NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
310 reportsClear category filter100,100 miles · Dec 20, 2012
EnginePower Train
I STARTED MY TRAILBLAZER AND LET IT WARM FOR A FEW MINUTES. THE TRUCK IDLE WAS LOUDER THEN NORMAL BUT DID NOT KNOCK OR MISS. I PUT THE TRUCK INTO DRIVE AND PULLED OUT OF MY DRIVEWAY. AS I WAS DRIVING DOWN THE STREET I NOTICED THE RPMS SHOOT UP AND THE TRUCK SLOW, I PULLED OVER AND PUT IT INTO PARK, THE TRUCK IDLED LOUDLY. I PUT …
Read full complaint
I STARTED MY TRAILBLAZER AND LET IT WARM FOR A FEW MINUTES. THE TRUCK IDLE WAS LOUDER THEN NORMAL BUT DID NOT KNOCK OR MISS. I PUT THE TRUCK INTO DRIVE AND PULLED OUT OF MY DRIVEWAY. AS I WAS DRIVING DOWN THE STREET I NOTICED THE RPMS SHOOT UP AND THE TRUCK SLOW, I PULLED OVER AND PUT IT INTO PARK, THE TRUCK IDLED LOUDLY. I PUT THE TRUCK INTO DRIVE AGAIN AND THE RPM WOULD RISE WITH LITTLE POWER TO THE WHEELS. I NURSED IT UP TO HIGHWAY SPEED AND AT HIGHER SPEEDS AROUND 60 THE PROBLEM SEEMS TO NOT BE THERE. THE TRUCK CONTINUES TO DO THIS IN THE LOWER GEARS AND AT LOWER SPEEDS. I NOTICE THE OIL PRESSURE GOES UP WHEN THIS HAPPENS AND I WORRY OF DOING MORE DAMAGE. I HAVE ALREADY HAD A WIPER MODULE REPLACED THAT WAS RECALLED BUT NEVER REPLACED BEFORE THE VEHICLE WAS SOLD TO ME. *TR
NHTSA ODI #10489417
74,888 miles · Aug 9, 2012
Power Train
I OWN A 2002 CHEVROLET TRAILBLAZER THAT HAS A DEFECTIVE TRANSMISSION. THE TRANSMISSION HAS BEEN COMPLETELY REPLACED TWICE AT APPROXIMATELY 24,000 MILES AND 45,000 MILES. I LEARNED RECENTLY ON AUGUST 7, 2012, AT JUST UNDER 75,000 MILES, THAT THE TRANSMISSION HOSES WERE LEAKING FLUID AND THAT THE TRANSMISSION WOULD NEED TO BE COMP…
Read full complaint
I OWN A 2002 CHEVROLET TRAILBLAZER THAT HAS A DEFECTIVE TRANSMISSION. THE TRANSMISSION HAS BEEN COMPLETELY REPLACED TWICE AT APPROXIMATELY 24,000 MILES AND 45,000 MILES. I LEARNED RECENTLY ON AUGUST 7, 2012, AT JUST UNDER 75,000 MILES, THAT THE TRANSMISSION HOSES WERE LEAKING FLUID AND THAT THE TRANSMISSION WOULD NEED TO BE COMPLETELY REPLACED AGAIN. I THINK GENERAL MOTORS RELEASED A DEFECTIVE SPORTS UTILITY VEHICLE IF THE TRANSMISSION NEEDS TO BE REPLACE APPROXIMATELY EVERY 25,000 MILES AND THESE AUTOMOBILES SHOULD BE RECALLED AS IT COULD CAUSE A SAFETY HAZARD IF THE TRANSMISSION STOPS WORKING WHEN SOMEONE IS DRIVING A CHEVROLET TRAILBLAZER. *TR
NHTSA ODI #10469941
186,000 miles · May 23, 2012
Power Train
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE TRANSMISSION WOULD NOT SHIFT INTO THIRD AND FOURTH GEARS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO FILED A REPORT AND OFFERED NO FURTHER ASSISTANCE TO THE CONTACT. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE TRANSMISSION WOULD NOT SHIFT INTO THIRD AND FOURTH GEARS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO FILED A REPORT AND OFFERED NO FURTHER ASSISTANCE TO THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 186,000.
NHTSA ODI #10459480
Mileage unknown · May 22, 2012
Power Train
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FOUR WHEEL DRIVE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AS THE FOUR WHEEL DRIVE FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSFER CASE CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT SPOKE WITH THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FOUR WHEEL DRIVE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AS THE FOUR WHEEL DRIVE FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSFER CASE CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT SPOKE WITH THE MANUFACTURER IN REFERENCE TO NHTSA RECALL CAMPAIGN ID NUMBER: 01V334000 (POWER TRAIN: TRANSFER CASE: 4-WHEEL DRIVE), BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10459274
Mileage unknown · May 16, 2012
Power Train
TSB #PIT-4722 -- GMC: FLUID LEAK FROM TRANSMISSION OIL COOLER LINES DUE TO CORROSION. ALL 2000-2006 LIGHT DUTY TRUCKS EQUIPPED WITH THE LIGHT DUTY AUTOMATIC TRANSMISSION. *PE (NHTSA ID #10026804, OCTOBER 01 2008)
NHTSA ODI #10458754
Mileage unknown · May 8, 2012
Power Train
AUTOMATIC TRANSMISSION SUNSHELL FAILED, DRIVING AND THE TRUCK DIDN'T GO INTO GEAR. SLOWING WENT IN GEAR, CAUSE STRUGGLE DRIVING...AS I TURN TO HELD BACK HOME THE SUV REFUSED TO GO IN TO REAR.TOOK TO TRANSMISSION SHOP FAILED SUNSHELL NEED NEW TRANSMISSION. COSTLY..START SLIPPED IN AND OUT OF GEAR WEEK BEFORE ENGINE LIGHT CAME ON…
Read full complaint
AUTOMATIC TRANSMISSION SUNSHELL FAILED, DRIVING AND THE TRUCK DIDN'T GO INTO GEAR. SLOWING WENT IN GEAR, CAUSE STRUGGLE DRIVING...AS I TURN TO HELD BACK HOME THE SUV REFUSED TO GO IN TO REAR.TOOK TO TRANSMISSION SHOP FAILED SUNSHELL NEED NEW TRANSMISSION. COSTLY..START SLIPPED IN AND OUT OF GEAR WEEK BEFORE ENGINE LIGHT CAME ON. THE SLIPPAGE OF GEAR HAVE ALMOST CAUSED SEVERAL ACCIDENT WHEN ENTER HIGHWAYS OR LANS. *TR
NHTSA ODI #10457838
86,000 miles · Apr 20, 2012
Power Train
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE VEHICLE VIOLENTLY JERKED WHILE CHANGING GEARS. IN ADDITION, THERE WOULD BE AN INCREASE IN THE ENGINE RPMS WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT THE VEHICLE ROLLED BACKWARD TWO AND A HALF FEET AFTER BEING PARKED. THE VEHICLE HAD…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE VEHICLE VIOLENTLY JERKED WHILE CHANGING GEARS. IN ADDITION, THERE WOULD BE AN INCREASE IN THE ENGINE RPMS WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT THE VEHICLE ROLLED BACKWARD TWO AND A HALF FEET AFTER BEING PARKED. THE VEHICLE HAD NOT BEEN INSPECTED AND HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.
NHTSA ODI #10455861
102,000 miles · Mar 22, 2012
Power Train
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE VEHICLE WOULD SHIFT AUTOMATICALLY WITHOUT ACTIVATION OR WARNING AND AT ANY SPEED. IN ADDITION, THE CONTACT WOULD HEAR A GRINDING NOISE WHEN THE FAILURE OCCURRED. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE BUT TO NO AVAIL. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE VEHICLE WOULD SHIFT AUTOMATICALLY WITHOUT ACTIVATION OR WARNING AND AT ANY SPEED. IN ADDITION, THE CONTACT WOULD HEAR A GRINDING NOISE WHEN THE FAILURE OCCURRED. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE BUT TO NO AVAIL. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 104,370 AND THE FAILURE MILEAGE WAS 102,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10452682
110,000 miles · Mar 4, 2012
Power Train
I HAD TO REPLACE ALL MY TRANSMISSION COOLER LINES DUE TO THE LINES BEING CORRODED AND LEAKING. THESE WERE THE ONLY LINES THAT WERE CORRODED OR SHOWED SIGNS OF CORROSION. THERE IS NO REASON THIS SHOULD HAPPEN TO ALMOST EVERY GMT360. THIS SHOULD BE A RECALL. *TR
NHTSA ODI #10450178
47,000 miles · Feb 28, 2012
Power Train
MY CHEVROLET TRAILBLAZER BLEW ITS TRANSMISSION FOR THE 1ST TIME ON 6/1/06 AT 47000 MILES. THE REPAIR QUOTE WAS $2700 BUT CHEVY ENDED UP COVERING ALL BUT $200 AS A WARRANTY REPAIR. ON 2/24/12, IT BLEW ITS TRANSMISSION FOR THE 2ND TIME AT 94000 MILES. THE CAR STILL HAS ITS ORIGINAL BRAKES, BUT IS NOW ON TRANSMISSION #3. THE REP…
Read full complaint
MY CHEVROLET TRAILBLAZER BLEW ITS TRANSMISSION FOR THE 1ST TIME ON 6/1/06 AT 47000 MILES. THE REPAIR QUOTE WAS $2700 BUT CHEVY ENDED UP COVERING ALL BUT $200 AS A WARRANTY REPAIR. ON 2/24/12, IT BLEW ITS TRANSMISSION FOR THE 2ND TIME AT 94000 MILES. THE CAR STILL HAS ITS ORIGINAL BRAKES, BUT IS NOW ON TRANSMISSION #3. THE REPAIR QUOTE THIS TIME IS $3038. OBVIOUSLY THERE IS A DESIGN DEFECT IN THIS TRANSMISSION, AS THE CAR IS JUST DRIVEN UNDER AVERAGE CONDITIONS (NO TOWING, NO HEAVY LOADS, ETC.) *TR
NHTSA ODI #10449531
Official recalls
12Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Apr 28, 2004
CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.
Remedy: DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Mar 19, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL CLUSTER MAY NOT PROPERLY POWER UP, RESULTING IN MOST OF THE DISPLAYS, TELLTALE LIGHTS, AND FUNCTIONS (EXCEPT THE SERVICE ENGINE LIGHT, TURN SIGNAL INDICATORS, AND THE INSTRUMENT PANEL CLUSTER BACKLIGHTING) BEING INOPERATIVE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER. OWNER NOTIFICATION BEGAN MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Mar 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence & remedy
Consequence: THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy: DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Oct 4, 2002
CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.
Consequence & remedy
Consequence: IN A CRASH, MISSING WELDS COULD DEGRADE PERFORMANCE OF THE THIRD ROW SEAT AND SAFETY BELT ANCHORAGE AND OCCUPANTS COULD RECEIVE GREATER INJURIES.
Remedy: DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF MISSING WELDS ARE FOUND, GM WILL EXCHANGE THE VEHICLE FOR AN EQUIVALENT VEHICLE OR PROVIDE A REFUND OF THE PURCHASE PRICE. OWNER NOTIFICATION BEGAN OCTOBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Aug 23, 2002
ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.
Consequence & remedy
Consequence: IF THE FITTING BECOMES DISCONNECTED WHILE THE VEHICLE IS IN MOTION, THE ENGINE WOULD STOP DUE TO INADEQUATE FUEL SUPPLY AND CAUSE A LOSS OF POWER STEERING ASSIST. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE FROM A DISCONNECTED FUEL FILTER FITTING COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER QUICK CONNECT RETAINERS. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Oct 17, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.
Consequence & remedy
Consequence: IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.
Remedy: DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Sep 5, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A COMPLETE FRACTURE OF THE RANGE SHIFT COLLAR AND SUBSEQUENT LOSS OF VEHICLE FORWARD AND REVERSE GEARS, AND THE INABILITY TO MAINTAIN "PARK" POSITION. THIS INCREASES THE RISK OF A VEHICLE CRASH RESULTING FROM UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Remedy: DEALERS WILL REPLACE THE TRANSFER CASES AND UPDATE THE CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Apr 12, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.
Consequence & remedy
Consequence: A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, RESULTING IN A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CONTROL ARM BRACKETS. OWNER NOTIFICATION BEGAN BY TELEPHONE ON APRIL 4, 2001. THE FOLLOWUP LETTER TO CONSUMERS WAS MAILED MAY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04032 · Brake Lamp Failure
Opened Apr 6, 2004 · Closed Aug 3, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON MODEL YEAR (MY) 2002-04 CHEVROLET TRAILBLAZER VEHICLES.GM REPORTS THAT OTHER VEHICLES SHARING THIS PLATFORM AND BRAKE LAMP DESIGN ARE THE MY 2002-2004 CHEVROLET TRAILBLAZER EXT; GMC ENVOY, XL, XUV; OLDSMOBILE BRAVADA AND 2004 BUICK RAINIER.COMPLAINTS ALLEGE THAT THE REAR BRAKE LAMP DOES NOT OPERATE WHEN THE BRAKE PEDAL IS DEPRESSED.THERE IS NO INDICATION TO THE DRIVER FROM INSIDE THE VEHICLE THAT ONE OR MORE BRAKE LAMPS BULBS ARE NOT FUNCTIONING.GM FOUND THAT HEAT FROM THE BULB COULD DEFORM THE LAMP SOCKET, PRODUCE ELECTRICAL ARCING AND AN INOPERATIVE BULB.TO CORRECT THE CONDITION, GM CHANGED THE BULB TO A BULB THAT TRANSMITS LESS HEAT TO THE SOCKET AND CHANGED THE SOCKET TO A THERMOPLASTIC POLYMER TO IMPROVE THERMAL STABILITY.THESE CHANGES WERE IMPLEMENTED INTO PRODUCTION VEHICLES ON OCTOBER 1, 2003.GM IMPLEMENTED A SPECIAL POLICY BY NOTIFYING CONSUMERS THAT IF THEY SHOULD EXPERIENCE A BRAKE LAMP FAILURE TO GO TO THEIR GM DEALERSHIP TO HAVE THE CIRCUIT BOARD CONTAINING THE BRAKE LAMP REPLACED ALONG WITH NEW BULBS.THIS POLICY IS GOOD FOR THE FIRST 6 YEARS OR 72,000 MILES OF THE LIFE OF THE VEHICLE.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-021 AND INCLUDE THE ABOVE MENTIONED VEHICLES.
EA04002 · Windshield Wiper Failure
Opened Jan 6, 2004 · Closed Feb 10, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03042 · Windshield Wiper Failure
Opened Sep 17, 2003 · Closed Jan 6, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
PE02093 · 2002 Trailblazer/envoy Fuel Tank Leaks
Opened Dec 17, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
SEE ATTACHED REPORT.
Additional source detail variants (2)
Fuel System, Gasoline:storage
SEE ATTACHED REPORT.
Fuel System, Gasoline:storage:tank Assembly
SEE ATTACHED REPORT.
RQ02010 · Fuel Filter Quick Connect Fitting
Opened Jul 19, 2002 · Closed Nov 21, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Additional source detail variants (2)
Vehicle Speed Control:linkages
There is no summary currently available
Vehicle Speed Control:linkages
There is no summary currently available
PE02036 · Pincher/chafed Wiring
Opened Mar 18, 2002 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Steering
No summary supplied.
Illustration