Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 25 of 216 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
216 reports
Mileage unknown · Apr 1, 2025
Power Train
vehicle shutters when downshifting/slowing. Most commonly at cruising speeds between 40 and 50 mph, but does occur at lower speeds as well. Vehicle can be felt vibrating/shaking consistently every time it is driven. Was taken into a dealership, was not adequately diagnosed as it was only test driven 1 mile per the paperwork and …
Read full complaint
vehicle shutters when downshifting/slowing. Most commonly at cruising speeds between 40 and 50 mph, but does occur at lower speeds as well. Vehicle can be felt vibrating/shaking consistently every time it is driven. Was taken into a dealership, was not adequately diagnosed as it was only test driven 1 mile per the paperwork and they could not duplicate the issue and was told they were "in the business of making money to repair vehicles" and this was a warranty repair. While leaving a gentleman was walking in and happened to have the same type of vehicle and asked my husband what we were there for, turns out he was having the same issues. The vehicle shuttered the entire drive home after leaving the dealership and has continued since.
NHTSA ODI #11652083
Mileage unknown · Mar 30, 2025
Engine
I was driving on [XXX] thru Atlanta to meet my husband in Adairsville, Georgia, and my car started squealing like a belt was squealing and then it started making a loud knocking noise and shut off I was able to get it to the shoulder to see what was going on, when I realized it was in the motor I was about half a mile to the nex…
Read full complaint
I was driving on [XXX] thru Atlanta to meet my husband in Adairsville, Georgia, and my car started squealing like a belt was squealing and then it started making a loud knocking noise and shut off I was able to get it to the shoulder to see what was going on, when I realized it was in the motor I was about half a mile to the next exit as I did not feel safe being on the side of the road managed to make it to the truck stop after it cut off several times just imagine if someone was close behind me when my Tahoe kept shutting off it could have been a very bad accident called gm roadside assistance and had vehicle towed to nearest dealer they couldn’t look at it so my husband loaded it into the back of his lowboy trailer and took it to hometown dealer where I bought it from Tahoe only had 22599 miles on it and I paid over 90k for this I feel like we should be compensated for this and the downtime of not knowing when I will get it back INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11651619
Mileage unknown · Mar 29, 2025
Engine
2023 with 34,000 miles on the 6.2 engine. Shutoff while driving. Engine is bad and will need to be replaced. GM should be forced to do a recall
NHTSA ODI #11651468
Mileage unknown · Mar 28, 2025
Power Train
Driving on hwy at 75 mph and needed to brake. While decelerating and still moving, engine shut off, dashboard dinged and message said to press start. Vehicle put itself into neutral. Happened twice while driving on highway. Car currently in shop. GM stating transmission valve body needs to be replaced. Tahoe only has 28K miles. …
Read full complaint
Driving on hwy at 75 mph and needed to brake. While decelerating and still moving, engine shut off, dashboard dinged and message said to press start. Vehicle put itself into neutral. Happened twice while driving on highway. Car currently in shop. GM stating transmission valve body needs to be replaced. Tahoe only has 28K miles. Part is on back order
NHTSA ODI #11651256
Mileage unknown · Mar 24, 2025
Engine
Started having an issue a few weeks ago with the vehicle shutting off while driving for no reason without warning causing a very serious safety concern. This issue seemed to stop until one Saturday when i started the vehicle i noticed a small tick. This ticking sound continued to grow. The vehicle then shut off again with warnin…
Read full complaint
Started having an issue a few weeks ago with the vehicle shutting off while driving for no reason without warning causing a very serious safety concern. This issue seemed to stop until one Saturday when i started the vehicle i noticed a small tick. This ticking sound continued to grow. The vehicle then shut off again with warning while driving. 7 days had gone by since the first episode. When I started the vehicle again there was a very pronounce rapping and it sounded like parts inside the motor were coming apart. When I arrived home i called Onstar. They did a diagnostic twice and said the motor was not showing any codes and running perfect. I had it towed from my house and upon inspection the motor is blown with 10,000 miles
NHTSA ODI #11650185
Mileage unknown · Mar 20, 2025
Engine
Engine failure due to rod bearing failure, without warning at 16,500k miles. It is available for inspection if needed. Currently is at dealership waiting for new engine. The vehicle shut off while driving at 40mph forcing me to have to stop in the middle of a roadway without any shoulders or turn offs. The problem was diagnosed…
Read full complaint
Engine failure due to rod bearing failure, without warning at 16,500k miles. It is available for inspection if needed. Currently is at dealership waiting for new engine. The vehicle shut off while driving at 40mph forcing me to have to stop in the middle of a roadway without any shoulders or turn offs. The problem was diagnosed and confirmed by a certified Chevrolet dealership. The failed engine will be sent to GM by the dealer. There were no warning lights prior to this incident or after.
NHTSA ODI #11649564
28,000 miles · Mar 20, 2025
Engine
The contact owns a 2023 Chevrolet Tahoe. The contact stated that upon starting the vehicle, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The vehicle was repaired, but …
Read full complaint
The contact owns a 2023 Chevrolet Tahoe. The contact stated that upon starting the vehicle, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, who then determined that the sound was the lifters tapping. The contact was informed that all 16 lifters needed to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was taken to a different dealer, who also diagnosed the vehicle and determined that the failure was with the lifters, and informed the previous dealer might not have been repaired the vehicle properly. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 28,000.
NHTSA ODI #11649541
Mileage unknown · Mar 17, 2025
EnginePower Train
Traveling down the highway at 65 MPH the engine/transmission started bucking and you could hear the rear wheel lock up. The vehicle then would not shift and reduced the speed to 55MPH. Check engine light came on. Chevrolet is telling me the valve body needs to be replaced but keep driving it because it is on national backorde…
Read full complaint
Traveling down the highway at 65 MPH the engine/transmission started bucking and you could hear the rear wheel lock up. The vehicle then would not shift and reduced the speed to 55MPH. Check engine light came on. Chevrolet is telling me the valve body needs to be replaced but keep driving it because it is on national backorder. After doing some research GM is hiding the issue and keeps installing faulty valve bodies. The GM fix is that they programmed the transmission to reduce speed when it notices excessive wear. GM is not standing behind the issue as it has been like pulling teeth to get a loaner vehicle.
NHTSA ODI #11648821
Mileage unknown · Mar 17, 2025
Engine
Vehicle broke down on 12/1/2024. Had it towed to the nearest dealership. Dealership claimed that gasoline was pumped into the tank. We knew that wasn't the case. I called the store we last used for fuel and spoke to the manager. She was able to pull my wife up on surveillance and verified that she pumped diesel fuel from a …
Read full complaint
Vehicle broke down on 12/1/2024. Had it towed to the nearest dealership. Dealership claimed that gasoline was pumped into the tank. We knew that wasn't the case. I called the store we last used for fuel and spoke to the manager. She was able to pull my wife up on surveillance and verified that she pumped diesel fuel from a "diesel fuel only" pump on 11/21/24. We also verified that the fuel in the holding tank at the store was actual diesel fuel. My wife purchased 23.45 gallons of diesel fuel. The tank size on this Tahoe is a 24 gallon tank. We had burned half of this fuel before the vehicle broke down. We also verified that no one else had complained about the fuel from the store. Dealership said it needed a new engine. We had it towed to another dealership for a second opinion, but they couldn't verify what happened because the 1st dealership had cleaned out the fuel system. I called GM but they won't help because they are going off what the 1st dealership claimed. Vehicle is still under power train warranty, but they won't fix it. This vehicle left us stranded on the side of the road. Insurance was called and a representative did go and look at the Tahoe. He called back and said that the issue does not fall within our policy.
NHTSA ODI #11648704
Mileage unknown · Mar 12, 2025
EngineForward Collision Avoidance
First the front collision warning systems kept coming on and off. Then the engine died on the highway and I had to restart. I drove a little further and it died again and would not restart. I had it towed to the dealer and they are telling me the engine has seized and needs to be replaced. I have 40,000 mile and the car is 2…
Read full complaint
First the front collision warning systems kept coming on and off. Then the engine died on the highway and I had to restart. I drove a little further and it died again and would not restart. I had it towed to the dealer and they are telling me the engine has seized and needs to be replaced. I have 40,000 mile and the car is 2 years old. It was very dangerous to have the car die twice while at speed on the highway.
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Tahoe Problems, Complaints & Recalls | Skip That Year
Illustration