NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
9 reportsClear category filter45,059 miles · Sep 14, 2026
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the engine seized. There was no warning light illuminated. The contact attempted to restart the vehicle; however, the engine cranked for 2 minutes and indicated that there was no oil pressure. The engine cranked over after sev…
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the engine seized. There was no warning light illuminated. The contact attempted to restart the vehicle; however, the engine cranked for 2 minutes and indicated that there was no oil pressure. The engine cranked over after several minutes. The vehicle was taken to the dealer, where it was diagnosed with rod-bearing failure and that the engine needed to be replaced. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The engine was replaced under the recall. The manufacturer was notified of the failure. The dealer repaired the vehicle. The vehicle engine seized but was able to be driven at a reduced speed. The failure mileage was 45,059.
NHTSA ODI #11764093
68,000 miles · Mar 18, 2026
Engine And Engine Cooling
The contact's wife owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 50-60 MPH, several unknown warning lights illuminated. The driver pulled over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that unknown engine valves had…
Read full complaint
The contact's wife owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 50-60 MPH, several unknown warning lights illuminated. The driver pulled over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that unknown engine valves had collapsed, and there was possible camshaft damage. The contact was advised that further diagnostic tests were required. The dealer informed the contact that a recall should be issued for the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the dealer for assistance. The failure mileage was approximately 68,000.
NHTSA ODI #11725181
63,800 miles · Sep 8, 2025
EngineEngine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at various speeds, the engine warning light illuminated. While inspecting the oil level, the contact discovered that the oil level was extremely low. The contact added oil as needed. The vehicle was taken to a dealer and five different tests were perf…
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at various speeds, the engine warning light illuminated. While inspecting the oil level, the contact discovered that the oil level was extremely low. The contact added oil as needed. The vehicle was taken to a dealer and five different tests were performed and each test produced varying results. The contact stated that on several tests, the oil level remained at a normal level, but on other tests, the oil level was extremely low. The vehicle was taken to another dealer, Koepp Chevrolet, INC. (13221 U.S. Hwy 87 W, La Vernia, TX 78121); and similar results were received. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 63,800.
NHTSA ODI #11685631
100,000 miles · Aug 5, 2025
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving 60 MPH, the vehicle briefly lost motive power but quickly returned to normal functionality. Later, upon starting the vehicle, the vehicle immediately shut off and could to be restarted. No warning lights were illuminated. The vehicle was towed to the …
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving 60 MPH, the vehicle briefly lost motive power but quickly returned to normal functionality. Later, upon starting the vehicle, the vehicle immediately shut off and could to be restarted. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine after observing metal shavings in the oil pan. The contact was informed that the engine needed to be replaced. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was 100,000. The VIN was unavailable.
NHTSA ODI #11678520
73,000 miles · Jul 21, 2025
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated while driving 70 MPH, the vehicle lost power in the middle of the roadway. The contact was unable to pull over to the shoulder of the roadway with the rear wheels seized. The “Service Transmission” warning light was illuminated. The vehicle was taken to the dealer, who …
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated while driving 70 MPH, the vehicle lost power in the middle of the roadway. The contact was unable to pull over to the shoulder of the roadway with the rear wheels seized. The “Service Transmission” warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front brakes. The vehicle was repaired, but the failure reoccurred. The vehicle was towed back to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 73,000.
NHTSA ODI #11675154
20,000 miles · Jul 17, 2025
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at approximately 30 MPH, the vehicle started losing motive power and shuddered violently…
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at approximately 30 MPH, the vehicle started losing motive power and shuddered violently. Several unknown warning lights were illuminated. The vehicle was towed to a dealer, where it was diagnosed. The dealer replaced the SN-L Pipe and installed an SN-L injector kit. The vehicle was repaired; however, the failure recurred. The vehicle was towed to another unknown dealer, where it was diagnosed and determined that the cylinder #7 injector and R/R Fuel Rail needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken to an independent mechanic oil shop, where the contact was informed that metal shavings were found in the oil filter and the oil level was significantly low. The vehicle was repaired, however the failure recurred while driving, and the vehicle experienced excessive oil consumption. The dealer was contacted and advised the contact that the recall part was not yet available and an appointment could not be scheduled. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000. Parts distribution disconnect.
NHTSA ODI #11674350
49,000 miles · May 1, 2025
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while attempting to accelerate from a red light, the vehicle stalled. The vehicle was restarted, and the vehicle operated normally. The contact stated that later, while making a right turn, the vehicle stalled. The contact stated that after restarting the vehicle, …
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while attempting to accelerate from a red light, the vehicle stalled. The vehicle was restarted, and the vehicle operated normally. The contact stated that later, while making a right turn, the vehicle stalled. The contact stated that after restarting the vehicle, the vehicle operated normally. The vehicle was taken to the local mechanic, who was unable to duplicate the failure or diagnose the cause of the failure. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 49,000.
NHTSA ODI #11658241
64,000 miles · Apr 30, 2025
Engine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while depressing the accelerator pedal, there was an abnormal sound from the engine compartment. The contact stated that it sounded like a metal-on-metal rattling. The contact stated that the "Service Suspension and Low Oil" warning lights were illuminated. The con…
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while depressing the accelerator pedal, there was an abnormal sound from the engine compartment. The contact stated that it sounded like a metal-on-metal rattling. The contact stated that the "Service Suspension and Low Oil" warning lights were illuminated. The contact stated that a quart of engine oil was being added once per month. The contact had taken the vehicle to a local dealer, who was unable to determine the cause of the failure or to duplicate the failure. The vehicle was not repaired. The contact was notified of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the engine was replaced in 2022, and the replacement engine was consuming oil and making abnormal sounds. The manufacturer was informed of the failure. The failure mileage was approximately 64,000.
NHTSA ODI #11657756
4,984 miles · Mar 7, 2023
EngineEngine And Engine Cooling
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the local dealer and the contact informed that the system was being updated and was interrupted while attempting to start-up. While driving approximately 25-30 MPH, the veh…
Read full complaint
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the local dealer and the contact informed that the system was being updated and was interrupted while attempting to start-up. While driving approximately 25-30 MPH, the vehicle stalled. The message “No Key Detected” was displayed. The check engine warning light was illuminated. The vehicle was towed to the same dealer to be diagnosed. The contact was informed that the failure was due to the gateway serial data module. The vehicle was repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 4,984. The VIN was not available.
NHTSA ODI #11510665
Official recalls
4Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration