LIGHTS AND WHILE PARKING ON INCLINES. MULTIPLE COMPONENTS WERE REPLACED TO CORRECT THE PROBLEM BUT THEY RECURRED. THE RADIO BECAME EXTREMELY HOT WHILE DRIVING ON LONG TRIPS. THE RADIO WAS REPLACED BUT THE PROBLEM CONTINUED. THE A/C UNIT FAILED INTERMITTENTLY BECAUSE OF A FAULTY A/C SWITCH. THE CONSUMER MENTIONED FUEL SYSTEM PROBLEMS. *NM
NHTSA ODI #10065034
8,000 miles · Apr 27, 2004
Engine And Engine Cooling
TRAVELING ON HIGHWAY ENGINE DIES WHILE GOING 65 MPH . ALSO DIES AT IDLE DEALER COULD NOT DUPLICATE. *AK
NHTSA ODI #10067937
15,600 miles · Apr 21, 2004
Engine And Engine Cooling
WHILE DRIVING VEHICLE HESITATED THEN STALLED. CONSUMER WAS ABLE TO RESTART THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10068591
16,333 miles · Feb 10, 2004
Engine And Engine Cooling
WHILE DRIVING VEHICLE STALLED. CONSUMER MANAGED TO PULL OVER AND RESTART THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10057824
9,000 miles · Jan 29, 2004
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD THE EXACT PROBLEMS AS STATED IN 10047425. WINDSHIELD WIPERS WENT OUT COMPLETELY ON A RAINY DAY, MODULE REPLACED, A/C BROKE ON A HOT DAY-FIXED, POWER STEERING ASSIST STOPPED WORKING COMPLETELY MAKING DRIVING THE VEHICLE NEARLY IMPOSSIBLE, VEHICLE STARTED ON RESERVE POWER WHEN TEMP HIT -6 DEGREES, HEATER MOTOR STOPPED…
Read full complaint
I HAVE HAD THE EXACT PROBLEMS AS STATED IN 10047425. WINDSHIELD WIPERS WENT OUT COMPLETELY ON A RAINY DAY, MODULE REPLACED, A/C BROKE ON A HOT DAY-FIXED, POWER STEERING ASSIST STOPPED WORKING COMPLETELY MAKING DRIVING THE VEHICLE NEARLY IMPOSSIBLE, VEHICLE STARTED ON RESERVE POWER WHEN TEMP HIT -6 DEGREES, HEATER MOTOR STOPPED WORKING COMPLETELY THE NEXT DAY -10 DEGREES. BASICALLY THIS VEHICLE DOESN'T LIKE CHANGES IN WEATHER. *AK
NHTSA ODI #10055194
17,000 miles · Jan 21, 2004
Engine And Engine Cooling
VEHICLE'S REDUCED POWER LIGHT STAYED ON. AS A RESULT, VEHICLE'S POWER FAILED. *AK
NHTSA ODI #10055565
Mileage unknown · Jan 14, 2004
Engine And Engine CoolingEquipmentExterior Lighting
CONSUMER TOOK VEHICLE TO REPAIR SHOP BECAUSE OF THE FOLLOWING PROBLEMS; RACK AND PINION FAILED TWICE/AIR CONDITIONER MALFUNCTIONED TWICE/VEHICLE STALLED AT TAKE OFF/ OIL LEAK, AND BRAKE LIGHTS FAILED TO OPERATE PROPERLY. ALSO, VEHICLE MADE A LOUD NOISE ON DRIVER'S SIDE WHILE DRIVING. *AK
NHTSA ODI #10054097
4,000 miles · Jan 7, 2004
Engine And Engine Cooling
WHEN IT IS COLD OUTSIDE AND THE ENGINE IS STARTED IT KNOCKS AND TICKS UNTIL WARMED UP. GM CUSTOMER SERVICE WILL OFFER ADDITIONAL MILES ON THE WARRANTY BUT NO ADDITIONAL TIME. THE DEALERS WILL NOT FIX THE PROBLEM. GM SAYS IT IS A PISTON PROBLEM. THIS PROBLEM HAPPENS EVERY DAY BELOW 50 DEGREES. THAT IS 8 MONTHS OF THE YEAR IN MI…
