NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
658 reportsMileage unknown · May 28, 2015
Seat BeltsInjury
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. WHEN THE FRONT DRIVER SEAT WAS ADJUSTED AT ITS HIGHEST POINT, THE SEAT BELT ANCHOR PRESSED DOWN ON THE CONTACT'S LEG AND CAUSED BRUISING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE SEAT WOULD NEED TO BE LOWERED IN ORDER FOR THE SEAT BELT TO WORK PROPERLY. THE…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. WHEN THE FRONT DRIVER SEAT WAS ADJUSTED AT ITS HIGHEST POINT, THE SEAT BELT ANCHOR PRESSED DOWN ON THE CONTACT'S LEG AND CAUSED BRUISING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE SEAT WOULD NEED TO BE LOWERED IN ORDER FOR THE SEAT BELT TO WORK PROPERLY. THE SEAT BELT WAS NOT DESIGNED TO WORK WHEN THE SEAT WAS RAISED THAT HIGH. THE CONTACT FELT THE SEAT BELT SHOULD STILL WORK WHEN THE SEAT IS AT ITS HIGHEST POSITION. THE SEAT BELT ANCHOR WAS CONNECTED TO THE SEAT AND NOT THE FRAME OF THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER AND WAS INFORMED THAT THERE WAS NO EXTENSION MADE FOR THE SEAT BELT. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10721902
4,500 miles · May 16, 2015
Power Train
LAST NIGHT VEHICLE START JERKING AND WHEN ACCELERATING IT WOULD HESITATE THEN TAKE OF AND THERE WAS A SOUND IN THE TRANSMISSION. THE NEXT MORNING WHICH IS TODAY WHEN I WENT TO DRIVE THERE WAS A ERROR MESSAGE THAT SAID 4 WHEEL DRIVE. WHEN I WENT TO TAKE OF THE VEHICLE WOULD GO IN AND OUT OF 4 WHEEL DRIVE BY ITSELF. THIS CONTINUED…
Read full complaint
LAST NIGHT VEHICLE START JERKING AND WHEN ACCELERATING IT WOULD HESITATE THEN TAKE OF AND THERE WAS A SOUND IN THE TRANSMISSION. THE NEXT MORNING WHICH IS TODAY WHEN I WENT TO DRIVE THERE WAS A ERROR MESSAGE THAT SAID 4 WHEEL DRIVE. WHEN I WENT TO TAKE OF THE VEHICLE WOULD GO IN AND OUT OF 4 WHEEL DRIVE BY ITSELF. THIS CONTINUED ALL DAY AND FEEL THE VEHICLE IS NOT SAFE BECAUSE WHEN IT ERRATICALLY GOES INTO 4 WHEEL DRIVE AT NORMAL SPEED THE STEERING WAS COMPROMISED. I WILL TAKE IT TO DEALER MONDAY..
NHTSA ODI #10716855
41,000 miles · May 14, 2015
Steering
IT STARTED WITH A CLICKING SOUND WHEN TURNING THE STEERING WHEEL. I BROUGHT IT TO DEALERSHIP AND THEY CHANGED ENTIRE STEERING COLUMN. A WEEK LATER IT MADE A CLICKING SOUND AGAIN ON A HARD TURN. I CALLED GM TO ASK ABOUT A BUY BACK. I DO NOT FEEL SAFE IN THAT CAR WITH KIDS. THEN LATER THE SAME DAY, I WAS BACKING OUT OF SONS LITTLE…
Read full complaint
IT STARTED WITH A CLICKING SOUND WHEN TURNING THE STEERING WHEEL. I BROUGHT IT TO DEALERSHIP AND THEY CHANGED ENTIRE STEERING COLUMN. A WEEK LATER IT MADE A CLICKING SOUND AGAIN ON A HARD TURN. I CALLED GM TO ASK ABOUT A BUY BACK. I DO NOT FEEL SAFE IN THAT CAR WITH KIDS. THEN LATER THE SAME DAY, I WAS BACKING OUT OF SONS LITTLE LEAGUE GAME AND STEERING COLUMN LOCKED AND DISPLAYED LOCKED ON INFORMATION SCREEN. I HIT BRAKES AND LOCK DISPLAY DISAPPEARED SO I SHIFTED TO PARK AND THEN TO BACK TO REVERSE AND STEERING COLUMN LOCK AGAIN DISPLAY AND LOCK. I THEN PUT CAR BACK INTO PARK AND TURNED OFF. I TURN CAR BACK ON AFTER A COUPLE OF MINUTES AND IT WAS WORKING FINE NO MORE STEERING COLUMN LOCK DISPLAY. I HAVE A KEYLESS START, LOADED LT MODEL THAT HAS ALL FEATURES OF AN LTZ TAHOE.
NHTSA ODI #10716588
1,000 miles · May 13, 2015
Vehicle Speed Control
THE FORWARD COLLISION ALERT SYSTEM JUST DOESN'T WORK. I CANNOT MAKE IT PRODUCE A COLLISION ALERT NO MATTER WHAT I DO. FOR EXAMPLE IT IS ADVERTISED TO PROVIDE A HEADS UP VISUAL WARNING AS WELL AS AN AUDIAL WARNING IF I APPROACH THE CAR IN FRONT OF ME TO RAPIDLY. IT DOES NOT THE SYSTEM ALSO A GREEN AUTOMOBILE ICON WHEN YOU ARE FOL…
Read full complaint
THE FORWARD COLLISION ALERT SYSTEM JUST DOESN'T WORK. I CANNOT MAKE IT PRODUCE A COLLISION ALERT NO MATTER WHAT I DO. FOR EXAMPLE IT IS ADVERTISED TO PROVIDE A HEADS UP VISUAL WARNING AS WELL AS AN AUDIAL WARNING IF I APPROACH THE CAR IN FRONT OF ME TO RAPIDLY. IT DOES NOT THE SYSTEM ALSO A GREEN AUTOMOBILE ICON WHEN YOU ARE FOLLOWING CLOSER THAN ABOUT 200 FEET TO THE VEHICLE IN FRONT OF YOU. THE GREEN ICON IS ADVERTISED TO TURN YELLOW IF YOU FOLLOW TOO CLOSE. IT DOES NOT. THE ONLY TIME THAT I HAVE EVER SEEN THE RED HEADS UP DISPLAY IS WHEN IT IS A FALSE ALERT. ALL AND ALL, THIS SYSTEM WHICH WAS TOUTED TO BE A GREAT SAFETY FEATURE IS TOTALLY WORTHLESS.
NHTSA ODI #10716274
16,562 miles · May 4, 2015
Service Brakes
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. WHILE DRIVING AT 45 MPH, THE SERVICE BRAKE ASSIST WAS DISPLAYED ACROSS THE MESSAGE BOARD. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND IT TOOK A GREATER AMOUNT OF TIME FOR THE VEHICLE TO COME TO A COMPLETE STOP. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. WHILE DRIVING AT 45 MPH, THE SERVICE BRAKE ASSIST WAS DISPLAYED ACROSS THE MESSAGE BOARD. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND IT TOOK A GREATER AMOUNT OF TIME FOR THE VEHICLE TO COME TO A COMPLETE STOP. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 16,562. UPDATED 6/18/15*CN UPDATED 10/12/2017*CN
NHTSA ODI #10714400
3,000 miles · Apr 25, 2015
Electrical SystemEquipment Adaptive/mobilityVehicle Speed Control
UPON PURCHASE OF A NEW 2015 TAHOE I OBSERVED THE POSSIBILITY OF A PROBLEM WITH THE FORWARD COLLISION ALERT SYSTEM (FCA). I REPORTED THIS TO THE SERVICE MANAGER AT CHEVROLET. ON 9 APRIL 2015 THE SERVICE MANAGER, ASSISTANT SERVICE MANAGER, MASTER TECHNICIAN, AND I TOOK THE VEHICLE FOR A TEST DRIVE. WHILE DRIVING THE VE…
Read full complaint
UPON PURCHASE OF A NEW 2015 TAHOE I OBSERVED THE POSSIBILITY OF A PROBLEM WITH THE FORWARD COLLISION ALERT SYSTEM (FCA). I REPORTED THIS TO THE SERVICE MANAGER AT CHEVROLET. ON 9 APRIL 2015 THE SERVICE MANAGER, ASSISTANT SERVICE MANAGER, MASTER TECHNICIAN, AND I TOOK THE VEHICLE FOR A TEST DRIVE. WHILE DRIVING THE VEHICLE AT MODERATE HIGHWAY SPEEDS I DEMONSTRATED THE VARIOUS PHASES AND OPERATION OF VEHICLE DETECTION. THE FCA HAS PLENTY OF SENSITIVITY AND DETECTS VEHICLES IN EXCESS OF THE SPECIFIED DISTANCE IN THE OWNER'S MANUAL WHICH IS NOT AN ISSUE. AT A MODERATE CLOSING RATE BETWEEN VEHICLES THE INSTRUMENT CLUSTER ICON CHANGES FROM GREEN TO AMBER-ORANGE WHICH APPEARS NOMINAL. HOWEVER, THE RED ALARM HEADS-UP WINDSHIELD DISPLAY, RAPID HIGH-PITCHED BEEPS AND RED ICON ARE NEVER ACTIVATED UNTIL A CLOSING DISTANCE ABOUT ~3 FEET BEFORE A COLLISION. THERE IS VIRTUALLY ZERO REACTION TIME FOR A DRIVER TO BRAKE THE VEHICLE AT LESS THAN ONE CAR LENGTH BEFORE GOING TO RED. IN ADDITION, THE SYSTEM IS SUPPOSED TO DISENGAGE THE ADAPTIVE CRUISE CONTROL (ACC). CONSIDERING TIME, RATE, AND DISTANCE THIS IS INEFFECTIVE AS THE MASS AND KINETIC ENERGY ALSO NEEDS TO FULLY DISENGAGE BEFORE A POTENTIAL COLLISION. BECAUSE OF THE DANGER OF CREATING A TRAFFIC INCIDENT THE VEHICLE WAS NOT TESTED TO THE LEVEL OF A FULL COLLISION. I WAS INFORMED BY THE SERVICE MANAGER THAT THERE ARE NO SERVICE BULLETINS, ADJUSTMENTS, OR SOFTWARE PATCHES THAT MAY CORRECT THIS DEFICIENCY BY THE DEALER. GM STATED THAT THE SYSTEM WORKS AS DESIGNED AND DELIVERED. THE GM FORWARD COLLISION ALARM (FCA) DELIVERED PRODUCT APPEARS TO HAVE A DESIGN DEFICIENCY AND IS AN OPERATIONAL SAFETY HAZARD WAITING TO HAPPEN. IF THE FCA DOES NOT FUNCTION PROPERLY THEN WHY INTRODUCE IT TO A CONSUMER REGARDLESS OF GM OWNER MANUAL WARNINGS ABOUT TRUSTING ALERT SYSTEMS. *TR
NHTSA ODI #10712864
10,900 miles · Apr 9, 2015
Seats
FRONT DRIVER SEAT MOVEMENT DURING SLOW TURNING AND STOPPING, ALSO CLUNKING INSIDE SEAT. *TR
NHTSA ODI #10704843
100 miles · Apr 1, 2015
Equipment Adaptive/mobilityVisibility/wiper
THE ENTERTAINMENT SYSTEMS WAS PULLED DOWN BY MY KIDS TO WATCH A MOVIE. WHEN THE DVD SCREEN WAS PULLED DOWN IT COMPLETELY BLOCKED THE DRIVER REAR VIEW MIRROR. AS SUCH....YOU CANNOT USE THE ENTERTAINMENT SYSTEM AND DRIVE AT THE SAME TIME IN THE VEHICLE. *TR
NHTSA ODI #10703063
350 miles · Mar 23, 2015
Electrical System
JANUARY 15, 2015 NOT EVEN TWO WEEKS AFTER PURCHASING MY VEHICLE I GOT IN IT AFTER WORK AND NOTICED I COULDN'T MANAGE THE CLIMATE CONTROLLERS (HEATING/AIR CONDITIONING/SPEED/AIR FLOW) NOTHING IN THE FRONT OR BACK. I IMMEDIATELY CALLED THE DEALERSHIP AND SENT IN A PICTURE. ALL THE KNOBS AND CONTROLLERS FOR JUST THE CLIMATE WERE DA…
Read full complaint
JANUARY 15, 2015 NOT EVEN TWO WEEKS AFTER PURCHASING MY VEHICLE I GOT IN IT AFTER WORK AND NOTICED I COULDN'T MANAGE THE CLIMATE CONTROLLERS (HEATING/AIR CONDITIONING/SPEED/AIR FLOW) NOTHING IN THE FRONT OR BACK. I IMMEDIATELY CALLED THE DEALERSHIP AND SENT IN A PICTURE. ALL THE KNOBS AND CONTROLLERS FOR JUST THE CLIMATE WERE DARK, NO LIGHTING AS IF THE VEHICLE WAS OFF. I DROVE IT HOME AND SINCE IT WAS SO COLD OUT IT WAS THOUGHT MAYBE IT JUST NEEDED TO WARM UP MORE. I DROVE 45 MINUTES HOME AND THE CLIMATE CONTROLLERS NEVER TURNED ON AGAIN UNTIL THE NEXT MORNING. TOOK IT TO THE DEALERSHIP BECAUSE I WAS ALSO HAVING OTHER ISSUES AND THEY STATED THEY COULDN'T FIND ANYTHING WRONG. EVERYTHING HAS BEEN FINE WITH THE CLIMATE CONTROLLERS FROM THAT POINT ON UNTIL THIS WEEKEND. ON MARCH 21, 2015 I DROVE TO PICK UP BREAKFAST, EVERYTHING WAS FINE. AN HOUR LATER AFTER WE PILED IN THE VEHICLE AND WERE DRIVING I WENT TO KICK THE AIR ON AS IT WAS GETTING WARM AND NOTICED THE CONTROLLERS WERE NOT RESPONDING AGAIN. I PULLED OVER INTO A PARKING LOT AND RECORDED MY ACTIONS SO THE DEALERSHIP CAN'T SAY THEY NEED TO "SEE IT." I TURNED THE VEHICLE OFF, TRIED TURNING THE LIGHTS ON AND OFF, REMOTE STARTING, EVERYTHING BUT DISCONNECTING THE BATTERY. NOTHING. THE REST OF THE DAY WHILE WE BOUNCED FROM STORE TO STORE WITH HAD NO AIR. MARCH 22ND, IT WAS BACK ON AS NORMAL. TODAY MARCH 23RD AFTER WORK IT WAS NOT OPERATIONAL AGAIN. SOMETHING NEEDS TO BE DONE, THE LAST POST I HAD ON THIS SITE WAS WHEN I HAD A 2014 GMC ACADIA AND MY SON OVER HEATED FROM A VERY SIMILAR SITUATION. THIS IS BEYOND RIDICULOUS THAT I HAVE YET ANOTHER GM MADE VEHICLE AND THERE IS A MAJOR ISSUE WITH A BRAND NEW VEHICLE. GM NEEDS TO BE HELD RESPONSIBLE, NOT HAVING HEAT OR AIR CONDITIONING IN A FAMILY VEHICLE IS EXTREMELY DANGEROUS FOR ANYONE WHO DEPENDS ON TRAVEL WITH THAT VEHICLE. *TR
NHTSA ODI #10701270
Mileage unknown · Mar 16, 2015
Seat Belts
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. THE CONTACT STATED THAT THE SEAT BELT ON THE THIRD ROW CENTER SEAT BELT FAILED TO UNLATCH. THE DEALER WAS CONTACTED AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER REFERRED THE CONTACT TO THE OWNER'S MANUAL WHICH STATED "TO DISCONNECT THE REAR SAFETY BELT MINI LATCH, US…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET TAHOE. THE CONTACT STATED THAT THE SEAT BELT ON THE THIRD ROW CENTER SEAT BELT FAILED TO UNLATCH. THE DEALER WAS CONTACTED AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER REFERRED THE CONTACT TO THE OWNER'S MANUAL WHICH STATED "TO DISCONNECT THE REAR SAFETY BELT MINI LATCH, USING A KEY IN THE SLOT ON THE MINI BUCKLE AND LET BELT RETRACT TO THE HEADLINER. STOW THE MINI LATCH IN THE HOLDER IN THE HEAD LINER." IN THE EVENT OF AN EMERGENCY, THE OCCUPANT OF THIS SEAT COULD BECOME ENTRAPPED IN THE SEAT IF THEY DID NOT HAVE AN OBJECT TO UNLATCH THE BUCKLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10694571
Official recalls
14Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Sep 7, 2018
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Consequence & remedy
Consequence: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
May 3, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Oct 9, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13, 2014. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.
Consequence & remedy
Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.
Nov 10, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
Consequence & remedy
Consequence: During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
Remedy: GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
Jun 27, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
Consequence & remedy
Consequence: If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
Additional source detail variants (2)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
Seat Belts:front:warning Light/devices
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Silverado vehicles manufactured May 23, 2013, through March 25, 2014, 2014 GMC Sierra vehicles manufactured May 25, 2013, through March 31, 2014, and 2015 Chevrolet Tahoe vehicles manufactured January 29, 2014, through March 27, 2014. In the affected vehicles, the tie rod threaded attachment may not be properly tightened to the steering gear rack.
Consequence & remedy
Consequence: An improperly tightened tie rod attachment may allow the tie rod to separate from the steering rack, resulting in a loss of steering, increasing the risk of a vehicle crash.
Remedy: GM notified all owners, and dealers will inspect the inner tie rods to make sure that they are correctly tightened, replacing the steering gear, as necessary, free of charge. The recall began on May 14, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14204. NOTE: Owners are advised not to drive their vehicles until they have been inspected and repaired. Owners should contact GM to have their vehicles towed to the dealership.
Mar 31, 2014
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission (feature code MYC). The subject vehicles may have a transmission oil cooler line that is not securely seated in the fitting.
Consequence & remedy
Consequence: If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
Remedy: GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration