Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 25 of 216 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
216 reports
Mileage unknown · Sep 15, 2026
Engine
We were driving on the highway and the engine started making a ticking noise and AFM light came on. Took the car to the dealership for inspection and they said the lifter had collapsed and it would cost $1000 to tear the engine down to see if the camshaft was damaged. Asked for the estimate to replace camshaft and lifters and th…
Read full complaint
We were driving on the highway and the engine started making a ticking noise and AFM light came on. Took the car to the dealership for inspection and they said the lifter had collapsed and it would cost $1000 to tear the engine down to see if the camshaft was damaged. Asked for the estimate to replace camshaft and lifters and they quoted $10,000.
NHTSA ODI #11764400
Mileage unknown · Sep 14, 2026
Engine
Our Tahoe was included in the recall. The dealership inspected it, found no issue at the time, and told us to switch to a different oil viscosity, which we did. This vehicle has only ever been serviced at a Chevrolet dealership. On August 20th, while driving on the highway, the engine shut off without warning and we had to coas…
Read full complaint
Our Tahoe was included in the recall. The dealership inspected it, found no issue at the time, and told us to switch to a different oil viscosity, which we did. This vehicle has only ever been serviced at a Chevrolet dealership. On August 20th, while driving on the highway, the engine shut off without warning and we had to coast to the shoulder. We attempted to restart it several times, but the engine would not hold an idle. After shutting off all accessories, including the A/C and radio, the vehicle finally started. We brought it back to the dealership for inspection, and once again they could not find any issue. Today, September 14, 2026, we heard loud clanking coming from the engine. We pulled over immediately and had the truck towed to the dealership. At this point, we believe the engine is no longer serviceable and will need to be replaced. We do not believe the change in oil viscosity is an adequate fix for the 2022 to 2024 6.2L engines covered under the GM recall, including the one in our Tahoe. An engine dying without warning at highway speed is a serious safety hazard, and we were fortunate it didn't end in a collision.
NHTSA ODI #11764113
82,000 miles · Sep 14, 2026
Engine
The contact owns a 2023 Chevrolet Tahoe. The contact stated there was a misfire in the engine, with the engine warning light illuminated. The message “Collision Mitigation System Off” was displayed. There was a burning odor coming from the vehicle after the failure. The vehicle started shaking abnormally. The vehicle was taken t…
Read full complaint
The contact owns a 2023 Chevrolet Tahoe. The contact stated there was a misfire in the engine, with the engine warning light illuminated. The message “Collision Mitigation System Off” was displayed. There was a burning odor coming from the vehicle after the failure. The vehicle started shaking abnormally. The vehicle was taken to the local dealer, where it was diagnosed and determined that the lifter and crankshaft needed to be replaced. The contact purchased a rebuilt engine, and the engine was replaced at another service center. The failure mileage was approximately 82,000.
NHTSA ODI #11764103
Mileage unknown · Sep 11, 2026
Engine
Hard shudder when driving between 45 to 50 mph and when you decelerate around 12 to 15 mph. Inspected at Lond Lewis Chevrolet stated and now being inspected by Bentley Chevrolet due to Lond Lewis Chevrolet doing absolute nothing. Tahoe has 23,000 miles currently. Bought new one owner always serviced as should.
NHTSA ODI #11763723
Mileage unknown · Sep 7, 2026
Engine
1 week and 1 day later we are stranded again on the side of highway going full speed in our Tahoe. We took it to two different certified Chevy dealerships and they gave us a vague resolution and this issusr is not fixed at all. Our engine is locking up on us at full speed on the highway. This vehicle has 83,000 miles on it and w…
Read full complaint
1 week and 1 day later we are stranded again on the side of highway going full speed in our Tahoe. We took it to two different certified Chevy dealerships and they gave us a vague resolution and this issusr is not fixed at all. Our engine is locking up on us at full speed on the highway. This vehicle has 83,000 miles on it and we’ve maintained this vehicle very well.
NHTSA ODI #11762588
Mileage unknown · Sep 2, 2026
EngineFuel/propulsion SystemUnknown Or Other
We were driving full speed down the highway and the vehicle completely shut down steering wheel locked and we were stranded for six hours. Turns out the dealer said it was just the battery and they fixed the grounding of the battery. I’m sorry but I’m not satisfied with this response. I’m scared to drive this vehicle.
NHTSA ODI #11761638
Mileage unknown · Aug 28, 2026
EngineForward Collision AvoidanceFuel/propulsion System
A couple weeks ago, the truck suddenly started running rough and the front collision avoidance system failure message displayed. Immediately took it to the dealership. Computer read out showed #7 fuel injector failed. Repaired and was fine. Yesterday, 8/27/26, same thing happened again. Immediately went to the dealership. Now #…
Read full complaint
A couple weeks ago, the truck suddenly started running rough and the front collision avoidance system failure message displayed. Immediately took it to the dealership. Computer read out showed #7 fuel injector failed. Repaired and was fine. Yesterday, 8/27/26, same thing happened again. Immediately went to the dealership. Now #4 fuel injector failed. Service manager just called and states that Chevrolet does not have that injector and on backorder with no date of expected delivery. No other Chevy dealer has #4 fuel injectors either. Tells me that there is an overwhelming demand for fuel injectors that indicates a defect. Meanwhile, the truck is out of service and GM is not addressing the issue to replace all the defective injectors.
NHTSA ODI #11760405
22,000 miles · Aug 28, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was taken to a dealer, where the NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) remedy was completed with an oil change and oil cap replacement. Approximately three months later, while the contact's wife was driving approximately 45 MPH, t…
Read full complaint
The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was taken to a dealer, where the NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) remedy was completed with an oil change and oil cap replacement. Approximately three months later, while the contact's wife was driving approximately 45 MPH, the engine stalled. The driver was able to coast to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the engine had failed. The engine was replaced. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 22,000.
NHTSA ODI #11760258
Mileage unknown · Aug 25, 2026
Power Train
I am writing to express my disappointment with how the L87 engine recall was handled on my 2023 Chevrolet Tahoe. I purchased this vehicle for approximately $82,000 and brought it to Kunes Chevrolet in Lake Geneva multiple times for scheduled maintenance. During my first visit after learning of the recall involving potential con…
Read full complaint
I am writing to express my disappointment with how the L87 engine recall was handled on my 2023 Chevrolet Tahoe. I purchased this vehicle for approximately $82,000 and brought it to Kunes Chevrolet in Lake Geneva multiple times for scheduled maintenance. During my first visit after learning of the recall involving potential connecting rod and crankshaft defects, I specifically asked when my vehicle would be inspected and repaired. I was repeatedly told that I would receive additional information in the mail and that I would be contacted when repairs became available. Over the course of several oil change visits, I continued to ask about the recall. Each time, I received essentially the same response. During my most recent visit, I was informed that when the recall procedure became available, the dealership would listen to the engine with a stethoscope and then determine whether the vehicle required repairs or only a switch to a heavier oil viscosity. As a customer who invested $82,000 in a full-size SUV, I found that response extremely disappointing. The recall concerns involve engine components that could potentially lead to catastrophic engine failure. Being told that the solution may simply be listening to the engine and installing thicker oil did not inspire confidence in the long-term reliability of the vehicle. Ultimately, my confidence in both the vehicle and the handling of this recall deteriorated to the point where I no longer felt comfortable taking long trips with my family. I made the difficult decision to trade the vehicle in less than two years after purchase, resulting in an approximately $26,000 financial loss. I believe customers who invested significant amounts of money in these vehicles deserved clearer communication, a more proactive response, and a solution that restored confidence in the product. Unfortunately, my experience left me with serious trust concerns regarding both this recall process and General Motors' customer commitment.
NHTSA ODI #11759440
Mileage unknown · Aug 24, 2026
Unknown Or Other
ONSTAR module does not work. GM dealership claims the hardworking malfunctions and needs replacement for $800. Onstar is advertised as a safety feature that is now unable to be used.
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Tahoe Problems, Complaints & Recalls | Skip That Year
Illustration