Read full complaint
WHEN IT IS COLD OUTSIDE AND THE ENGINE IS STARTED IT KNOCKS AND TICKS UNTIL WARMED UP. GM CUSTOMER SERVICE WILL OFFER ADDITIONAL MILES ON THE WARRANTY BUT NO ADDITIONAL TIME. THE DEALERS WILL NOT FIX THE PROBLEM. GM SAYS IT IS A PISTON PROBLEM. THIS PROBLEM HAPPENS EVERY DAY BELOW 50 DEGREES. THAT IS 8 MONTHS OF THE YEAR IN MICHIGAN. THE TRUCK IS EMBARRASSINGLY LOUD. SOUNDS LIKE IT IS 20 YEARS OLD. IT IS ONLY 5 MONTHS OLD.*AK
NHTSA ODI #10052596
2,392 miles · Nov 25, 2003
Electrical SystemEngine And Engine CoolingEquipment
MY 11-MONTH OLD 2003 CHEVROLET TRAILBLAZER HAS HAD MULTIPLE QUALITY PROBLEMS, TWICE AFFECTING MY SAFETY. MOST OF THE PROBLEMS HAVE BEEN ELECTRICAL IN NATURE. THE 4WD HAS BECOME INOPERABLE NUMEROUS TIMES, ONCE WHILE DRIVING IN SNOW. IN ANOTHER INCIDENT DURING A SEVERE THUNDERSTORM AT NIGHT THE AIR CONDITIONER (A/C) FAILED AND I W…
Read full complaint
MY 11-MONTH OLD 2003 CHEVROLET TRAILBLAZER HAS HAD MULTIPLE QUALITY PROBLEMS, TWICE AFFECTING MY SAFETY. MOST OF THE PROBLEMS HAVE BEEN ELECTRICAL IN NATURE. THE 4WD HAS BECOME INOPERABLE NUMEROUS TIMES, ONCE WHILE DRIVING IN SNOW. IN ANOTHER INCIDENT DURING A SEVERE THUNDERSTORM AT NIGHT THE AIR CONDITIONER (A/C) FAILED AND I WAS UNABLE TO DEFROST MY WINDSHIELD IN ORDER TO SEE. AFTER ONE DEALER FAILED TO DIAGNOSE THE 4WD PROBLEM, ANOTHER DEALER REPLACED MY IGNITION SWITCH BECAUSE THE TECHNICIAN SAID I HAD NO POWER AT ALL GOING TO THE "REAR GRID." I CONTINUE TO HAVE INTERMITTENT ELECTRICAL PROBLEMS, INCLUDING NEAR STALLING AT A TRAFFIC LIGHT, AND ONGOING 4WD FAILURES. THE CAR ALSO HAS VERY JERKY MOTION WHEN IN 4WD REVERSE, OF COURSE, WHEN THE 4WD IS WORKING AT ALL. THE DEALER TOLD ME THAT WAS NORMAL AND NOW I SEE THERE IS A SERVICE BULLETIN ON THE PROBLEM. *LA
NHTSA ODI #10047515
Mileage unknown · Oct 19, 2003
Engine And Engine CoolingExterior LightingVisibility
SINCE I BOUGHT THIS VEHICLE AUGUST 30, 2002 I HAVE HAD TO BRING IT BACK TO THE DEALERSHIP ON NUMEROUS OCCASIONS FOR SEVERAL DIFFERENT ITEMS. I HAVE HAD BOTH THE LEFT AND RIGHT BRAKE LIGHTS GONE OUT, THE DRIVER SIDE HEAD LAMP WENT OUT, THE AIR CONDITIONER HAS GONE OUT TWICE(FOUR MONTHS APART), THE DRIVER SIDE PASSENGER WINDOW IS …
Read full complaint
