NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
26 reportsClear category filter95,069 miles · Jul 8, 2019
Electrical SystemElectronic Stability Control (esc)Steering
WHILE DRIVING ON THE HIGHWAY AT HIGH SPEEDS, 70-80 MPH, STEERING BECAME EXTREMELY DIFFICULT FOR BRIEF PERIODS. OFTEN TIMES IT WAS IMMEDIATELY FOLLOWING ACTUATION OF THE AUTOMATIC WINDOW SWITCH. IT WAS ACCOMPANIED WITH A LOT OF THE LOSS OF ELECTRICAL POWER, A FLICKERING CONTROL PANEL, ABS LIGHT, STAB TRAK, BRAKE ASSIST, AND PARK …
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT HIGH SPEEDS, 70-80 MPH, STEERING BECAME EXTREMELY DIFFICULT FOR BRIEF PERIODS. OFTEN TIMES IT WAS IMMEDIATELY FOLLOWING ACTUATION OF THE AUTOMATIC WINDOW SWITCH. IT WAS ACCOMPANIED WITH A LOT OF THE LOSS OF ELECTRICAL POWER, A FLICKERING CONTROL PANEL, ABS LIGHT, STAB TRAK, BRAKE ASSIST, AND PARK ASSIST WARNINGS. A/C WOULD STOP, RADIO WOULD TURN OFF, THE DASHBOARD WOULD FLICKER, THEN I WOULD HAVE TO ACKNOWLEDGE ALL OF THE WARNINGS IN ORDER TO CLEAR THE ISSUE. STEERING WAS TOUGH, THOUGH CONTROLLABLE, BUT I QUESTION THE ABILITY OF A LESS EXPERIENCED DRIVE TO BE ABLE TO HANDLE THE SAME PROBLEM AT THOSE SPEEDS. THIS HAS HAPPENED BEFORE AT LOWER SPEEDS, USUALLY WHILE BACKING UP TO PARK. AT LOWER SPEEDS THE SUV WOULD CUT OFF COMPLETELY. AT HIGHER SPEEDS, THE STALL WAS RECOVERABLE, VERY FORTUNATE IN THIS MATTER. UNABLE TO GET THE ISSUE TO REPEAT AT THE DEALERSHIP AND IT IS VERY INCONSISTENT. USUALLY RESETS ITSELF ONCE THE CAR IS TURNED OFF AND RESTARTED.
NHTSA ODI #11230267
71,000 miles · Jun 17, 2019
Electronic Stability Control (esc)SteeringSuspension
WHILE DRIVING SUSPENSION SYSTEM ALLOWS CAR TO BOUNCE BADLY, AS IF ALL SHOCKS ARE NOT WORKING, LTZ MODEL HAS MAG RIDE ACTIVE SUSPENSION. THIS PROBLEM IS FOUND TO BE COMMON ON 2015 TAHOE AND SUBURBANS. MANY FORUMS ON WEB HAVE REPORTS OF THIS SYSTEM FAILURE AT LOW MILAGE. MY TAHOE WAS PURCHASED NEW AND HAS ONLY 71K MILES, NO COLLIS…
Read full complaint
WHILE DRIVING SUSPENSION SYSTEM ALLOWS CAR TO BOUNCE BADLY, AS IF ALL SHOCKS ARE NOT WORKING, LTZ MODEL HAS MAG RIDE ACTIVE SUSPENSION. THIS PROBLEM IS FOUND TO BE COMMON ON 2015 TAHOE AND SUBURBANS. MANY FORUMS ON WEB HAVE REPORTS OF THIS SYSTEM FAILURE AT LOW MILAGE. MY TAHOE WAS PURCHASED NEW AND HAS ONLY 71K MILES, NO COLLISIONS OR ACCIDENTS. ALL MAINTAINED CE PERFORMED AS NEEDED.
NHTSA ODI #11220583
125,312 miles · Apr 25, 2019
Electrical SystemElectronic Stability Control (esc)Steering
VEHICLE RANDOMLY LOSES STEERING CONTROL AND FLASHES WARNING LIGHTS. AT TIMES, XM RADIO WILL NOT PLAY. AT ONE TIME, VEHICLE SHUT OFF AND WOULD NOT RESART FOR APPROXIMATELY 10 SECONDS. OCCASIONALLY, THE WARNING LIGHTS FLASH WHEN MAKING AN ADJUSTMENT LIKE CHANGING TO BRIGHT LIGHTS OR ACTIVATING THE TURN SIGNAL. LEFT TURN SIGNAL …
Read full complaint
VEHICLE RANDOMLY LOSES STEERING CONTROL AND FLASHES WARNING LIGHTS. AT TIMES, XM RADIO WILL NOT PLAY. AT ONE TIME, VEHICLE SHUT OFF AND WOULD NOT RESART FOR APPROXIMATELY 10 SECONDS. OCCASIONALLY, THE WARNING LIGHTS FLASH WHEN MAKING AN ADJUSTMENT LIKE CHANGING TO BRIGHT LIGHTS OR ACTIVATING THE TURN SIGNAL. LEFT TURN SIGNAL DISENGAGES CRUISE WHEN ACTIVATED. GM HAS UPDATED THE SOFTWARE TWICE DUE TO SERVICE OVER THE ABOVE COMPLAINTS. FIXES PROBLEM FOR SHORT AMOUNT OF TIME.
NHTSA ODI #11203835
108,000 miles · Apr 21, 2019
Electrical SystemElectronic Stability Control (esc)Steering
ON SEVERAL OCCASIONS MY CARE HAS GIVEN ME A WARNING OF STABILITY RACK ISSUES AND IT WILL THEN JUST SHUT DOWN. THIS HAS HAPPENED IN THE MIDDLE OF TURNING INTO PARKING LOTS AS WELL AS BACKING INTO PARKING SPOTS. I THEN HAVE TO ROLL DOWN AND UP MY DRIVER SIDE AND PASSENGER SIDE WINDOWS BEFORE I CAN RESTART MY VEHICLE.
NHTSA ODI #11202765
5 miles · Apr 20, 2019
Electrical SystemElectronic Stability Control (esc)Engine
IM DRIVING THE CAR AND RANDOMLY STOPS LIKE DIED ALL THE POWER AND BRAKES, LIGHTS AND RADIO GO OFF AND I HAVE TO PARK THEN THE CAR WONT START AFTER FEW MINUTES
NHTSA ODI #11202704
30,000 miles · Mar 8, 2019
Electronic Stability Control (esc)Unknown Or Other
STABILITRAK COMES ON AND LOCKS THE STEERING WHILE DRIVING. IT HAS HAPPENED APPROX. 4 TIMES AND THE DEALERSHIP DOESN'T KNOW WHY, NOR HAVE THEY RESOLVED THE PROBLEM. WATER KEEPS GETTING IN THE VEHICLE AND THE DEALERSHIP CAN'T FIGURE OUT WHERE IT'S COMING FROM EITHER. THEY HAVE TRIED 6 TIMES
NHTSA ODI #11185125
42,000 miles · Nov 19, 2018
Electronic Stability Control (esc)Power TrainUnknown Or OtherCrash
2015 CHEVROLET TAHOE WAS PARKED ON MODERATELY SLOPED DRIVEWAY. ENGINE WAS NOT RUNNING. VEHICLE TRANSMISSION SHIFTER WAS IN "PARK" POSITION. VEHICLE SPONTANEOUSLY ROLLED BACK SEVERAL FEET, AND CRASHED INTO ANOTHER PARKED VEHICLE. OTHER VEHICLE ALSO OWNED BY ME. SUBSTANTIAL DAMAGE TO BOTH VEHICLES. NOT INFLUENCED BY DRIVER. AFTER …
Read full complaint
2015 CHEVROLET TAHOE WAS PARKED ON MODERATELY SLOPED DRIVEWAY. ENGINE WAS NOT RUNNING. VEHICLE TRANSMISSION SHIFTER WAS IN "PARK" POSITION. VEHICLE SPONTANEOUSLY ROLLED BACK SEVERAL FEET, AND CRASHED INTO ANOTHER PARKED VEHICLE. OTHER VEHICLE ALSO OWNED BY ME. SUBSTANTIAL DAMAGE TO BOTH VEHICLES. NOT INFLUENCED BY DRIVER. AFTER SOME RESEARCH IT IS MY BELIEF THE APPARENT PROBLEM WITH THE TRANSMISSION/SOFTWARE. I DID FIND WHERE THERE WAS A RECALL #14192 FOR THIS ISSUE.
