2003 CHEVROLET TRAILBLAZER 370 REAR PASSENGER SIDE DOOR ELECTRICAL WINDOW CONTROL SWITCH WOULD NOT COMPLETELY CLOSE WINDOW . SMELLED LIKE ELECTRICAL WIRE BURNING. HAD VEHICLE STOP AT TIME AND HAD ASSISTANCE IN REMOVING DOOR INTERIOR PANEL AND FOUND ELECTRICAL WINDOW SWITCH COMPLETELY MELTED AND WIRE CONNECTION BURNED . PERSONAL …
Read full complaint
2003 CHEVROLET TRAILBLAZER 370 REAR PASSENGER SIDE DOOR ELECTRICAL WINDOW CONTROL SWITCH WOULD NOT COMPLETELY CLOSE WINDOW . SMELLED LIKE ELECTRICAL WIRE BURNING. HAD VEHICLE STOP AT TIME AND HAD ASSISTANCE IN REMOVING DOOR INTERIOR PANEL AND FOUND ELECTRICAL WINDOW SWITCH COMPLETELY MELTED AND WIRE CONNECTION BURNED . PERSONAL VEHICLE USED ON VACATION, STOPPED JUST OFF HIGHWAY AT TIME . *JS
NHTSA ODI #10817099
140,000 miles · Jan 23, 2015
Electrical SystemVisibility
TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT 370. THE CONTACT STATED THAT THE WINDOWS FAILED TO ROLL UP OR DOWN. ALSO, THE CONTACT MENTIONED THAT THE HEATED SEAT WOULD NOT TURN OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10678582
150,000 miles · Jan 2, 2015
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT 370. THE CONTACT STATED THAT THE TURN SIGNALS DO NOT FUNCTION PROPERLY AND THE HAZARD LIGHTS ILLUMINATED INSTEAD OF THE TURN SIGNALS. THE CONTACT WAS ABLE TO PRESS THE BUTTON FOR THE HAZARD LIGHTS WHEN NEEDED, BUT NOT THE TURN SIGNALS. THE VEHICLE WAS NOT DIAGNOSED. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT 370. THE CONTACT STATED THAT THE TURN SIGNALS DO NOT FUNCTION PROPERLY AND THE HAZARD LIGHTS ILLUMINATED INSTEAD OF THE TURN SIGNALS. THE CONTACT WAS ABLE TO PRESS THE BUTTON FOR THE HAZARD LIGHTS WHEN NEEDED, BUT NOT THE TURN SIGNALS. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE CONTINUED AND CAUSED THE FRONT HEADLIGHT ASSEMBLY AND THE REAR HEADLIGHT ASSEMBLY TO SHORT AND DIM WITH NO WARNING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10669711
160,000 miles · Nov 5, 2014
Electrical System
WE WERE DRIVING DOWN THE HIGHWAY WHEN OUR REAR PASSENGER DOOR FLEW OPEN, AND WILL NOT STAY CLOSED OR LOCK. WE HAD TO DRIVE WITH SOMEONE BACK THERE HOLDING IT SHUT TIL WE GOT TO A STORE TO RATCHET STRAP IT CLOSED. I CALLED CHEVY WHEN I SEEN IT WAS PART OF A RECALL FOR THE 2005 BUT THEY WOULD NOT LOOK AT MINE BECAUSE IT WAS NOT TH…
Read full complaint
WE WERE DRIVING DOWN THE HIGHWAY WHEN OUR REAR PASSENGER DOOR FLEW OPEN, AND WILL NOT STAY CLOSED OR LOCK. WE HAD TO DRIVE WITH SOMEONE BACK THERE HOLDING IT SHUT TIL WE GOT TO A STORE TO RATCHET STRAP IT CLOSED. I CALLED CHEVY WHEN I SEEN IT WAS PART OF A RECALL FOR THE 2005 BUT THEY WOULD NOT LOOK AT MINE BECAUSE IT WAS NOT THE SAME YEAR AS THE RECALL AND WANT ME TO PAY OUT OF POCKET TO FIX THE PROBLEM, AND WOULD NOT TELL ME K=NAME OF THE PART TO SEE IF I COULD BUY IT AND FIX IT OURSELVES A LOT CHEAPER. *TR
NHTSA ODI #10652805
Mileage unknown · Sep 3, 2014
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
THIS HAS BEEN GOING ON FOR THREE YEARS SINCE 2011 AT NIGHT AT RANDOM TIMES OUR LOW BEAM HEADLIGHTS GO OUT ON US AS YOUR DRIVING DOWN THE HIGHWAY. THEY MAY COME BACK ON BEFORE YOU GET HOME BUT WE HAVE DROVE 1HR 30 MINUTES AND STILL NOT. WE DID TAKE IT IN SEVERAL TIMES AND THEY CAN NOT FINE A PROBLEM. THEY SAID THEY CAN CHANGE TH…
Read full complaint
THIS HAS BEEN GOING ON FOR THREE YEARS SINCE 2011 AT NIGHT AT RANDOM TIMES OUR LOW BEAM HEADLIGHTS GO OUT ON US AS YOUR DRIVING DOWN THE HIGHWAY. THEY MAY COME BACK ON BEFORE YOU GET HOME BUT WE HAVE DROVE 1HR 30 MINUTES AND STILL NOT. WE DID TAKE IT IN SEVERAL TIMES AND THEY CAN NOT FINE A PROBLEM. THEY SAID THEY CAN CHANGE THIS N THAT SENOR BUT COULDN'T SAY THAT WOULD EVEN FIX IT. BUT COST US $$$$$$ WHY CAN'T SOME ONE FINE OUT DO A RECALL WE HATE DRIVING ON OUR HIGHBEAM AND SO DOES THE PEOPLE WE PASS OR GET BEHIND. WE DO TRY AND TURN THEM OFF WHEN WE PASS OTHER BUT THAT IS DANGERS AS WELL.PLEASE HELP WE WANT TO KEEP OUR TRAILBLAZER AND STAY ALIVE. *TR
NHTSA ODI #10630361
60,000 miles · Jan 27, 2012
Electrical System
SPEEDOMETER TACHOMETER AND BATTERY GAUGE DO NOT WORK. *TR
NHTSA ODI #10445546
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
2003 Chevrolet Trailblazer Ext 370 Problems, Complaints & Recalls | Skip That Year
Illustration