SINCE I BOUGHT THIS VEHICLE AUGUST 30, 2002 I HAVE HAD TO BRING IT BACK TO THE DEALERSHIP ON NUMEROUS OCCASIONS FOR SEVERAL DIFFERENT ITEMS. I HAVE HAD BOTH THE LEFT AND RIGHT BRAKE LIGHTS GONE OUT, THE DRIVER SIDE HEAD LAMP WENT OUT, THE AIR CONDITIONER HAS GONE OUT TWICE(FOUR MONTHS APART), THE DRIVER SIDE PASSENGER WINDOW IS INOPERABLE(WE HAVE TRIED TO GET IT FIXED FOR ALMOST A MONTH NOW WITH NO SUCCESS) AND THE ENGINE COOLING FAN WAS WARPED AND THE FAN CLUTCH MALFUNCTIONED. AT THIS POINT WE DON'T UNDERSTAND WHY THEY HAVEN'T JUST RECALLED THE WHOLE VEHICLE. LUCKILY WE HAVE THE 36,000 MILE WARRANTY STILL IN AFFECT BUT WHAT'S GOING TO HAPPEN WHEN IT IS UP AND THE SAME PROBLEMS KEEP RECURRING? *LA
NHTSA ODI #10043192
Official recalls
8May 5, 2005
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Apr 23, 2003
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED.
Consequence & remedy
Consequence: IF BRAKING PERFORMANCE IS REDUCED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-8006.
Mar 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence & remedy
Consequence: THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy: DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04032 · Brake Lamp Failure
Opened Apr 6, 2004 · Closed Aug 3, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON MODEL YEAR (MY) 2002-04 CHEVROLET TRAILBLAZER VEHICLES.GM REPORTS THAT OTHER VEHICLES SHARING THIS PLATFORM AND BRAKE LAMP DESIGN ARE THE MY 2002-2004 CHEVROLET TRAILBLAZER EXT; GMC ENVOY, XL, XUV; OLDSMOBILE BRAVADA AND 2004 BUICK RAINIER.COMPLAINTS ALLEGE THAT THE REAR BRAKE LAMP DOES NOT OPERATE WHEN THE BRAKE PEDAL IS DEPRESSED.THERE IS NO INDICATION TO THE DRIVER FROM INSIDE THE VEHICLE THAT ONE OR MORE BRAKE LAMPS BULBS ARE NOT FUNCTIONING.GM FOUND THAT HEAT FROM THE BULB COULD DEFORM THE LAMP SOCKET, PRODUCE ELECTRICAL ARCING AND AN INOPERATIVE BULB.TO CORRECT THE CONDITION, GM CHANGED THE BULB TO A BULB THAT TRANSMITS LESS HEAT TO THE SOCKET AND CHANGED THE SOCKET TO A THERMOPLASTIC POLYMER TO IMPROVE THERMAL STABILITY.THESE CHANGES WERE IMPLEMENTED INTO PRODUCTION VEHICLES ON OCTOBER 1, 2003.GM IMPLEMENTED A SPECIAL POLICY BY NOTIFYING CONSUMERS THAT IF THEY SHOULD EXPERIENCE A BRAKE LAMP FAILURE TO GO TO THEIR GM DEALERSHIP TO HAVE THE CIRCUIT BOARD CONTAINING THE BRAKE LAMP REPLACED ALONG WITH NEW BULBS.THIS POLICY IS GOOD FOR THE FIRST 6 YEARS OR 72,000 MILES OF THE LIFE OF THE VEHICLE.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-021 AND INCLUDE THE ABOVE MENTIONED VEHICLES.
EA04002 · Windshield Wiper Failure
Opened Jan 6, 2004 · Closed Feb 10, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
PE03042 · Windshield Wiper Failure
Opened Sep 17, 2003 · Closed Jan 6, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Illustration