NHTSA ODI #11152511
32,000 miles · Jul 17, 2018
Electrical SystemElectronic Stability Control (esc)Steering
MULTIPLE ISSUES EFFECTING THIS VEHICLE, AND THE ISSUES OCCUR WHEN STABILITRAC ISSUE AND ABS ISSUE POPS UP ON SCREEN. A/C ALSO STOPS BLOWING COLD AIR, AND SPEEDOMETER READS ZERO WHILE MOVING. THE STABILITRAC AND ABS ISSUES FIRST OCCURRED MULTIPLE TIMES STARTING IN THE EARLY WARRANTY PERIOD.THE MAIN CONCERN IS THE POWER ASSIST MAL…
Read full complaint
MULTIPLE ISSUES EFFECTING THIS VEHICLE, AND THE ISSUES OCCUR WHEN STABILITRAC ISSUE AND ABS ISSUE POPS UP ON SCREEN. A/C ALSO STOPS BLOWING COLD AIR, AND SPEEDOMETER READS ZERO WHILE MOVING. THE STABILITRAC AND ABS ISSUES FIRST OCCURRED MULTIPLE TIMES STARTING IN THE EARLY WARRANTY PERIOD.THE MAIN CONCERN IS THE POWER ASSIST MALFUNCTIONING CAUSING TOTAL LOSS OF STEERING CONTROL. WHEN POWER ASSIST RE-ENGAGES, THE VEHICLE WILL JUMP IN THE DIRECTION THE STEERING WHEEL IS TURNED. THIS IS A MAJOR SAFETY ISSUE. I REPEAT THAT THESE ISSUES STARTED TO OCCUR DURING THE EARLY WARRANTY PERIOD IN 2015. THE DEALER COULD NOT DUPLICATE THE ISSUES. THERE ARE MULTIPLE POSTS ON LINE CONCERNING THE PROBLEMS WITH THE 2015 TAHOE, SOME ACTUALLY CAUSING ACCIDENTS.
NHTSA ODI #11111924
Mileage unknown · Apr 2, 2018
Electronic Stability Control (esc)SteeringSuspension
MY WIFE AND MYSELF PURCHASED A NEW CHEVROLET TAHOE LTZ IN 2015. THE FIRST MONTH THE A/C HAD TO BE REPLACED, RAC AND PINION STEERING AND REAR SHOCKS. THE WARRANTY COVERED THE COST. 2016 OF JANUARY THE A/C STARTED MAKING NOISES AND NOT COOILNG, THE FRONT STRUTS MAGNETIC,BALL JOINTS AND STEERING RACK PINION WENT OUT. THIRD OCC…
Read full complaint
MY WIFE AND MYSELF PURCHASED A NEW CHEVROLET TAHOE LTZ IN 2015. THE FIRST MONTH THE A/C HAD TO BE REPLACED, RAC AND PINION STEERING AND REAR SHOCKS. THE WARRANTY COVERED THE COST. 2016 OF JANUARY THE A/C STARTED MAKING NOISES AND NOT COOILNG, THE FRONT STRUTS MAGNETIC,BALL JOINTS AND STEERING RACK PINION WENT OUT. THIRD OCCURRENCE WAS IN 2017 DECEMBER THE FRONT MAGNETIC STRUCTS AGAIN. WE HAVE HAD PROBLEMS WITH THIS NEW VEHICLE FROM THE TIME WE PURCHASED IT. THE SUSPENSION IS HORRIBLE AND WE LATER FOUND OUT THERE ARE HUNDREDS OF OTHERS WITH THE IDENTITCAL HORRIBLE SUSPENSION PROBLEM. THIS VEHICLE IS PRESENTLY AT 62K MILE AND NEEDS FRONT END SUSPENSION REPLACEMENT. THE WARRANTY DO NOT COVER PASS THREE YEARS. THERE SHOULD BE A RECALL ON THIS HORRIBLE GENERAL MOTORS PRODUCT. THE VEHICLE IS PRESENTLY INOPERABLE BECAUSE OF SUSPENSION PROBLEMS AND GM WILL NOT STAND BEHIND THERE PRODUCT.
NHTSA ODI #11082580
27,000 miles · Jan 17, 2018
Electronic Stability Control (esc)Crash
ON JANUARY 14TH, 2018 I WAS DRIVING FROM TULARE, CA TO MY HOME IN PIXLEY, CA. HALF WAY HOME DRIVING ON HWY 99 I EXPERIENCED THAT MY RPMS WOULD GO DOWN AND MY VEHICLE WOULD SLOW DOWN EVERY SO OFTEN. ON DASH SCREEN I HAD A POP UP THAT READ, 'SERVICE STABILITY CONTROL' DON'T KNOW WHAT THAT MEANS. SOMETIMES NOT BEING ABLE TO SLOW DO…
Read full complaint
ON JANUARY 14TH, 2018 I WAS DRIVING FROM TULARE, CA TO MY HOME IN PIXLEY, CA. HALF WAY HOME DRIVING ON HWY 99 I EXPERIENCED THAT MY RPMS WOULD GO DOWN AND MY VEHICLE WOULD SLOW DOWN EVERY SO OFTEN. ON DASH SCREEN I HAD A POP UP THAT READ, 'SERVICE STABILITY CONTROL' DON'T KNOW WHAT THAT MEANS. SOMETIMES NOT BEING ABLE TO SLOW DOWN (FULL CONTROL) I MADE IT TO PIXLEY. STOPPED AT MY SISTERS HOUSE, WHEN LEAVING I WAS BACKING UP AND WHILE BACKING UP I NOTICED A MAIL BOX STAND WITH 2 MAILBOXES ON A STEAL STAND. I DID NOT HAVE CONTROL ON STOPPING THE VEHICLE. I DID SOME DAMAGE ON THE REAR LEFT HAND SIDE OF MY CHEVY TAHOE. I CAREFULLY DROVE THE TAHOE TO MY HOME DOWN THE STREET, PARKED IT AND CALLED CHEVY ROAD SIDE SERVICE. I ALSO NOTICED THAT THE BREAK PEDAL MOVES SIDE TO SIDE AND THE BREAK LIGHTS STAY ON WHEN IN PARK. LUCKILY NOTHING HAPPENED TO MY FAMILY AND I ON OUR WAY HOME. OBVIOUSLY THE VEHICLE IS UNSAFE TO DRIVE.
NHTSA ODI #11063192
Official recalls
14Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Sep 7, 2018
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Consequence & remedy
Consequence: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
May 3, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Oct 9, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13, 2014. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.
Consequence & remedy
Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.
Nov 10, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
Consequence & remedy
Consequence: During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
Remedy: GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
Jun 27, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
Consequence & remedy
Consequence: If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
Additional source detail variants (2)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
Seat Belts:front:warning Light/devices
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Silverado vehicles manufactured May 23, 2013, through March 25, 2014, 2014 GMC Sierra vehicles manufactured May 25, 2013, through March 31, 2014, and 2015 Chevrolet Tahoe vehicles manufactured January 29, 2014, through March 27, 2014. In the affected vehicles, the tie rod threaded attachment may not be properly tightened to the steering gear rack.
Consequence & remedy
Consequence: An improperly tightened tie rod attachment may allow the tie rod to separate from the steering rack, resulting in a loss of steering, increasing the risk of a vehicle crash.
Remedy: GM notified all owners, and dealers will inspect the inner tie rods to make sure that they are correctly tightened, replacing the steering gear, as necessary, free of charge. The recall began on May 14, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14204. NOTE: Owners are advised not to drive their vehicles until they have been inspected and repaired. Owners should contact GM to have their vehicles towed to the dealership.
Mar 31, 2014
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission (feature code MYC). The subject vehicles may have a transmission oil cooler line that is not securely seated in the fitting.
Consequence & remedy
Consequence: If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
Remedy: GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration